Summary of the content on the page No. 1
GAS COOKER
ZCG 531
INSTRUCTION BOOK
GB
Summary of the content on the page No. 2
2
Summary of the content on the page No. 3
CONTENTS Instructions for the User Instructions for the Installer Warnings 4 Technical Features 18 Use and care 5 Advice for safety 19 Gas connection 19 Use of the appliance 6 Electrical connections 20 Using the Oven 6 Using the Grill 8 Installation 21 Using the Hob 10 Gas connection 22 Hints and tips 12 Conversion of gas 24 Maintenance and cleaning 13 Oven bulb replacement 14 Something Not Working 15 Service and spare parts 16 Guarantee Conditions 17 How to read the instruction book ? The symbo
Summary of the content on the page No. 4
IMPORTANT SAFETY INFORMATION You MUST read these warnings carefully before installing or using the appliance. If you need assistance, contact our Customer Care Department on 08705 950950. Installation • The grill pan will become hot during use, • This cooker must be installed by qualified personnel, according to the manufacturer’s always use oven gloves when removing or replacing a hot grill pan. instructions and to the relevant British Standards. • Ensure the control knobs are in the ‘OFF’ • T
Summary of the content on the page No. 5
INSTRUCTIONS FOR THE USER USE AND CARE Control panel Model : ZCG 531 8 2 5 6 7 1 3 4 1. Back left burner control knob 5. Oven light 2. Front left burner control knob 6. Minute minder 3. Front right burner control knob 7. Oven/Grill burner control knob (selector) 4. Back right burner control knob 8. Ignition switch Hob 1 4 2 3 1. Back left burner (auxiliary) 3. Front right burner (semi-rapid) 2. Front left burner (rapid) 4. Back right burner (semi-rapid) 5
Summary of the content on the page No. 6
USE OF APPLIANCE Before the First Use of the Cooker Remove all packaging both inside and outside of the cooker, before using it. Before first use, the oven should be heated without food. During this time, an unpleasant odour may be emitted. This is quite normal. 1. Remove the oven accessories and ensure all packaging has been removed. 2. Ignite the oven burner (see instructions) and turn the control knob to maximum. 3. Open a window for ventilation. 4. Allow the oven to run empty for approximate
Summary of the content on the page No. 7
Ignition Attention: when turning on the oven and grill burner the oven door has to be opened. • Open the oven door, push and turn the control knob to the left to position 8, keeping the control knob pressed. • At the same time, push the electronic ignition knob (see fig). Keep it pushed until the gas ignites (1 spark / second). • Release the knob after 10 seconds and check that the burner is ignited through the holes in the burner cover. OR During a power cut • Open the oven door, push and turn
Summary of the content on the page No. 8
Using the Grill When grilling, the accessible parts of the A appliance are hot and the appliance should not be left unattended. Take care that children do not play near it. While the grill is operating leave the oven door half open and put the grill deflector “A” into place. Grill burner ignition Attention: when turning on the oven and grill burner the oven door has to be opened. • Open the oven door push and turn the control knob to the right to the “grill symbol” and keep the control knob pr
Summary of the content on the page No. 9
Heat comes from the top of the oven. It is suitable for grilling meat (beef bacon, pork bacon …) that remains tender, for toast or to brown dishes already cooked dishes. Grilling meat When using the grill it has to be supervised, the oven door opened and the grill deflector “A” in its place. • Prepare the meat to be grilled, lightly brush it with oil on both sides. • Place it on the roasting grid. 4 • Turn the oven/grill control knob to position “grill”. • Slide the roasting grid in the guide 4
Summary of the content on the page No. 10
Using the Hob The Hob Burners The symbol on the control panel shows which burner is operated by the knob. (See control panel). Off Maximum level Minimum level Use the maximum level for boiling and the minimum for simmering. Always choose positions between the minimum and maximum, never between maximum and off. Ignition of the burners • Push the knob and turn it left to the “large flame“ symbol. • At the same time, push the electronic ignition knob (see fig). Keep it pushed until the
Summary of the content on the page No. 11
For a correct ignition always keep the burner ring and the spark plugs clean. The following diameter pans can be used: Power Diameter (mm) Burner (kW) min. max. Rapid 3,00 160 280 Semi-Rapid 2,00 140 240 Auxiliary 1,00 120 180 Accessories delivered with the appliance The following accessories are supplied with your appliance. • Grill Deflector To be used when the grill is operation. • Shelf for placing dishes on (roast, pastry mounds) The dish should be put in the middle of the shelf to balance
