Summary of the content on the page No. 1
INSTALLATION AND
OPERATION MANUAL
MODEL 2664 MODEL 2934 MODEL 3572
MODEL 2709 MODEL 2935 MODEL 3573
MODEL 2711 MODEL 2938 MODEL 3574
MODEL 2742 MODEL 2939 MODEL 3575
MODEL 2748 MODEL 2940 MODEL 3581
MODEL 2806 MODEL 2941 MODEL 3582
MODEL 2903 MODEL 2942 MODEL 3583
MODEL 2908 MODEL 2943 MODEL 3584
MODEL 2932 MODEL 2944 MODEL 6060
MODEL 2933 MODEL 2945 MODEL 7236
MODEL 3571
BATHTUBS, WHIRLPOOLS, AIR BATHS
AND COMBINATION TUBS WITH
OPTIONAL CHROMATHERAPY
THANK YOU...
for selecting an American St
Summary of the content on the page No. 2
TABLE OF CONTENTS: Cover................................................................................................Page 1 Table of Contents..............................................................................Page 2 Safety Instructions Notice.................................................................Page 3 Installation, Framing and Post Installation Clean-Up Instructions.......................................................................Page 4 Roughing-in References for Re
Summary of the content on the page No. 3
IMPORTANT SAFETY INSTRUCTIONS READ AND FOLLOW ALL INSTRUCTIONS! ! WARNING: Risk of personal injury. Do not permit children to use this bathtub without adult supervision. Never drop or insert any object into any opening. Do not operate this unit without the guard over the suction fitting. ! WARNING: Risk of electric shock. Do not permit electrical appliances near any bathtub when bathtub contains water. ! WARNING: Risk of hyperthermia and possible drowning. People using medications and/or having
Summary of the content on the page No. 4
Installation and Framing Instructions Each bath arrives ready for installation, completely equipped with the pump/blower electronics and plumbing necessary for operation. However, a drain/overflow kit is required for each bath and it is not included. The variety of installations for this bath may require framing procedures other than those shown. Locate studs as required. Ensure roughing-in dimensions are proper, plumb, and square. ! Remove the bath from the carton. Retain the shipping carto
Summary of the content on the page No. 5
ROUGH-IN REFERENCES FOR RECESS TYPE INSTALLATIONS C 12" (305 mm) E LEVELING NOTE: STRINGERS 24" FRONT EDGE (610 mm) OF BATH MUST BE SUPPORTED BY STUD WALL OR ACCESS PANEL MUST BE LOCATED AMERICAN STANDARD ON THE SAME SIDE AS THE MOTOR. APRON KIT ALLOW OPEN FRAMING ON PUMP/MOTOR END FOR SERVICE. ACCESS PANELS NOT REQUIRED FOR BATH TUBS UNLESS AN ACCESS OPENING OF AT LEAST 12" x 24" (305 x 610mm) IS PROVIDED, WARRANTY SERVICE WILL NOT BE PERFORMED. TYPICAL TILE BEAD INSTALLATION TYPICAL
Summary of the content on the page No. 6
ROUGH-IN REFERENCES FOR PIER TYPE INSTALLATIONS AS DESIRED F CUTOUT G CUTOUT C 12" (305 mm) AS DESIRED MOUNTING SURFACE WATERPROOF 24" SEALANT (610 mm) ACCESS PANEL MUST BE LOCATED BATH ON THE SAME SIDE AS THE MOTOR. ALLOW OPEN FRAMING ON PUMP/MOTOR END FOR SERVICE. ACCESS PANELS NOT REQUIRED FOR BATH TUBS UNLESS AN ACCESS OPENING OF AT LEAST 12" X 24" (305 X 610mm) IS PROVIDED, WARRANTY SERVICE WILL NOT BE PERFORMED. UNDER DECK MOUNTING INSTRUCTIONS Please note that care must be taken to
Summary of the content on the page No. 7
SPECIFICATIONS: L W J H C A SIDE VIEW END VIEW DRAIN / OVERFLOW B GENERAL SPECIFICATIONS FOR WHIRLPOOLS AND BATH TUBS Description Dimensions Drain / Height to Cut Out Rough-In Tub Edge to Weight with Product Gallon to Whirlpool L-W-H Overflow Underside Pier Recess Centerline Water / Floor Weight Overflow Operating of Deck: C G x F E x D Overflow: J Loading Volume 2664 L 83-1/2" (2121mm) A 16" C 18-1/4" Template N/A 6-3/8" 781 lb. (351 kg)/ 94 lb. 80 gal. 58 gal. W 63-3/4" (1619mm) Scala (406
