Summary of the content on the page No. 1
AGA-HEARTLAND | 1050 FOUNTAIN STREET NORTH | CAMBRIDGE, ON N3H4R7 | CANADA
PHONE. (877) 650-5775 | FAX. (519) 650-3773 | WWW.HEARTLANDAPP.COM | WWW.AGA-
RANGES.COM
MODEL 9200/7200 GAS RANGE
Installation and Operating Instructions
Model 9200 Model 7200
Note: Please read these instructions thoroughly before attempting to install this unit.
Save these instructions for future use.
ATTENTION INSTALLER: Leave this manual with appliance.
These symbols on the name plate mean the product has been
design
Summary of the content on the page No. 2
WARNING If the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal injury or death. —FOR YOUR SAFETY— DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPOURS OR LIQUIDS IN THE VICINITY OF THIS APPLIANCE. * Do not use the range as a heater. * Do not heat unopened glass or metal containers in the oven. * Grease accumulation is the cause of many cooking fires. Clean the oven and broiler compart- ment regularly. * Do not attempt to ex
Summary of the content on the page No. 3
WARNING If the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal injury or death. WHAT TO DO IF YOU SMELL GAS!! • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a neighbour’s phone. Follow the gas supplier’s instructions. • If you cannot reach your gas supplier, call the fire department. Installation and service must be perf
Summary of the content on the page No. 4
Gas Models 9200/7200 CONSUMER WARRANTY ENTIRE PRODUCT – LIMITED ONE YEAR WARRANTY AGA-HEARTLAND warrants the replacement or repair of all parts, including gas components of this stove which prove to be defective in material or workmanship, with the exception of the painted or porcelain enamel finish or plated sur- faces, for one year from the date of original purchase. Such parts will be repaired or replaced at the option of Aga- Heartland without charge, subject to the terms and conditions set
Summary of the content on the page No. 5
TABLE OF CONTENTS 1. Assembly of Exhaust Hood to Range 6 26. Clock/Timer 22 2. Positioning the Range 6 27. Cooking Guide 23 3. Electrical Installation 7 28. Care and Cleaning 24 4. Exhaust Hood 8 29. Porcelain 24 5. Ventless Installation 8 30. Oven Cleaning 25 6. Vented Installation 8 31. Surface Burners 25 7. Installation of Ducting 9 32. Nickel Trim 26 8. Venting Safety Guidelines 10 33. Exhaust Hood 26 9. Gas Line Installation 10 34. Oven and Cabinet Light 26 10. Clearances
Summary of the content on the page No. 6
Assembly of Exhaust Hood to Range See the manual entitled "Cabinet Assembly Instructions for Gas, Electric, Combination and Wood Stoves" which is included with the cabinet . Figure 1 Positioning the Range 1. When the range is fully assembled, recheck all electrical connections especially between the exhaust hood and the back of the range. As well, check that all nuts and bolts have been tight- ened. 2. Ensure teflon gliders and flooring are clean. 3. Caution: On flooring with very rough surfaces
Summary of the content on the page No. 7
Electrical Installation THE MODEL 7200/9200 GAS RANGE MUST BE ELECTRICALLY GROUNDED IN COMPLIANCE WITH LOCAL CODES AND IN THE ABSENCE OF LOCAL CODES, WITH THE NATIONAL ELECTRICAL CODE ANSI/NFPA 70 “LAT- EST EDITION” IN THE U.S. OR THE CANADIAN ELECTRICAL CODE, PART I, CSA STANDARD C22.1 IN CANADA or YOUR NATIONAL ELECTRICAL CODE. Connect the female end of the power cord to the main power (male) receptacle at the rear of the stove. See page 10 for receptacle locations and figure 3 for receptacle
Summary of the content on the page No. 8
Exhaust Hood Your range is equipped with a two speed range hood that may be either vented directly to the outside, or may be installed ventless. A set of exhaust filters are included with your hood. The filters should be cleaned periodically in soapy water. Extras are available from your dealer or directly from Heartland Appliances Inc. Please order 4 or more filters at one time to save freight and handling charges. Phone your dealer for pricing and ordering instructions. Ventless Installation
Summary of the content on the page No. 9
Installation of Ducting Installation through an outside wall Remove air deflector (used for ventless operation only). Cut appropriate-sized hole through the wall directly behind the range hood outlet (see Figure 5, page 9), making sure no wall studs are cut. Push range into position. From outside of the house, measure distance from the siding to the range outlet. Cut duct pipe that length, plus 1" (25mm) for overlap into outlet. Attach vent hood to pipe. Caulk the back of vent hood and around pi
Summary of the content on the page No. 10
Venting Safety Guidelines Installation must be done in accordance with all local and national codes. Use only materials which conform to local codes in effect. Be sure power is disconnected before doing any electrical work. All duct work must be metal. Do not use plastic duct. The range hood should never be exhausted into a wall cavity or an attic where an accumulation of grease could become a fire hazard. When the installation is completed, turn on the fan and make sure that there are no obstru
Summary of the content on the page No. 11
