Summary of the content on the page No. 1
Owner's Manual
Rotary Mower
HRS216PDA � HRS216SDA
HRR216PDA � HRR216TDA
HRS216PDA � HRS216SDA K2
HRR216PDA • HRR216TDA
K3
See page 47 for instructions on
setting up your Lawn Mower.
EM4
POM52774-H
IPC
XXXXX.2005.10
31VL0U00
Printed on
00X31-VL0-U000 Recycled Paper © 1997–2005 American Honda Motor Co., Inc.—All Rights Reserved
PRINTED IN U.S.A.
Summary of the content on the page No. 2
Keep this owner’s manual handy, so you can refer to it at any time. This owner’s manual is considered a permanent part of the lawn mower and should remain with the lawn mower if resold. The information and specifications included in this publication were in effect at the time of approval for printing. American Honda Motor Co., Inc. reserves the right, however, to discontinue or change specifications or design at any time without notice and without incurring any obligation whatever. No part
Summary of the content on the page No. 3
INTRODUCTION Congratulations on your selection of a Honda lawn mower! We are certain you will be pleased with your purchase of one of the finest lawn mowers on the market. We want to help you get the best results from your new lawn mower and to operate it safely. This manual contains the information on how to do that; please read it carefully. As you read this manual, you will find information preceded by a NOTICE symbol. That information is intended to help you avoid damage to your lawn m
Summary of the content on the page No. 4
INTRODUCTION A FEW WORDS ABOUT SAFETY Your safety and the safety of others is very important, and using this lawn mower safely is an important responsibility. To help you make informed decisions about safety, we have provided operating procedures and other information on labels and in this manual. This information alerts you to potential hazards that could hurt you or others. Of course, it is not practical or possible to warn you about all the hazards associated with operating or mainta
Summary of the content on the page No. 5
CONTENTS LAWN MOWER SAFETY ..............................................................................4 IMPORTANT SAFETY INFORMATION ...................................................4 IMPORTANT MESSAGE TO PARENTS .................................................5 SAFETY LABEL LOCATIONS .................................................................6 CONTROLS & FEATURES ...........................................................................7 COMPONENT & CONTROL LOCATIONS ..............
Summary of the content on the page No. 6
LAWN MOWER SAFETY IMPORTANT SAFETY INFORMATION Most accidents with walk-behind mowers can be prevented if you follow all instructions in this manual and on the mower. The most common hazards, according to accident statistics, are discussed below, along with the best way to protect yourself and others. Avoid Rotating Blades Rotating blades can cause serious cuts and even amputate fingers, hands, toes, or feet. Keep away from the mower deck whenever the engine is running. If you need to adjus
Summary of the content on the page No. 7
LAWN MOWER SAFETY IMPORTANT MESSAGE TO PARENTS YOUR CHILDREN’S SAFETY IS VERY IMPORTANT to Honda. That’s why we urge you to read this message before letting your child operate this lawn mower. Lawn mowers are tools, not toys. As with any equipment, bad judgments can result in serious injuries. You can help prevent accidents by making good decisions about if, when, and how your child operates this equipment. The first question you’ll need to ask is whether your child is capable of operatin
Summary of the content on the page No. 8
Do a o re TO n t o inst W P e p r alle RE at d A VE e un or g R LAWN MOWER SAFETY SAFETY LABEL LOCATIONS The labels shown here contain important safety information. Please read them carefully. These labels are considered permanent parts of your mower. If a label comes off or becomes hard to read, contact an authorized Honda dealer for a replacement. CAUTION WARNING WARNING UNDER NORMAL USAGE, THIS BAG MATERIAL IS AVOID SERIOUS INJURY OR DEATH. OBJECTS THROWN BY BLADE SUBJECT TO DETERIORATIO
Summary of the content on the page No. 9
CONTROLS & FEATURES COMPONENT & CONTROL LOCATIONS Use the illustrations on the following pages to locate and identify the most frequently used controls. DRIVE CLUTCH LEVER HANDLEBAR (SDA & TDA) FLYWHEEL BRAKE LEVER RECOIL STARTER GRIP REAR CUTTING HEIGHT ADJUSTMENT LEVER (2) OIL FILLER CAP SIDE DISCHARGE GUARD (HRS ONLY) MUFFLER FRONT CUTTING HEIGHT ADJUSTMENT LEVERS Model Identification To easily identify your model, refer to the chart on page 54. 7
Summary of the content on the page No. 10
CONTROLS & FEATURES REAR DISCHARGE GUARD SHIFT LEVER (HRR) (TDA) MULCHING PLUG (HRR) GRASS BAG (HRR) REAR DISCHARGE GUARD FUEL TANK CAP THROTTLE LEVER SPARK PLUG CAP HANDLEBAR LOCKING KNOB (2) FUEL VALVE AIR CLEANER FRONT CUTTING HEIGHT CARBURETOR MOWER DECK ADJUSTMENT LEVERS 8
Summary of the content on the page No. 11