Summary of the content on the page No. 8
ROUGH-IN REFERENCES MODEL SERIES 2664 1" (25mm) INTEGRAL TILE FLANGE (2) SIDES PROVIDE ACCESS 10" x 10" TO PUMP (254mm x 254mm) SERVING ON DRAIN OUTLET ALL INSTALLATIONS CUTOUT 21-3/4" (552mm) 8-1/2" (216mm) 3/4"(19mm) CUTOUT DIMENSION 16" (406mm) C OF DRAIN OUTLET L 41" (1041mm) MODEL SERIES 2709 69-1/4" (1759mm) 9-7/16" OUTLINE OF (240mm) CUTOUT 12" (305mm) x 9" (229mm) CUTOUT IN FLOOR FOR DRAIN 38-1/2" (978mm) 19-1/4" (489mm) PROVIDE ACCESS 3" TO PUMP (76mm) SERVING ON ALL INSTALLATIONS CO
Summary of the content on the page No. 9
ROUGH-IN REFERENCES MODEL SERIES 2711 72" (1829mm) OUTLINE OF CUTOUT 4" 36-1/2" 70-1/2" X 46-1/2" (102mm) (927mm) (1791 X 1181mm) 12" (305mm) C/L OF DRAIN 9" x 14" (229 x 356mm) 48" FLOOR (1219mm) CUTOUT PROVIDE ACCESS TO PUMP SERVING ON ALL INSTALLATIONS GRAB BAR OPTIONAL RECOMMENDED FITTING AREA DECK FITTING FITTING AREA LOCATION 2-1/2" X 11" MODEL SERIES 2908 66" 13" (1676mm) (330mm) 18" 9" X 12" (457mm) (229 x 305mm) FLOOR 36" CUTOUT (914mm) 2-1/2" REF. INTEGRAL PROVIDE ACCESS (64mm) FIT
Summary of the content on the page No. 10
ROUGH-IN REFERENCES MODEL SERIES 2806 72" (1829mm) 11" (279mm) 18" (457mm) 9" x 13" (229 x 330mm) FLOOR CUTOUT 35-3/4" (908mm) INTEGRAL FITTING DECK PROVIDE ACCESS TO PUMP SERVING ON ALL INSTALLATIONS 5-1/2" C/L OF DRAIN OUTLINE (140mm) OF CUTOUT OVERFLOW MODEL SERIES 2903 60" (1524mm) 9-1/2" OUTLINE OF (241mm) CUTOUT - USE TEMPLATE 4-1/4" 12" (305mm) X 9"(229mm) (1073mm) CUTOUT IN FLOOR FOR DRAIN 21-1/8" (537mm) PROVIDE ACCESS TO PUMP SERVING ON ALL INSTALLATIONS 3" (76mm) C OF DRAIN L OUTLET
Summary of the content on the page No. 11
ROUGH-IN REFERENCES MODEL SERIES 2742 71-1/2" 4" (1816mm) (102mm) INTEGRAL 35-3/4" FITTING DECK (908mm) 3" 13-1/4" 3" x 14" (76mm) (337mm) C/L OF DRAIN OUTLET (76 x 356mm) EDGE OF FLOOR CUTOUT 41-3/4" FLOOR CUTOUT 26-3/4" (1060mm) 5" X 15" (679mm) (127 X 381mm) PROVIDE ACCESS 3/4" TO PUMP (19mm) SERVING ON ALL INSTALLATIONS OUTLINE OF CUTOUT 70" X 40-1/4" (1778 X 1022mm) MODEL SERIES 2748 59-1/2" (1511mm) INTEGRAL 3" FITTING DECK 29-7/8" (76mm) 5-1/4" 3" X 14" (759mm) (133mm) (76 X 356mm) 14-1/
Summary of the content on the page No. 12
63-3/16" (1605mm) 54-1/2" (1384mm) ROUGH-IN REFERENCES MODEL SERIES 6060 76-3/4" REF. (1949mm) 38-3/8" (975mm) OUTLINE OF C/L CUTOUT SEAT AREA 65-3/8" (1661mm) 7" x 15" CUTOUT (178mm x 381mm) PROVIDE ACCESS TO PUMP FOR SERVICE ON ALL INSTALLATIONS NOTE: APRON ASSEMBLY WILL 13-5/8" PROVIDE REQUIRED (346mm) ACCESS FOR SERVICING C/L OF 5-5/8" RECOMMENDED FITTING LOCATION 10" (143mm) DRAIN 2-1/2" x 15" (64 x 381mm) (254mm) 4-1/2" (114mm) USE CUTOUT TEMPLATE SUPPLIED WITH PACKAGED PRODUCT. MODEL S
Summary of the content on the page No. 13
SPECIFICATIONS: L W J H C A SIDE VIEW END VIEW DRAIN / OVERFLOW B GENERAL SPECIFICATIONS FOR STUDIO 5' X 32" WHIRLPOOLS AND BATH TUBS Description Deck Dimensions Drain / Height to Cut Out Rough-In Tub Edge to Weight with Product Gallon to Whirlpool Trim L-W-H Overflow Underside Pier Recess Centerline Water / Floor Weight Overflow Operating Option of Deck: C G x F E x D Overflow: J Loading Volume 2932 Zero L 59-1/2" (1511mm) A 17-3/4" C 21-7/8" 58" 59-11/16" 581 lb. (264 kg)/ 90 lb. 59 gal. 54
Summary of the content on the page No. 14
