Summary of the content on the page No. 1
Operator’s Manual
®
2-Cycle
2-in-1 PLUS TRIMMER / BLOWER
®
GAS WEEDWACKER
Model No. 316.791920
with
• SAFETY
• ASSEMBLY
• OPERATION
• MAINTENANCE
• PARTS LIST
• ESPAÑOL, P. 15
CAUTION: Before using
this product, read this
manual and follow all
safety rules and operating
instructions.
Sears, Roebuck and Co., Hoffman Estates, IL 60179, U.S.A.
Visit our website: www.sears.com/craftsman
769-01969
Summary of the content on the page No. 2
RULES FOR SAFE OPERATION SPARK ARRESTOR NOTE CALIFORNIA PROPOSITION 65 WARNING NOTE: For users on U.S. Forest Land and in the states of California, Maine, Oregon and Washington. All U.S. Forest WARNING Land and the state of California (Public Resources Codes 4442 and 4443), Oregon and Washington require, by law that certain THE ENGINE EXHAUST FROM THIS PRODUCT internal combustion engines operated on forest brush and/or CONTAINS CHEMICALS KNOWN TO THE STATE OF grass-covered areas be equipped with
Summary of the content on the page No. 3
RULES FOR SAFE OPERATION • Use the unit only in daylight or good artificial light. this tool that are sold by Sears or a Craftsman outlet. Use of any replacement parts or accessories purchased elsewhere • Avoid accidental starting. Be in the starting position whenever pulling the starter rope. The operator and unit must may be hazardous, and will also void your warranty. be in a stable position while starting. Refer to • Keep unit clean of vegetation and other materials. They may Starting/Stoppi
Summary of the content on the page No. 4
WARRANTY STATEMENT TWO YEAR FULL WARRANTY ON CRAFTSMAN GAS TRIMMER When used and maintained according to the operator’s manual, if this gas trimmer fails due to a defect in material or workmanship within two years from the date of purchase, return it to any Sears store, other Craftsman outlet, or Sears Parts & Repair Center for free repair (or replacement if repair proves impossible). This warranty excludes cutting line, spark plug and air filter, which are expendable parts that can wear out fro
Summary of the content on the page No. 5
ASSEMBLY INSTRUCTIONS KNOW YOUR TRIMMER INSTALL AND ADJUST THE D-HANDLE On/Off Stop Control Fuel Cap Install Starter Rope 1. Place the D-handle down on to the shaft housing and the Grip bottom clamp so that the handle slants towards the shaft grip (Fig. 1). Place handle and clamp a minimum of 6 inches from Shaft Grip the end of the shaft grip. On/Off Stop Control (4) Screws Primer Shaft Bulb Housing D-Handle Shaft Grip Throttle Control Convertible™ Minimum 6 Inches Coupler (15.24 cm) Shift Shaf
Summary of the content on the page No. 6
OIL & FUEL INFORMATION CAUTION: For proper engine operation and WARNING: Add fuel in a clean, well ventilated maximum reliability, pay strict attention to the oil and outdoor area. Wipe up any spilled fuel immediately. fuel mixing instructions on the 2-cycle oil container. Avoid creating a source of ignition for spilt fuel. Do Using improperly mixed fuel can severely damage not start the engine until fuel vapors dissipate. the engine. WARNING: Gasoline is extremely flammable. Ignited vapors may
Summary of the content on the page No. 7
OPERATING INSTRUCTIONS HOLDING THE UNIT WARNING: Always wear eye, hearing, foot and body protection to reduce the risk of injury when operating this unit. Before operating the unit, stand in the operating position (Figs. 7–9). Check for the following: • The operator is wearing eye protection and proper clothing. • The right arm is slightly bent, and the hand is holding the shaft grip. • The left arm is straight, and the hand is holding the D- handle. • The unit is at waist level. • The trimmer/
Summary of the content on the page No. 8
OPERATING INSTRUCTIONS WARNING: Do not remove or alter the line cutting WARNING: Before you begin using any blade assembly. Excessive line length will make the attachment, read and understand the manual that clutch overheat. This may lead to serious personal came with the attachment. Follow all safety injury or damage to the unit. information contained within. 1. Remove the old line and line glide plate from the cutting WARNING: To avoid serious personal injury and head. Cutting damage to the u
Summary of the content on the page No. 9
MAINTENANCE & REPAIR INSTRUCTIONS MAINTENANCE SCHEDULE 3. Wash the filter in detergent and water WARNING: To prevent serious injury, never (Fig. 19). Rinse the filter Inside Muffler perform maintenance or repairs with unit running. thoroughly. Squeeze Cover Always service and repair a cool unit. Disconnect the out excess water. Allow spark plug wire to ensure that the unit cannot start. it to dry completely. Perform these required maintenance procedures at the 4. Apply enough clean SAE frequency
Summary of the content on the page No. 10