Model 9200 APPLIANCES VENTING How to Steps How to Steps Appliance Clearances (see Page 13 for additional details): Option 1 - Ventless • Sides of stove to adjacent surfaces: 1/2” (1.5 cm) min installation: • Nickel trim to adjacent surfaces: 0” right and left • Requires no fur- • Rear clearance: 0” ther set up (cooking • Closet right side to cabinetry: 0” fumes are drawn • Top of counter to underside adjacent cabinetry: 18” (46 cm) through pre-installed • Cooktop to underside overhead
Summary of the content on the page No. 12
Model 9200 Dimensions 3-7/8” Range HoodOutlet (10 cm) 13-3/4” 3 1/4” x 10” 27-1/2” 11-3/8” cresting (35 cm) 8 cm x 25 cm (70 cm) (29 cm) panel 14” (36 cm) 56” 29-1/2” (142 cm) (75 cm) Gas Inlet-1/2” NPT 66-1/4” 62-3/8” (168 cm) 43-3/4” (159 cm) (111 cm) with oven Exhaust 62-3/8” 36-1/8” Power 0” clearance 36-1/8” Hood door open Cord (92 cm) (female) (159 cm) to the back (92 cm) Receptacle 3” (7.6 cm) 34” (86 cm) 29-3/4” 52” 28” (76 cm) (133 cm) (72 cm) 3-3/4” 29-3/4” with bottom drawer full
Summary of the content on the page No. 13
Model 7200 APPLIANCES VENTING How to Steps How to Steps Appliance Clearances (see Page 15 for additional details): • Sides of stove to adjacent surfaces: 1/2” (1.5 cm) min • Nickel trim to adjacent surfaces: 0” right and 1” (2.5 cm)left Option 1 - Ventless • Rear clearance: 0” installation: • Closet right side to cabinetry: 0” • Requires no fur- • Top of counter to underside adjacent cabinetry: 18” (46 cm) ther set up (cooking • Cooktop to underside overhead cabinets: 30-1/4” (77 cm) f
Summary of the content on the page No. 14
Model 7200 Dimensions 3-7/8” Range Hood (10 cm) 37-3/4” 11-3/8” Outlet Cresting (29 cm) (96 cm) 3-1/4” x 10” 20” Panel (8cm x 25cm) (51 cm) 14” (36 cm) 4-3/4” (12 cm) 29-1/2” 56” Gas Inlet 1/2” NPT (75 cm) (142 cm) 66-1/4” Power 43-3/4” 62-3/8” 36-1/8” (169 cm) Cord (111 cm) (159 cm) (92 cm) 36-1/8” with oven 0” clearance (92 cm) door open Exhaust Hood to the back 30” (female) 3” (7.6 cm) (76 cm) Receptacle 39-3/4” 28” 39-3/4” 52” (101 cm) 47-1/2” (101 cm) (133 cm) (72 cm) (121 cm) with bot
Summary of the content on the page No. 15
Important Safety Instructions 1. PROPER INSTALLATION—BE SURE YOUR APPLIANCE IS PROPERLY INSTALLED AND GROUNDED BY A QUALIFIED TECHNICIAN. 2. NEVER use this appliance as a space heater to heat or warm the room. Doing so may result in Carbon Monoxide poisoning and in overheating of the oven. 3. Do not leave children alone. Children should not be left alone or unattended in area where appliance is in use. They should never be allowed to sit or stand on any part of the appliance. 4. Wear proper ap
Summary of the content on the page No. 16
Features I A D B C E F H G Figure 13 Cooking Controls The cooking controls are located on the right hand side of the cooktop; these controls offer an infinite number of heat settings for ease and accuracy in cooking and baking. Sealed Burner Features (see fig. 13) A) Centre Burners - are two maximum 8,000 BTU (2.34 kW)(L/P 7,000 BTU) with simmer of 600 BTU (.2 kW) sealed gas burners, easy clean, for medium duty cooking tasks. B) Right Burners (48" models only) - front sealed burner is maximum 1
Summary of the content on the page No. 17
J M K L Figure 14 Oven Features E) Oven Temperature Control - With infinite bake temperature and broil control. All units feature "auto gas shutoff", which means that if for any reason the flame goes out, gas to the oven burner shuts off! F) Gas Oven Features: -4 position racking -3.6 cubic feet of energy efficient area -16,500 BTU (4.83Kw) oven burner 2 - 380in cooking area in broiling drawer G) Broiler - Broiler drawer located under the oven, glides open for easy access, for all your broilin
Summary of the content on the page No. 18
Control Panel Layout The control panel is laid out in a straight line and each control is identified by a graphic on the right side of the knob. Model 7200 Model 9200 Control Panel Control Panel Left Rear Burner Control (Medium) Left Rear Burner Left Front Burner Control (Medium) Control (Large) Centre Rear Burner Right Rear Burner Control (Medium) Control (Medium) Centre Front Burner Left Front Burner Control (Medium) Control (Large) Right Rear Burner Control (Medium) Right Front Burner Contro
Summary of the content on the page No. 19
OPERATION Top Burner Operation Lighting the Top Burners Your range is equipped with a spark ignition system that is electrically operated. You need only to push in and turn the knob to any position and the burner will light. When you turn the knob, you will hear a distinct clicking noise. After the burner lights, the clicking noise will stop. Note: when lighting any one burner, all burners will spark, but only the burner that you have selected will light. All models feature "auto-reignition", w
Summary of the content on the page No. 20
Oven Cooking Oven Lighting Open oven door. There are 2 holes in the oven bottom so you can view the oven flame. Push in and hold down the oven knob and select the desired oven temperature. You should hear sparking until the oven flame ignites. You must continue to keep oven knob depressed for 5-6 seconds after the oven ignition has occurred. The extra 5-6 seconds is to heat up the safety thermocouple to allow proper oven control. (releasing the knob too early will extinguish the flame.) All unit