Summary of the content on the page No. 12
Hints and Tips Condensation and steam • The thickness, the material and the colour of When food is heated it produces steam in the the pan will influence the cooking results. same way as a boiling kettle. The oven vents • When cooking, certain dishes increase in allow some of this steam to escape. However, volume, ensure the pan is large enough. always stand back from the oven when • To prevent fat dripping when roasting use tall opening the oven door to allow any build up of rim pans proportion
Summary of the content on the page No. 13
MAINTENANCE AND CLEANING The oven should be kept clean at all - Open the door completely. - Lift the two locking plates on the hinge arms times. A build-up of fats or other foodstuffs could result in a fire. to 170°; o Before cleaning, ensure all control - Partially close the door, to a 30 angle knobs are in the OFF position, and the - Lift the door and pull out. appliance has cooled completely. Before any maintenance or cleaning locking plates can be carried out, you must DISCONNECT the cooker
Summary of the content on the page No. 14
Hob After every use wipe with a soft cloth well wrung out in warm water to which a little washing up Burner cap liquid has been added, avoiding any leakage through the holes of the hob. Rinse and dry with a soft cloth. To remove more stubborn stains, wet and leave Burner to dissolve, do not scratch and avoid the use of ring abrasive or caustic products that could damage the enamel. Ignition Burners The burner caps and crowns can be removed for cleaning. Wash the burners caps and crowns using hot
Summary of the content on the page No. 15
SOMETHING NOT WORKING If the appliance is not working correctly, please carry out the following checks, before contacting your local Service Force Centre. IMPORTANT: If you call out an engineer to a fault listed below, or to repair a fault caused by incorrect use or installation, a charge will be made even if the appliance is under guarantee. Symptoms Solutions 1. No burner ignition Check that: • Gas supply is completely open • The position of gas pipe is correct • The burner is not wet • The b
Summary of the content on the page No. 16
SERVICE AND SPARE PARTS In the event of your appliance requiring service, or if you wish to purchase spare parts, please contact your local Service Force Centre by telephoning:- 08705 929929 Your telephone call will be automatically routed to the Service Force Centre covering your post code area. For the address of your local Service Force Centre and further information about Service Force, please visit the website at www.zanussi-electrolux.co.uk In-guarantee customers should ensure that the che
Summary of the content on the page No. 17
GUARANTEE CONDITIONS Standard Guarantee Conditions We Zanussi-Electrolux undertake that if, within 12 months of the date of the purchase, this Zanussi- Electrolux appliance or any part thereof is proved to be defective by any reason only of faulty workmanship or materials, we will, at our option, repair or replace the same FREE OF ANY CHARGE for labour, materials or carriage on condition that: • The appliance has been correctly installed and used only on the electricity supply stated on the rati
Summary of the content on the page No. 18
INSTRUCTIONS FOR THE INSTALLER TECHNICAL FEATURES Free standing Class 1 Hob Pan support Enamelled Front right burner Semirapid 2000 W Back right burner Semirapid 2000 W Front left burner Rapid 3000 W Back left burner Auxiliary 1000 W Hob ignition Spark Oven Gas Oven Oven burner power 3000 W Grill Gas Grill burner power 2000 W Oven lamp Lamp 25W type E14 Oven ignition Spark Cleaning Manual Cavity dimensions Height 267 mm Width 405 mm Depth 381 mm Oven volume 41,2 l Accessories Oven shelf Roasting
Summary of the content on the page No. 19
ADVICE FOR SAFETY Gas connections • Before installation ensure that the local distribution conditions (gas type and pressure) and the pre-setting of the appliance are consistent. • This appliance must be installed only in a room with good ventilation. • This appliance must not connected to a chimney. It has to be installed and connected in accordance with the rules in force. Special attention should be paid to the applicable disposal concerning ventilation. • The adjacent furniture panels have t
Summary of the content on the page No. 20
Electrical connections A cut off plug inserted into a 13 amp Any electrical work required to install socket is a serious safety (shock) hazard. this cooker should be carried out by a qualified electrician or competent person, in Ensure that the cut off plug is disposed of safety. accordance with the current regulations. THIS COOKER MUST BE EARTHED. The manufacturer declines any liability should these safety measures not be observed. This cooker is designed to be connected to a 230-240V AC 50Hz e
