Summary of the content on the page No. 1
SERVICE MANUAL
X1161/X1261/X1161A/X1161N/X110/H5360
Date Revise Version Description
2009.05.22 V1.0 Initial Issue
2009.06.25 V2.0 Modify Chapter 5
1. Add X1161’s extended models: X1161A, X1161N,X110
2009.08.06 V3.0 2. Update Engineering Spec. of Chapter 1
3. Modify Chapter 4
1. Add X1261’s extended models: H5360
2009.09.16 V4.0 2. Update Engineering Spec. of Chapter 1
3. Modify Chapter 4
Copyright September, 2009 All Rights Reserved P/N: 36.8CP01G001
SI : TSE: Check: Approved
Summary of the content on the page No. 2
Preface This manual is applied to X1161/X1261/X1161A/X1161N/X110/H5360 projection system. The manual gives you a brief description of basic technical information to help in service and maintain the product. Your customers will appreciate the quick response time when you immediately identify problems that occur with our products. We expect your customers will appreciate the service that you offer them. This manual is for technicians and people who have an electronic background. Please send
Summary of the content on the page No. 3
X1161/X1161A/X1161N/X110/X1261/H5360 Comparison List Models H5360 X1261 X1161 X1161A X1161N X110 Parts NAME LABEL 35.8ER02H001 35.8CQ03H001 35.8CP02H001 35.8CP07H001 35.8CP05H001 35.8CP10H001 MAIN BOARD 70.8ER17GR01 70.8CQ09GR01 70.8CP25GR01 70.8CP27GR01 70.8CP29GR01 70.8CP28GR01 DMD CHIP 48.8ER01G001 48.8CQ01G003 48.8EH01G001 IO COVER 70.8ER18GR01 70.8CQ08GR01 70.8CP23GR01 ENGINE 70.8ER15GR01 70.8CQ07GR01 70.8CP22GR01 SPEAKER 49.8CQ01G001 N/A LAMP BLOWER 49.8CS01G002 49.8CS
Summary of the content on the page No. 4
Table of Content Chapter 1 Introduction Highlight 1-1 Compatible Mode 1-5 Product Overview 1-9 Chapter 2 Disassembly Process & Assembly Process Equipment Needed & Product Overview 2-1 Disassemble Lamp Cover Module 2-2 Disassemble Lamp Module 2-2 Disassemble Top Cover Module 2-3 Disassemble Top Shielding 2-3 Disassemble Front Cover and IR Sensor Board 2-4 Disassemble Main B
Summary of the content on the page No. 5
Assemble Bottom Shielding 2-17 Assemble Interrupt Switch 2-17 Assemble Lamp Driver Module 2-18 Assemble LVPS Module 2-19 Assemble Blower 2-19 Assemble System Fan Module 2-20 Assemble Focus Ring 2-21 Assemble Zoom Ring 2-21 Assemble DMD Chip and DMD Board 2-22 Assemble Color Wheel Module 2-22 Assemble Engine Module 2-23 Assemble IO Cover and Main Board Module 2-23 Assemble IR Sensor Board and Front Cover
Summary of the content on the page No. 6
Calibration 4-7 Video Performance 4-9 Optical Performance Measure 4-10 Others 4-12 Chapter 5 Firmware Upgrade Equipment Needed 5-1 DLP Composer Lite Setup Procedure 5-2 USB Driver Upgrade Procedure (for X1161 only) 5-4 Firmware Upgrade Procedure 5-5 Waveform Download 5-8 Chapter 6 EDID Upgrade EDID Introduction 6-1 Equipment Needed 6-2 Setup Procedure (VGA) 6-3 EDID Key-In Pr
Summary of the content on the page No. 7
Chapter 1 Introduction 1-1 Highlight No Item Description 1 Dimensions (W x H x D) ● 268 mm x 192 mm x 80 mm 2 Weight ● <4.9 lbs 3 Tilt Angle ● 2.7 degree with elevator mechanism ● Universal AC 100 – 240 V ~ 50-60 Hz with PFC input 4 Power Supply ● Variance FAN speed control (Depends on temperature variant) 5 Keystone correction ● +/ -40 degree (80 degree) ● Advanced Air Flow ● Two fans with system 6 Cooling system ● Temperature control circuits with adaptive fan rotational speeds ● M
