Summary of the content on the page No. 1
Hustler FasTrak
36" & 42" Decks
Parts Manual
•••••••
Hustler Turf Equipment
•••••
P.O. Box 7000
•••
Hesston, Kansas
•
67062-2097
Summary of the content on the page No. 2
WARNING: The engine exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects or other reproductive harm. IMPORTANT: This engine is not equipped with a spark arrester muffler. It is a violation of California Public Resource Code Section 4442 to use or operate this engine on any forest-covered, brush-covered, or grass-covered unimproved land. Other states or federal areas may have similar laws. This spark ignition system complies wi
Summary of the content on the page No. 3
333559 9/08 cl-3
Summary of the content on the page No. 4
cl-4 333559 9/08
Summary of the content on the page No. 5
Table of Contents Chapter 1 General Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1 Chapter 2 Tractor Frame Rivet Nut Installation . . . . . . . . . . . . . . . . . . . . . . . . 2-2 Engine Guard and Anti-rollover Bracket Assemblies . . . . . . . . . . . 2-3 Footrest Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-4 Chapter 3 Battery Installation. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Summary of the content on the page No. 6
c-2 333559 09/08
Summary of the content on the page No. 7
Chapter 1 General Information This Manual covers “Mini” FasTrak 15/36 model 927343, “Mini” FasTrak 17/42 model 927350, “Mini” FasTrak 16/42 model 927368, & “Mini” FasTrak 16/36 model 927376, Frequently Ordered Parts PART NO. DESCRIPTION 793836 Pump Drive Belt 793828 Deck Belt 36" 793893 Deck Belt 42" 068478 Fuel Filter Kohler 785626 Fuel Filter Honda 794370 Air Filter, Kohler 787226 Air Filter, Honda 747303 Engine Oil Filter, Kohler 787234 Engine Oil Filter, Honda 793794 20.50" 42D X 0.631 CW B
Summary of the content on the page No. 8
Hardware Description Codes & Abbreviations The following codes are used throughout this parts manual. Refer to this list when ordering parts. ABBREVIATION DESCRIPTION CB Carriage Bolt CE Clevis Pin CP Cotter Pin CS Cap Screw CW Cup Washer FDRW Fender Washer FW Flat Washer HX Hex Head LW Lock Washer MB Machine Bushing MS Machine Screw NT Nut SC Self Tapping Cap Screw SH Socket Head SB Shoulder Bolt SS Set Screw OD Outside Diameter ID Inside Diameter Standard Torques The following chart lists the
Summary of the content on the page No. 9
Chapter 2 Contents Tractor Frame Rivet Nut Installation . . . . . . . . . . . . . . . . . . . . . . . . . 2-2 Engine Guard and Anti-rollover Bracket Assemblies. . . . . . . . . . . . . 2-3 Footrest Assembly. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-4 333559 09/08 2-1
Summary of the content on the page No. 10
Tractor Frame Rivet Nut Installation 2 1 3 INDEX SERVICE MFG. PART QTY. DESCRIPTION NO. PART NO. NO. 1 546911 315440 1 FASTRAK 36 FRAME 546895 320242 1 FASTRAK 42 FRAME 2 808493 808493 2 3/8-16 THREAD RIVET NUT 3 793869 793869 2 1.5 SQ TUBE PLUG NOTES: 2-2 333559 09/08
Summary of the content on the page No. 11
Engine Guard and Anti-rollover Bracket Assemblies 1 3 4 2 3 3 8 5 6 9 7 INDEX SERVICE MFG. PART QTY. DESCRIPTION NO. PART NO. NO. 1 316836 316836 1 ENGINE GUARD 2 320580 320580 2 ANTI ROLLOVER BRACKET 3 808493 808493 8 3/8-16 THREAD RIVET NUT 4 781567 781567 2 NT .50-13 HX LK NY ZNYC 5 344267 344267 4 FW .510 X 2.15 X .187SPL ZNYC 6 053199 N/A 2 NT .500-13 HX JAM ZNYC 7 767962 N/A 4 FW .531 X 1.063 X .090 SAE HD ZN 8 031997 N/A 2 ANTI-SCALP WHEEL 9 781708 N/A 2 CS .500-13 X 4.25 HX G5 ZNYC 10 7
Summary of the content on the page No. 12