MAINTENANCE & REPAIR INSTRUCTIONS 5. Reinstall the spark arrestor screen by putting the “raised” REPLACING THE SPARK PLUG portion of the screen inside the recessed hole of the muffler. Use a Champion RDJ7Y spark plug or equivalent. Remove the Make sure that the spark arrestor screen fits flat against the plug after every 25 hours of operation and check its condition. muffler. 1. Stop the engine and allow it to cool. Grasp the plug boot firmly and pull it from the spark 6. Place the spark arrest
Summary of the content on the page No. 11
TROUBLESHOOTING PROBLEM SOLUTION ENGINE WILL NOT START Empty fuel tank Fill fuel tank with properly mixed fuel Primer bulb wasn't pressed enough Press primer bulb fully and slowly 10 times Engine is flooded Pull the starter rope Old or improperly mixed fuel Drain fuel tank and add fresh fuel mixture Fouled spark plug Replace the spark plug Plugged spark arrestor Clean or replace spark arrestor The outside temperature is below 40º F Pull the starter rope up to 10-15 times The outside temperature
Summary of the content on the page No. 12
Repair Protection Agreements Convenios de Cobertura de Gastos para Reparaciones Congratulations on making a smart purchase. Your new Felicidades por haber hecho una compra inteligente. Su nuevo ® Craftsman product is designed and manufactured for years of producto Craftsman está diseñado y fabricado para que opere de manera confiable durante años. Pero como todos los dependable operation. productos, pudiera necesitar una reparación cada cierto But like all products, it may require repair from ti
Summary of the content on the page No. 13
NOTES 13
Summary of the content on the page No. 14
NOTES 14
Summary of the content on the page No. 15
NORMAS PARA UNA OPERACION SEGURA PARACHISPAS INDICE DE CONTENIDOS NOTA: Para los usuarios en tierras forestales de los EE.UU. y en los estados de California, Maine, Oregon y Normas para una operación segura Página 16 Washington. Todos los terrenos forestales de los EE.UU. y el Garantía Página 18 estado de California (Códigos de Recursos Públicos 4442 y CARB / EPA Garantía Página 18 4443), Oregon y Washington, requieren por decreto, que Instrucciones de ensamble Página 19 ciertos motores de combu
Summary of the content on the page No. 16
NORMAS PARA UNA OPERACION SEGURA • IMPORTANTE INFORMACION DE SEGURIDAD • LEA TODAS LAS INSTRUCCIONES ANTES DE LA No fume mientras carga o mezcla el combustible. Limpie de OPERACION inmediato todo el combustible que se haya derramado. • Lea todas las instrucciones con cuidado. Conozca bien los • Evite crear una fuente de encendido por combustible controles y el uso correcto de la unidad. derramado. No arranque el motor hasta que se hayan disipado los vapores del combustible. • No opere esta un
Summary of the content on the page No. 17
NORMAS PARA UNA OPERACION SEGURA • Apague siempre el motor cuando demore el corte o mientras OTRAS ADVERTENCIAS DE SEGURIDAD camina entre zonas de corte. • No guarde nunca la unidad con combustible en el tanque en • Si golpea o se enreda con algún objeto extraño, apague el un edificio donde los gases puedan llegar a una llama abierta motor de inmediato y verifique si hay daños. Repare todos o a una chispa. los daños antes de volver a intentar operar la unidad. No • Espere que el motor se enfrí
Summary of the content on the page No. 18
NORMAS PARA UNA OPERACION SEGURA GARANTÍA LIMITADA POR DOS AÑOS EN EL RECORTADOR DE GASOLINA CRAFTSMAN Por dos años a partir de la fecha de compra, cuando se use y se dé mantenimiento a este Recortador según el manual del operador, Sears reparará cualquier defecto en material o mano de obra sin cargo alguno. Esta garantía excluye la bujía, el filtro de aire y la bolsa de la aspiradora, las cuales son piezas fungibles que se pueden gastar debido al uso normal en menos de dos años. Si este Recor
Summary of the content on the page No. 19
INSTRUCCIONES DE ENSAMBLAJE CONOZCA SU UNIDAD Tapa del Control de encendido INSTALACIÓN Y AJUSTE DE LA MANIJA EN D combustible y apagado Instalación Mango de la 1. Coloque la manija en D por encima del bastidor del eje y cuerda de sobre la abrazadera inferior (Fig. 1). Colóquela a un mínimo arranque de 15,24 cm (6 pulgadas) desde el extremo del puño del eje. Mango del Arranque/ Encendido (I) eje (4) Tornillos Bastidor Bombilla del eje del cebador Mango del eje Manija en D Mínimo de 15,24 cm C
Summary of the content on the page No. 20
INFORMACION DEL ACEITE Y DEL COMBUSTIBLE PRECAUCION: Para que el motor funcione ADVERTENCIA: Cargue el combustible en un área correctamente y con la mayor fiabilidad, preste exterior limpia y bien ventilada. Limpie de inmediato mucha atención a las instrucciones de mezcla de todo combustible que se haya derramado. Evite crear aceite y combustible del envase de aceite de 2 ciclos. una fuente de encendido con el combustible El uso de combustible mezclado en forma incorrecta derramado. No arranque