Summary of the content on the page No. 8
No Item Description ● Engineering spec: For X1161/X1161N/X1161A/X110: • 2500: 1 Full White with full power / full Black with eco power (Minimum; projection lens at tele mode) • 3600: 1 Full White with full power / full Black with eco power (Typical; projection lens at tele mode) For X1261: • 2100: 1 Full White with full power / full Black with eco power (Minimum; projection lens at tele mode) • 3300: 1 Full White with full power / full Black with eco 8 Co
Summary of the content on the page No. 9
No Item Description ● TI DMD 0.55” 12° 2xLVDS S450 SVGA Digital Mirror Device (for X1161/X1161N/X1161A/X110) ● TI DMD 0.55” 12° 2xLVDS S450 XGA Digital Mirror Device 16 TI DMD (for X1261) ● TI DMD 0.62” 12° S450 720p Digital Mirror Device (for H5360) ● 800(H) x 600(V) (for X1161/X1161N/X1161A/X110)) 17 Number of active dots ● 1024(H) x 768(V) (for X1261) ● 1280(H) x 720(V) (for H5360) ● 6 segments (R81Y41G84C31W52B71) (for (for X1 X1161/X1261/ 161/X1261/ X1161N/X1161A/X110) 1
Summary of the content on the page No. 10
No Item Description ● For X1161/1161A/X110: • VGA In * 1: One D-Sub 15-Pin Female Connector for PC input and analog Data ( Component i/p, HDTV, RGB Sync) • S-video * 1: One Mini DIN 4-Pin connector for S-Video Input Connector • Composite * 1: One RCA Jack for Composite Video Input Connector • USB * 1: One Type-B USB support F/W up-grade and reserve remote Page-Up and Page-Down function ● For X1161N: • VGA In * 1: One D-Sub 15-Pin Female Connector for PC
Summary of the content on the page No. 11
No Item Description ● Hsync Frequency 30~ 100 kHz ● Vsync Frequency 50~ 85 Hz ● Video Signal RGB (PC) • Analog RGB 0.7Vp-p, 75 ohm, Separate TTL H,V Sync • Analog RGB 1Vp-p, 75 ohm, Sync. On Green signal 22 Input signal spec. • Analog RGB 0.7Vp-p, 75 ohm, Composite TTL Sync. ● Video • Composite video 1Vp-p,75 ohm • S-video Luminance 0.714Vp-p, 75 ohm • Chrominance 0.286Vp-p, 75 ohm • Component Video 1Vp-p, 75 ohm ● Operating: • for 0 - 2500 ft, 5 - 35 °C 23 Temperature
Summary of the content on the page No. 12
Compatibility Resolution V.Frequency [Hz] H.Frequency [KHz] 1024 x 768 60 48.4 1024 x 768 70 56.5 XGA 1024 x 768 75 60.0 1024 x 768 85 68.7 1152 x 864 70 63.8 1152 x 864 75 67.5 1152 x 864 85 77.1 SXGA 1280 x 1024 60 64.0 1280 x 1024 72 77.0 1280 x 1024 75 80.0 1280 x 1024 85 91.1 1280 x 960 60 60.0 QuadVGA 1280 x 960 75 75.2 SXGA+ 1400 x 1050 60 65.3 UXGA 1600 x 1200 60 75.00 640 x 480 66.6(67) 34.9 800 x 600 60 37.9 Power Mac G4 1024 x 768 60 48.4 1152 x 870 75 68.7 1280 x 960 75 75.0 640 x 48
Summary of the content on the page No. 13
Compatibility modes (VGA Analog) (for H5360) Compatibility Resolution V.Frequency [Hz] H.Frequency [KHz] (1) VGA Analog - PC Signal 640 x 480 60 31.5 640 x 480 72 37.9 VGA 640 x 480 75 37.5 640 x 480 85 43.3 640 x 480 120 61.6 800 x 600 56 35.2 800 x 600 60 37.9 800 x 600 72 48.1 SVGA 800 x 600 75 46.9 800 x 600 85 53.7 800 x 600 120 77.2 1024 x 768 60 48.4 1024 x 768 70 56.5 XGA 1024 x 768 75 60.0 1024 x 768 85 68.7 1024 x 768 120 98.8 1152 x 864 70 63.8 1152 x 864 75 67.5 1152 x 864 85 77.1 SX