Footrest Assembly 3 1 4 2 1 6 7 6 5 7 INDEX SERVICE MFG. PART QTY. DESCRIPTION NO. PART NO. NO. 1 011320 011320 4 CB .375-16 X .75 STD ZN 2 785485 785485 2 UPPER STEP TREAD 3 793844 793844 2 LOWER STEP TREAD 4 320267 320267 1 FLOOR PLATE 36" MOWERS 316844 316844 1 FLOOR PLATE 42" MOWERS 5 767954 767954 2 FW .406 X .812 X .060 SAE HD ZN 6 076422 076422 2 FW.406X 1.000X.06 ZNYC 7 054502 054502 4 NT .375-16 HX GRD 5 ZNYC NOTES: 2-4 333559 09/08
Summary of the content on the page No. 13
Chapter 3 Contents Battery Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-2 Deck Lift Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-3 Hydro Transmission Installation S/N Prior To 07091558. . . . . . . . . . 3-4 Hydro Transmission Installation S/N Higher Than 07091558 . . . . . . 3-6 Steering and Brake Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-8 333559 09/08 3-1
Summary of the content on the page No. 14
Battery Installation 2 3 1 4 6 5 2 3 7 8 4 4 PART OF WIRE HARNESS (BLK) 2 9 INDEX SERVICE MFG. PART QTY. DESCRIPTION NO. PART NO. NO. 1 314989 314989 1 BATTERY CLAMP STRAP 2 024927 024927 3 NT .250-20 HX GR.5 ZNYC 3 055939 055939 2 CS .250-20 X .75 HX G5 ZNYC 4 029868 029868 4 LW .250 INT-EXT TOOTH ZNYC 5 740696 740696 1 BATTERY VU1LH-8 6 771428 771428 1 RED BATTERY CABLE BOOT 7 785063 785063 1 POSITIVE BATTERY CABLE (KOHLER) 786632 786632 1 POSITIVE BATTERY CABLE (HONDA) 8 786640 786640 1 NEGA
Summary of the content on the page No. 15
Deck Lift Assembly 1 2 3 5 6 7 8 4 9 9 10 8 1 11 12 9 7 7 13 1 11 8 9 14 9 7 15 5 16 17 16 7 INDEX SERVICE MFG. PART QTY. DESCRIPTION NO. PART NO. NO. 1 348318 348318 1 STOP HANDLE 2 348284 348284 1 HEIGHT ADJUSTMENT STOP 3 793505 793505 1 DECK HEIGHT INDICATOR 4 782995 782995 1 DECK LIFT SPRING 5 055749 055749 2 CS .437-14 X 1.75 HX G5 ZNYC 6 334045 334045 1 DECK LIFT LINK 7 704643 704643 6 NT .437-14 HX FLG ZN 8 025296 025296 4 FW .760 X 1.625 X .08 ZNYC 9 781294 781294 5 E CLIP 1.00 X.625X .
Summary of the content on the page No. 16
Hydro Transmission Installation S/N Prior To 07091558 1 12 1 2 3 5 4 10 6 8 9 7 12 12 21 4 1 13 12 2 1 13 14 11 16 15 19 20 18 17 3-4 333559 09/08
Summary of the content on the page No. 17
Hydro Transmission Installation S/N Prior To 07091558 INDEX SERVICE MFG. PART QTY. DESCRIPTION NO. PART NO. NO. 1 710087 710087 8 CS .312-18 X 2.50 HX G5 ZNYC 2 028118 028118 2 FW .62 X 1.00 X .134 ZNYC 3 794404 794404 1 PULLEY 4 025007 025007 2 CS .625-11 X 1.75 HX G5 ZNYC 5 793836 793836 1 A-SECTION PUMP BELT 6 792911 792911 1 EZT LEFT PUMP/MOTOR COMBO 7 792895 792895 1 EZT RIGHT PUMP/MOTOR COMBO 8 718288 718288 1 FW .516 X .875 X .09 ZNYC 9 035238 035238 1 LW .437 MED SPRING ZYNC 10 794552 7
Summary of the content on the page No. 18
Hydro Transmission Installation S/N Higher Than 07091558 1 11 1 3 2 4 5 9 8 6 11 7 20 8 11 12 1 21 4 11 1 12 2 10 15 14 13 18 19 16 17 3-6 333559 09/08
Summary of the content on the page No. 19
Hydro Transmission Installation S/N Higher Than 07091558 INDEX SERVICE MFG. PART QTY. DESCRIPTION NO. PART NO. NO. 1 710087 710087 8 CS .312-18 X 2.50 HX G5 ZNYC 2 028118 028118 2 FW .62 X 1.00 X .134 ZNYC 3 601162 601162 1 PULLEY 4 025007 025007 2 CS .625-11 X 1.75 HX G5 ZNYC 5 793836 793836 1 A-SECTION PUMP BELT 6 792911 792911 1 EZT LEFT PUMP/MOTOR COMBO 7 792895 792895 1 EZT RIGHT PUMP/MOTOR COMBO 8 712919 712919 2 FW .516 X .875 X .09 ZNYC 9 721134 721134 1 CS .375-16X8.0 HX.GR5 Z 10 33569
Summary of the content on the page No. 20
Steering and Brake Assembly 1 2 4 5 6 3 8 4 11 20 19 7 8 10 12 9 10 4 13 14 5 21 15 22 23 8 11 11 13 8 17 16 13 8 18 2 11 7 23 8 9 13 41 24 26 35 35 28 27 28 21 8 8 11 39 36 37 38 25 27 27 20 33 See Note 4 40 28 29 8 30 3 31 32 11 3-8 333559 09/08
