Summary of the content on the page No. 1
IMPORTANT: MAXIMUM COOLING CAPACITY
This Carry-On air conditioner is designed to cool a space of
approximately 90 square feet (Carry-On 5000) to 120 square feet
(Carry-On 7000). This is “below decks space.” This means that
there are no large windows, typical of powerboats, and the unit
will cool a “space/cabin” or a boat with the above dimensions. If you
have any questions, please call our customer service line at
888-452-0349 (Ocean Marketing).
Carry-On 7000 Portable A/C Units ❖ INSTALLATION •
Summary of the content on the page No. 2
Summary of the content on the page No. 3
Table of Contents Carry-On 7000 Portable Air Conditioners • Introduction Warnings .......................................................................................... 4 Dimensions & Hatch Size .................................................................4 Important Information .......................................................................4 Power Requirements ........................................................................ 4 Inverter/Generator Operation ................
Summary of the content on the page No. 4
Carry-On 7000 Portable Air Conditioners Introduction You have purchased a marine air conditioner that will add to Power Requirements your boating enjoyment. Please read the accompanying For 115 Volt Units (50/60Hz Operation) instructions to insure proper installation, operation and care. 115/60/1 dockside power Running amps: 6.9 A Warnings Starting amps: 21 A The use of the Carry-On™ is not recommended while the Minimum Voltage: 104 VAC boat is under way because of the potential for damage to
Summary of the content on the page No. 5
(c.) DANGER - SHOCK HAZARD! Do not, under any after operation in the COOL mode, WAIT 3 MINUTES circumstances, cut or remove the grounding prong from the BEFORE RESTARTING. This allows pressure inside the end of your power cord. Your Carry-On must be used with a compressor to equalize. Consequences of attempted restart three-prong grounding power cord and connected to a within the 3 minute period may be a tripped circuit breaker or properly grounded and polarized three prong receptacle. DO blow
Summary of the content on the page No. 6
Carry-On 7000 Portable Air Conditioners Installation Alternate Batten Pocket Batten Batten Pocket Figure 2. Close-up of Batten and Batten Pockets Figure 1. The Carry-On positioned in the boat hatch with the Hatch Bag in place. See inset Figure 2. 1. Place in open hatch as shown. (See 3a. Proper Positioning In Hatch Figure 5.) Adjust Carry-On so that the hatch pad protects and insulates the hatch and the Carry-On unit. Make sure that movement of Carry-On is stifled due to wedging action of the
Summary of the content on the page No. 7
use the alternative batten pockets, you must cut the battens to size. A more weathertight seal can be achieved if you adapt the hatch bag to your boat using a Velcro® brand Hatch Pad fastener, or snaps. Consult your marine dealer or canvas Air Filter shop if you need help. 4. Level unit with adjustable cam and leg. Adjust the leg until the indicator bubble is away from the side of the level. It is not necessary to exactly center the bubble. If your hatch location is such that the Carry-On cannot
Summary of the content on the page No. 8
AIR DEFLECTOR (Standard for Carry-On 7000 and 7020) Air Deflector changes the direction of the air flow from almost vertical to horizontal. Can be purchased from your dealer............................................ Part No. PL-0018 8 L-2245 English ❖❖❖❖❖
Summary of the content on the page No. 9
Carry-On 7000 Portable Air Conditioners Operation 1. Plug in Carry-On. 2. Set the thermostat at the coldest setting (fully clockwise). 3. Set the FAN/COOL selector at HI COOL. 4. Close all windows, vents, hatches, doors and exhaust fans in the area to be cooled by your Carry-On. 5. Once your cabin or boat has cooled, adjust the thermostat Figure 6. The Carry-On Control Panel and fan speed to suit your comfort level. Carry-On 7000 Portable Air Conditioners Operational Features Automatic Ther
Summary of the content on the page No. 10
Carry-On 7000 Portable Air Conditioners Cleaning & Storage For more stubborn cases: You may soak the Hatch Bag or Cleaning Instructions the Storage Cover for approximately twenty minutes in a Clean the Carry-On occasionally to keep it looking new and ® solution of no more than 1/2 cup (4 oz.) CLOROX and 1/4 operating properly. Be sure to unplug the Carry-On before cup IVORY or LUX SOAP per gallon of warm water. Rinse cleaning. thoroughly in cold water to remove all of the soap. Air Filter NOT
Summary of the content on the page No. 11
Carry-On 7000 Portable Air Conditioners Troubleshooting Before you call for service, review this list. It may save you time and expense. This list contains common occurrences that are not a result of defective workmanship or materials. Important: Boat must be closed so that outside air is prevented from access to the inside. Close all hatches and ventilators. Problem Possible Cause Action Unit will not operate 1. Plug disconnected from receptacle or unit 1. Connect firmly 2. Blown fuse or trip
Summary of the content on the page No. 12
Carry-On 7000 Portable Air Conditioners Parts List ATTENTION: Owners or Independent Service Companies: Use the following guide if replacement parts are required. Handle Body Bulkhead Cam Blocks Air Separator Cam with pin Pan Inlet/Outlet Leg Foot Hatch Pad Part No. Description Part No. Description 1013 .......... CO-Thermostat Air Temp (Ranco) 7010B ....... CO-Evap. Assembly 11.875 x 8 13FPI 3ROW 1014 .......... CO-Switch 2-SPD Short 7011 .......... CO-Condenser Assembly 1025 .......... CO-P
Summary of the content on the page No. 13
Owner’s Limited Warranty Air Conditioners As hereinafter described, Dometic Corporation (Dometic) limits the duration of any implied warranty to the duration of the express warranty provided herein and also disclaims any liability for consequential damages arising from any application, installation, use or malfunction of any warranted product. This warranty gives you, the purchaser, specific legal rights, Section I: What does the limited and you may also have other rights which vary from state t
Summary of the content on the page No. 14
Warning Dometic Corporation (Dometic) manufacturers of Cruisair, Grunert, Marine Air and from sewage holding tanks, or any other dangerous gas or vapor could exist. If an Sentry Products, makes the following safety warnings concerning the application, air handling unit is installed in such a manner that allows potentially lethal gases installation, use and care of its products. Although these warnings are extensive, or vapors to be discharged by the air handling unit into the living space, this
Summary of the content on the page No. 15
Summary of the content on the page No. 16
Dometic Corporation Environmental Systems 2000 N. Andrews Ave. Ext. Pompano Beach, FL 33069-1497 USA Phone: 954-973-2477 Facsimile: 954-979-4414 Website: www.marineair.com Email: sales@marineair.com P.O. Box 15299 Richmond, VA 23227-0699 USA Phone: 804-746-1313 Facsimile: 804-746-7248 Website: www.cruisair.com Email: sales@cruisair.com For Sales and Service Calls Within Europe and the Middle East, please contact +44 (0) 870 330 6101. L-2245