CONTROLS & FEATURES DESCRIPTION OF CONTROLS Fuel Valve The fuel valve controls fuel flow from the fuel tank to the carburetor. The fuel valve must be ON to start and operate the mower. The fuel valve should be kept OFF when the mower is not in use. FUEL VALVE OFF ON Throttle Lever CHOKE For starting a cold engine. FAST For restarting a warm engine and for mowing. SLOW For idling the engine. CHOKE FAST SLOW 9
Summary of the content on the page No. 12
CONTROLS & FEATURES Flywheel Brake Lever This lever is connected to the engine flywheel brake and the engine switch. The engine will not start or run unless this lever is held against the handlebar. FLYWHEEL BRAKE LEVER DRIVE CLUTCH LEVER Drive Clutch Lever (SDA, TDA) (SDA, TDA) The drive clutch lever engages and disengages the transmission that drives the rear wheels. The drive clutch lever should only be engaged after the engine has been warmed up. Shift Lever (TDA) The shift lever
Summary of the content on the page No. 13
CONTROLS & FEATURES Cutting Height Adjustment Levers The mower deck can be set to any of the six approximate settings. Each wheel should be adjusted to the same position. Lower deck Move both the front and rear adjusters backward. Raise deck Move both the front and rear adjusters forward. FRONT REAR ADJUSTMENT ADJUSTMENT LEVER LEVER RIGHT SIDE SHOWN FORWARD 11
Summary of the content on the page No. 14
BEFORE OPERATION ARE YOU READY TO GET STARTED? Your safety is your responsibility. A little time spent in preparation will significantly reduce your risk of injury. Knowledge Read and understand this manual. Know what the controls do and how to operate them. Familiarize yourself with the lawn mower and its operation before you begin using it. Know how to quickly shut off the lawn mower in case of an emergency. IS YOUR LAWN MOWER READY TO GO? For your safety, and to maximize the service life
Summary of the content on the page No. 15
BEFORE OPERATION Check the General Condition of the Lawn Mower: • Look around and underneath the lawn mower for signs of oil or gasoline leaks. • Look for signs of damage. • Check each control for proper operation. • Check the blades for wear. Replace as necessary (page 30). Check that the blade bolts are tight (page 32). • Check that all nuts, bolts, screws are tightened. Check the Engine • Check the air cleaner (page 35) and oil level (page 33). • Check the fuel level (page 38). Starting wit
Summary of the content on the page No. 16
BEFORE OPERATION Mulching Plug (HRR) The mulching plug helps to curve REAR DISCHARGE the inside of the mower deck for GUARD more efficient mulching. Install and remove the mulching plug by raising the rear discharge guard as shown. The mulching plug only fits one way. Remove the mulching plug when using a grass bag. MULCHING PLUG Side Discharge Chute SIDE (HRS) DISCHARGE GUARD To discharge clippings to the side, install the side discharge chute as shown. Remove the side discharge chut
Summary of the content on the page No. 17
BEFORE OPERATION Grass Bag (HRR) A lawn mower works like a vacuum cleaner; it blows air through the bag, which traps the grass clippings. Always empty the grass bag before it becomes filled to the limit of its capacity. Bagging performance will diminish after the bag becomes about 90% full. Also, the bag is easier to empty when not packed full. Inspection Inspect the grass bag before use. Check for holes, tears, and excessive wear. The grass bag does wear during normal use, and will eventu
Summary of the content on the page No. 18
OPERATION MOWING PRECAUTIONS Before operating the mower for the first time, please review the LAWN MOWER SAFETY chapter beginning on page 4 and the BEFORE OPERATION chapter beginning on page 12. Even if you have operated other mowers, take time to become familiar with how this mower works and practice in a safe area until you build up your skills. For your safety, avoid starting or operating the engine in an enclosed area, such as a garage. Your mower’s exhaust contains poisonous carbon mo
Summary of the content on the page No. 19
OPERATION 3. SDA, TDA: Release the drive DRIVE CLUTCH LEVER (SDA, TDA) clutch lever (page 10). If the drive clutch lever is engaged, the mower will move forward when you operate the starter. 4. Pull back on the flywheel brake lever and hold it against the handlebar. 5. Pull the starter grip lightly until FLYWHEEL BRAKE LEVER you feel resistance, then pull briskly. Return the starter grip gently. STARTER GRIP Keep your hands and feet away from the mower deck at all times when starting
Summary of the content on the page No. 20
OPERATION OPERATING THE CONTROLS FOR MOWING Throttle Lever For best cut quality, always mow with the throttle lever in the FAST position. When the blades rotate at the preset fast speed, it creates a strong fan action that lifts and cuts grass more efficiently. Do not try to increase the preset engine speed, the blade(s) could fracture and come apart. THROTTLE LEVER FAST When you need to leave the mower for any reason, move the throttle to SLOW, then turn the engine OFF by releasing the f
