Summary of the content on the page No. 1
MIXED FUEL
COOKER
ZCM 600 W
ZCM 610 X
INSTRUCTION BOOKLET
1
Please read this instruction booklet before using the appliance
Summary of the content on the page No. 2
Important Safety Information You MUST read these warnings carefully before installing or using the hob. If you need assistance, contact our Customer Care Department on 08705 727727 Installation l This cooker must be installed by qualified l When using other electrical appliances, ensure the personnel, according to the manufacturer’s cable does not come into contact with the hot instructions and to the relevant British Standards. surfaces of the cooker. • This cooker is heavy. Take care when movi
Summary of the content on the page No. 3
Contents For the User For the Installer Important Safety Information.............. 2 Instructions for the Installer ............. 22 Description of the Cooker.................... 4 Important Safety Requirements......... 23 Control Panel ...................................... 5 Installation........................................ 24 The Oven Cavity ................................... 5 Electrical connections ....................... 26 Accessories .......................................... 5 Commi
Summary of the content on the page No. 4
ST SET TIME OP Description of the Cooker Splash back (only in model ZCM 610 X) Semi-rapid Semi-Rapid burner burner Rapid burner Auxiliary burner Control panel Shelf Oven door Fitting the Splash back (only in model ZCM 610 X) A stainless steel splash back is supplied with the appliance. This is meant to be fitted on the rear edge of the cooker's hob. The splash back package is in the oven cavity. 1. Unpack the splash back and dispose of the packaging with due regard to safety and the environment.
Summary of the content on the page No. 5
Control Panel 1 2 BACK LEFT FRONT LEFT FRONT RIGHT BACK RIGHT OVEN FUNCTION TEMPERATURE OVEN PROGRAMMER MAINS ON THERMOSTAT IGNITION + PUSH - SET TIME STOP BOTH 3 4 5 6 7 8 9 10 1. Cooker Operation Pilot Light 2. Oven Thermostat Pilot Light 3. Electric ignition push button 4. Back left burner control knob (semi-rapid) 5. Front left burner control knob (rapid) 6. Front right burner control knob (auxiliary) 7. Back right burner control knob (semi-rapid) 8. Oven function control knob 9. Oven thermo
Summary of the content on the page No. 6
Operation INSTALLATION Any gas installation must be carried out by a CORGI registered installer, and in accordance with existing rules and regulations. The relevant instructions are to be found in the second section of this manual. Please ensure that when the appliance is installed, it is easily accessible for the engineer in the event of a breakdown. WHEN THE COOKER IS FIRST INSTALLED Once the cooker has been installed, it is important to remove any protective materials, which were put on in th
Summary of the content on the page No. 7
200 Electric Oven OFF Oven Function Control Knob Oven Light - The oven light will be on without any cooking function 0 Defrost Setting - This setting is intended to assist in thawing of frozen food (see page 15). Fan cooking - This allows you to roast or roast and bake simoultaneously using any shelf, without flavour transference. Grill - The heat comes only from the top element. Thermostat Control Knob OFF Turn the thermostat control knob clockwise to select temperatures between 50°C and 250°C
Summary of the content on the page No. 8
24 Hour Clock and Timer 1. ( - ) DECREASE CONTROL & TIMER SETTING BUTTON 2. ( + ) INCREASE CONTROL + - PUSH ( ) COOKPOT SYMBOL SET TIME STOP BOTH ( ) PUSH BOTH CLOCK SETTING SYMBOL 12 1. SET THE TIME OF DAY When the electricity supply is first switched ON, the display will flash 0.00. See Fig. 1. + - PUSH SET Press buttons (1) and (2) together. The display will TIME STOP BOTH Fig. 1 momentarily read 88.88. See Fig. 2. Release buttons, 0.00 will appear in the display as Fig. 3. Within 5 seco
Summary of the content on the page No. 9
2. THE TIMER IMPORTANT The timer can be used to time a set cooking period. At the end of the cook time the timer will - + PUSH automatically switch off the oven if in use. SET TIME The timer gives an audible reminder at the end of any STOP BOTH Fig. 6 period of cooking up to 23 hours and 59 minutes. To set, press button (1) and the display will read , see Fig. 6. 0 . 00 Release button (1) and press and hold button (2). The display will count up in one minute intervals until the interval to be t
Summary of the content on the page No. 10
Before the First Use of the Cooker Remove all packaging, both inside and outside the cooker, before using it. Before first use, the oven should be heated without food. During this time, an unpleasant odour may be emitted. This is quite normal. 1. Set the electronic timer to manual + function. 2. Switch the oven function control knob to fan cooking . 3. Set the thermostat control knob to MAX. 4. Open a window for ventilation. 5. Allow the oven to run empty for approximately 45 minutes. This proce
Summary of the content on the page No. 11