SPECIFICATIONS: L W J H C A SIDE VIEW END VIEW DRAIN / OVERFLOW B GENERAL SPECIFICATIONS FOR STUDIO 5' X 36" WHIRLPOOLS AND BATH TUBS Description Deck Dimensions Drain / Height to Cut Out Rough-In Tub Edge to Weight with Product Gallon to Whirlpool Trim L-W-H Overflow Underside Pier Recess Centerline Water / Floor Weight Overflow Operating Option of Deck: C G x F E x D Overflow: J Loading Volume 2934 Zero L 59-1/2" (1511mm) A 17-3/4" C 21-7/8" 58" 59-11/16" 686 lb. (311 kg)/ 95 lb. 71 gal. 64
Summary of the content on the page No. 15
SPECIFICATIONS: L W J H C A SIDE VIEW END VIEW DRAIN / OVERFLOW B GENERAL SPECIFICATIONS FOR STUDIO 5-1/2' X 36" WHIRLPOOLS AND BATH TUBS Description Deck Dimensions Drain / Height to Cut Out Rough-In Tub Edge to Weight with Product Gallon to Whirlpool Trim L-W-H Overflow Underside Pier Recess Centerline Water / Floor Weight Overflow Operating Option of Deck: C G x F E x D Overflow: J Loading Volume 2938 Zero L 65-1/2" (1664mm) A 17-3/4" C 21-7/8" 64" 65-11/16" 766 lb. (348 kg)/ 100 lb. 80 gal
Summary of the content on the page No. 16
SPECIFICATIONS: L W J H C A SIDE VIEW END VIEW DRAIN / OVERFLOW B GENERAL SPECIFICATIONS FOR STUDIO 6' X 36" WHIRLPOOLS AND BATH TUBS Description Deck Dimensions Drain / Height to Cut Out Rough-In Tub Edge to Weight with Product Gallon to Whirlpool Trim L-W-H Overflow Underside Pier Recess Centerline Water / Floor Weight Overflow Operating Option of Deck: C G x F E x D Overflow: J Loading Volume 2940 Zero L 71-1/2" (1816mm) A 17-3/4" C 21-7/8" 70" 71-11/16" 846 lb. (384 kg)/ 105 lb. 89 gal. 81
Summary of the content on the page No. 17
SPECIFICATIONS: L W J H C A SIDE VIEW END VIEW DRAIN / OVERFLOW B GENERAL SPECIFICATIONS FOR STUDIO 6' X 42" WHIRLPOOLS AND BATH TUBS Description Deck Dimensions Drain / Height to Cut Out Rough-In Tub Edge to Weight with Product Gallon to Whirlpool Trim L-W-H Overflow Underside Pier Recess Centerline Water / Floor Weight Overflow Operating Option of Deck: C G x F E x D Overflow: J Loading Volume 2942 Zero L 71-1/2" (1816mm) A 17-3/4" C 21-7/8" 70" 71-11/16" 943 lb. (428 kg)/ 110 lb. 100 gal. 9
Summary of the content on the page No. 18
SPECIFICATIONS: L W J H C A SIDE VIEW END VIEW DRAIN / OVERFLOW B GENERAL SPECIFICATIONS FOR STUDIO CORNER WHIRLPOOLS AND BATH TUBS Description Deck Dimensions Drain / Height to Cut Out Rough-In Tub Edge to Weight with Product Gallon to Whirlpool Trim L-W-H Overflow Underside Pier Recess Centerline Water / Floor Weight Overflow Operating of Deck: C G x F E x D Overflow: J Loading Volume 2944 Zero N/A 988 lb. (448 kg)/ 130 lb. 103 gal. 65 gal. L 83-15/16" (2132mm) A 15" C 20-7/8" Studio (5/8")
Summary of the content on the page No. 19
SPECIFICATIONS: L W J H C A SIDE VIEW END VIEW DRAIN / OVERFLOW B GENERAL SPECIFICATIONS FOR STUDIO CORNER WHIRLPOOLS AND BATH TUBS Description Deck Dimensions Drain / Height to Cut Out Rough-In Tub Edge to Weight with Product Gallon to Whirlpool Trim L-W-H Overflow Underside Pier Recess Centerline Water / Floor Weight Overflow Operating of Deck: C G x F E x D Overflow: J Loading Volume 2945 N/A A 15-3/4" C 22-1/2" N/A 60-3/16" 597 lb. (271 kg)/ 57 lb. 54 gal. N/A L 60" (1524mm) 45 lb./sq.ft.
Summary of the content on the page No. 20
SPECIFICATIONS: L W J H C A SIDE VIEW END VIEW DRAIN / OVERFLOW B GENERAL SPECIFICATIONS FOR GREEN TEA WHIRLPOOLS AND BATH TUBS Description Dimensions Drain / Height to Cut Out Rough-In Tub Edge to Weight with Product Gallon to Whirlpool L-W-H Overflow Underside Pier Recess Centerline Water / Floor Weight Overflow Operating of Deck: C G x F E x D Overflow: J Loading Volume L 60" (1524mm) 3571 A 16" C 19" 58-1/2" 60-3/16" 3-1/2" 519 lb. (236 kg)/ 86 lb. 52 gal. 38 gal. W 36" (914mm) Green Te