Summary of the content on the page No. 14
Compatibility Resolution V.Frequency [Hz] H.Frequency [KHz] (2) VGA Analog - Extended Wide timing 1280 x 768 60 47.8 1280 x 768 75 60.3 1280 x 768 85 68.6 WXGA 1280 x 720 60 44.8 1280 x 800 60 49.6 1366 x 768 60 47.71 WXGA+ 1440 x 900 60 55.9 WSXGA+ 1440 x 900 60 65.3 Horizontal scan rate 30k-100kHz Vertical scan rate 50-85Hz Max. pixel rate 170MHz Note: If the Compatibility modes supportive signal is different from User's Manual, please refer to User’s Manual. X1161/X1261
Summary of the content on the page No. 15
1-3 Product Overview Projector Outlook Front /Upper side Item Description Item Description 1 Ventilation (inlet) 6 Lens cap 2 Ventilation (outlet) 7 Power button 3 Remote control receivers 8 Remote control 4 Focus ring 9 Zoom lever 5 Zoom lens 10 Horn X1161/X1261/X1161A/X1161N/X110/H5360 Confidential 1-9
Summary of the content on the page No. 16
Rear side (for X1161/X1261/X1161A/X1161N/X110) Item Description Item Description 1 Power socket Below items are for X1261 only: 2 KensingtonTM lock port 4 S-Video input connector PC analog signal/HDTV/component video 3 5 Composite video input connector input connector (VGA IN 1 or VGA IN) PC analog signal/HDTV/component Below items are for X1161/X1161A/X110 6* only: video input connector (VGA IN 2) 4 S-Video input connector 7 RS232 connector Monitor loop-through output 5 Composite video input
Summary of the content on the page No. 17
Rear side (for H5360) Item Description Item Description 1 Power socket 6 YPbPr input connector 2 KensingtonTM lock port 7 S-Video input connector 3 RS232 connector 8 Composite video input connector PC analog signal/HDTV/component video 4 9 Audio input connector input connector (VGA IN 1 or VGA IN) 5 HDMI connector X1161/X1261/X1161A/X1161N/X110/H5360 Confidential 1-11
Summary of the content on the page No. 18
Remote Control and Control Panel Layout X1161/X1261/X1161A/X1161N/X110/H5360 Confidential 1-12
Summary of the content on the page No. 19
Item Icon Function Description Remote control 1 Receives signals from remote control. receiver 2 POWER Refer to the “Turning the Projector On/Off” section. • Press “MENU” to launch the Onscreen display (OSD) menu, back to the previous step for the 3 MENU OSD menu operation or exit the OSD menu. • Confirm your selection of items. 4 KeyPad 0~9 Press “0~9” to input a password in the “Security”. 5 KeyPad 0~9 To choose the desired aspect ratio (Auto/4:3/16:9). Automatically synchronizes the p
Summary of the content on the page No. 20
Getting Started Connecting the Projector Item Description Item Description 1 Power cord 6 S-Video cable 2 VGA cable 7 Audio cable jack/jack 3 Composite video cable 8 Audio cable jack/RCA 4 RS232 cable 9 USB cable Note: To ensure the projector works well with your computer, please make sure the timing of the display mode is compatible with the projector. X1161/X1261/X1161A/X1161N/X110/H5360 Confidential 1-14