i Hints and Tips Condensation and steam When food is heated it produces steam in the same way as a boiling kettle. The oven vents allow some of this steam to escape. However, always stand back from the oven when opening the oven door to allow any build up of steam or heat to release. If the steam comes into contact with a cool surface on the outside of the oven, e.g. a trim, it will condense and produce water droplets. This is quite normal and is not a fault with the oven. To prevent discolorati
Summary of the content on the page No. 12
Using the Fan Oven The air inside the oven is heated by the element around the fan situated behind the back panel. The fan circulates hot air to maintain an even temperature inside the oven. The advantages of cooking with this function are: 3 Faster Preheating As the fan oven quickly reaches temperature, it is not usually necessary to preheat the oven although you may find that you need to allow an extra 5-7 minutes on cooking times. For recipes which require higher temperatures, best results a
Summary of the content on the page No. 13
Cooking Chart This chart is intended as a guide only. It may be necessary to increase or decrease the temperature to suit your individual requirements. Only experience will enable you to determine the correct setting for your personal requirements. Food Thermostat Runner Time Position Biscuits, cookies 2 trays 160-190 1-3 18-25 min. Bread, yeast doughs 2 trays 170-200 1-3 35-45 min. Cakes, Victoria sandwich 2 trays 160-170 1-3 20-28 min. Choux pastry, eclairs 2 trays 170-200 1-3 30-35 min. Fruit
Summary of the content on the page No. 14
i Hints and Tips Runner positions are not critical, but make sure the shelves are evenly spread. When cooking more than one dish in the fan oven, place dishes centrally on the shelves rather than several dishes on one shelf. When the oven is full, you may need to allow slightly longer cooking time. A shelf may be placed on the floor of the oven. Place dishes on a shelf in this position rather than on the oven base, to allow air circulation around the food. When the oven is full of the same food,
Summary of the content on the page No. 15
Defrosting The oven fan operates without heat and circulates the i Hints and Tips air, at room temperature, inside the oven. This increases the speed of defrosting. However, please note that the temperature of the kitchen will influence • Cover food with a lid, aluminium foil or plastic the speed of defrosting. film to prevent drying out during defrosting. This function is particularly suitable for delicate food • ALWAYS COOK THOROUGHLY which could be damaged by heat, e.g. cream filled IMMEDIAT
Summary of the content on the page No. 16
Grilling Grilling must be carried out with the oven Conventional Grill Food door closed. The grill pan handles must be Time (Min) removed from the pan. Bacon rashers 2-3 each side Beefburgers 6-10 each side How to Use the Grill + 1. Turn the oven control function knob to . Chicken joints 10-15 each side 2. Turn the thermostat control knob on the required Chops: 7-10 each side lamb temperature. pork 10-15 each side 3. Adjust the grid and grill pan runner position to Fish: whole trout/herring 8-
Summary of the content on the page No. 17
Maintenance and Cleaning Before any maintenance or cleaning can be carried out, you must DISCONNECT the cooker from the electricity supply. The Hob Top The hob is best cleaned whilst it is still warm, as spillage can be removed more easily than if it is left to cool. Regularly wipe over the hob top using a soft cloth well wrung out in warm water to which a little wasing up liquid has been added. Avoid the use of the following: - household detergent and bleaches; - impregnated pads unsuitable for
Summary of the content on the page No. 18
Cleaning the Oven Before cleaning always allow the cooling fan to cool the oven down before switching off at the electricity supply. The oven should be kept clean at all times. A build-up of fats or other foodstuffs could result in a fire, especially in the grill pan. Cleaning materials Before using any cleaning materials on your oven, check that they are suitable and that their use is recommended by the manufacturer. Cleaners that contain bleach should NOT be used as they may dull the surface f
Summary of the content on the page No. 19
Oven Cavity The enamelled oven cavity is best cleaned whilst the oven is still warm. Wipe the oven over with a soft cloth soaked in warm soapy water after each use. From time to time it will be necessary to do a more thorough cleaning, using a proprietary oven cleaner. If the soilage has become set, after the oven has cooled down, the following process will help to soften the splatters to help make cleaning easier. 1. Place the grill/ meat pan on the oven shelf + positioned in the lowest runner.
Summary of the content on the page No. 20
Something not working If the aplliance is not working correctly, please carry out the following checks, before contacting your local Zanussi Service Centre. IMPORTANT: If you call out an engineer to a fault listed below, or to repair a fault caused by incorrect use or installation, a charge will be made even if the appliance is under guarantee. SYMPTOM SOLUTION n There is no spark when lighting the gas u Check that the unit is plugged in and the electrical supply is switched on u Check that
