Summary of the content on the page No. 1
HN System
Terrestrial Broadband Router
Installation Guide
Model: HN7700S
1037753-0001
Revision A
May 19, 2008
Summary of the content on the page No. 2
Revision record Revision Date of issue Scope A May 19, 2008 Initial release Copyright © 2008 Hughes Network Systems, LLC All rights reserved. This publication and its contents are proprietary to Hughes Network Systems, LLC. No part of this publication may be reproduced in any form or by any means without the written permission of Hughes Network Systems, LLC, 11717 Exploration Lane, Germantown, Maryland 20876. Hughes Network Systems, LLC has made every effort to ensure the correctness and co
Summary of the content on the page No. 3
Important safety information For your safety and protection, read this entire manual before you attempt to install the HN router. In particular, read this safety section carefully. Keep this safety information where you can refer to it if necessary. This section introduces the various types of warnings used in this Types of warnings used manual to alert you to possible safety hazards in this manual WARNING Indicates a potentially hazardous situation, which, if not avoided, could result
Summary of the content on the page No. 4
� Important safety information iv 1037753-0001 Revision A
Summary of the content on the page No. 5
Contents Important safety information . . . . . . . . . . . . . . . . . . . . . iii Types of warnings used in this manual . . . . . . . . . . . . . . . . . . . iii Chapter 1 Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1 Scope and audience . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1 HN router overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1 Router specifications . . . . . . . . . . . . . . . . . . .
Summary of the content on the page No. 6
Chapter 5 Commissioning the HN router . . . . . . . . . . . . . . . . . . . .19 Router connections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19 Commissioning procedures . . . . . . . . . . . . . . . . . . . . . . . . . . . .19 Changing from VSAT to router mode . . . . . . . . . . . . . . . . . . . .20 Terrestrial Broadband Setup page . . . . . . . . . . . . . . . . . . . . . . .22 Commissioning by auto selection. . . . . . . . . . . . . . . . . . . . . . . .24 Selectin
Summary of the content on the page No. 7
Chapter 8 Configuring the HN router for VADB backup . . . . . . .57 VADB overview. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .57 Requirements for VADB . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .58 Installing VADB. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .58 Verifying that the VADB profile is loaded . . . . . . . . . . . . . .59 Testing the telephone line. . . . . . . . . . . . . . . . . . . . . . . . . . . .60 Connecting
Summary of the content on the page No. 8
FCC Part 68 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .96 Ringer equivalence number (REN) . . . . . . . . . . . . . . . . . . . .97 Discontinuance of service. . . . . . . . . . . . . . . . . . . . . . . . . . . .97 Telephone Company changes. . . . . . . . . . . . . . . . . . . . . . . . .97 Repairs in the United States . . . . . . . . . . . . . . . . . . . . . . . . . .98 Canada – equipment attachment limitations. . . . . . . . . . . . . .98 Appendix E ADTRAN Tota
Summary of the content on the page No. 9
Figures Chapter 1 1. HN router . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2 Chapter 2 2. HN router components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6 Chapter 3 3. Attaching the router to the pedestal base . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10 4. AC/DC power supply . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12 5.
Summary of the content on the page No. 10
Chapter 6 29. Summary page . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .38 30. SDL Monitor page . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .39 31. System Status page . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .39 Chapter 7 32. Selecting settings option. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .42 33. Sett
Summary of the content on the page No. 11
64. Internet Protocol Properties - Windows XP . . . . . . . . . . . . . . . . . . . . . . . . . . . .74 65. Network and Dial-up Connections - Windows 2000 . . . . . . . . . . . . . . . . . . . . .75 66. Local Area Connection Properties - Windows 2000 . . . . . . . . . . . . . . . . . . . . .75 67. Internet Protocol Properties - Windows 2000 . . . . . . . . . . . . . . . . . . . . . . . . . .76 Appendix B 68. Saving the Fallback Updater utility . . . . . . . . . . . . . . . . . . . . . . . . . .
Summary of the content on the page No. 12
99. Setting the service. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .113 100. Mapping a DS0 port . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .114 101. Mapping multiple DS0s . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .114 102. Log out screen . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .115 103. Ping Far-End IP address
Summary of the content on the page No. 13
Tables Chapter 1 1. Specifications for the HN router. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2 Chapter 3 2. Available power supplies for the HN router. . . . . . . . . . . . . . . . . . . . . . . . . . . .11 Chapter 8 3. HN router LED appearance during VADB operation . . . . . . . . . . . . . . . . . . . .66 Appendix D 4. HN7700S standards compliance. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .93 Appendix E 5. ADTRAN front panel LEDs.
Summary of the content on the page No. 14
� Tables xiv 1037753-0001 Revision A
Summary of the content on the page No. 15
Chapter 1 Introduction This manual explains how to install, commission, and service the Hughes HN7700S as a Terrestrial Broadband Router (HN router). The manual also includes installation information for the DSL and T-1 transport methods used with the HN router. This chapter discusses the following topics: • Scope and audience on page 1 • HN router overview on page 1 • Router specifications on page 2 • Commissioning on page 3 • Installation and commissioning steps on page 4 The HN7700S has d
Summary of the content on the page No. 16
crossover Cat-5 cable to a single computer or to an Ethernet hub/switch port. It is completely self-contained requiring no external PC to host any functions or software. The software is automatically updated from the Network Operations Center. It also has an an internal modem (with telephone jack) to support the Virtual Private Network Automatic Dial Backup (VADB) feature. Figure 1: HN router Table 1 lists the specifications for the HN router. Router specifications Table 1: Specificatio
Summary of the content on the page No. 17
Table 1: Specifications for the HN router Safe operating 5 to 40°C (Above 5000 ft altitude, reduce maximum temperature by 1°C per temperature range 1000 ft) Safe operating 5% to 95% non-condensing humidity range Safe altitude 10,000 ft Cooling method Convection Main processor 300 MHz Main memory 64 Mbyte Flash memory 16 Mbyte Protocol support TCP/IP (Transmission Control Protocol / Internet Protocol) protocol suite Interfaces/ports � Two Ethernet ports supporting 10BaseT or 100BaseT operation,
Summary of the content on the page No. 18
The installation and commissioning of the HN router is a Installation and multi-step process involving two pieces of equipment—the HN commissioning steps router and the associated transport device. The workflow and chapter reference numbers for the process steps follow. 1. Preparing, installing, and commissioning the transport device a. ADTRAN Total Access 600R – Installing the ADTRAN 600R on page 100 – Connecting the ADTRAN on page 106 – Configuring the ADTRAN on page 107 – Confirming conn
Summary of the content on the page No. 19
Chapter 2 Preparing the HN router for installation This chapter discusses preparations you must make prior to installing the HN router and information you should know before beginning the installation. Note: Install your trasport device before installing the HN router. The appendices listed below give the installation instructions for the trasport devices. • Appendix E – ADTRAN Total Access 600R, on page 99 • Appendix F – Siemens 4100/4101 DSL Modem, on page 117 This chapter discusses the f
Summary of the content on the page No. 20
Items required for Ensure the HN router shipping carton contains the items shown in Figure 2. installation Cat-5 Ethernet cable Wall unit or In-line Warranty Pedestal base Power supply Wall unit or in-line unit Remote terminal Items provided in the remote terminal shipping carton terr.cfg file (if you are Installation specification or work order instructed to upload it) Items provided by the installer G-29716 C 05/19/08 Figure 2: HN router components You must confirm that your PC (the instal
