Summary of the content on the page No. 1
13/30
HERITAGE TRACTOR
CODE131B
INSTRUCTION BOOK
FROM SERIAL NO:131B001001 MANUAL PART NO: 131004(REV.1.)
F–040730L
Summary of the content on the page No. 2
1 2 5 (30x49) 1 6 4 (17x195) 2 7 (17x192) 3 5 (1001054) 3 4 (17x47) 1 2 3 4 5 7 7 (14x79) 4 2 4 (25x3) 8 6 (2x82) 6 (17x146) 1 6 (2x82) 3 2 1 3 6 10 5 6 6 (1x121) 3 1 7 (15x116) 3 5 6 (1x121) 4 4 6 (1x121) 8 9 7 (15x116) 5 6 (1x121) 2 7 (15x116) F–040730L 2
Summary of the content on the page No. 3
7 8 3 11 8 9 10 3 9 14 3 9 10 9 13 12 15 11 12 9 1 2 F–040730L 3
Summary of the content on the page No. 4
13 14 1 1 7 2 2 6 4 3 5 15 16 1 2 1 2 3 7 8 17 18 6 3 4 5 9 F–040730L 4
Summary of the content on the page No. 5
19 20 6 1 7 10 5 2 8 1 2 9 4 1 3 21 22 4 5 7 1 3 1 4 5 2 3 2 23 24 1 8 6 4 3 2 5 7 1 3 2 F–040730L 5
Summary of the content on the page No. 6
25 26 2 2 1 1 2 1 27 28 29 3 4 1 1 2 2 F–040730L 6
Summary of the content on the page No. 7
30 31 3 6 1 2 3 2 4 1 5 32 33 4 2 13 2 3 1 F–040730L 7
Summary of the content on the page No. 8
8 34 2 1 4 1 1 3 6 4 3 5 9 7 F–040730L 8
Summary of the content on the page No. 9
35 7 6 12 3 5 4 9 10 11 12 8 13 14 36 8 2 4 67 9 1 5 3 10 11 12 14 13 15 37 30x49 2x82 14x79 15x116 25x3 20729 1x121 17x146 17x195 1001054 17x192 17x47 F–040730L 9
Summary of the content on the page No. 10
GB LIMITED WARRANTY Hayter Limited warrants to the original user / purchaser that this unit shall be free from defects in material and workmanship under normal use and service for a period of three years from the date of purchase. The manufac- turers of the engine and battery pack system (where applicable) furnish their own warranty and services are pro- vided through their authorised network (Refer to “Engine/Battery Pack Warranty Statement”). To qualify for the full benefit of the warranty, th
Summary of the content on the page No. 11
GB CONTENTS LIMITED WARRANTY 10 INTERNATIONAL PICTORIALS 11 OWNER’S INFORMATION 12 SAFE OPERATION PRACTICES 12 ASSEMBLY 13 OPERATION 14 MAINTENANCE 15 TROUBLE SHOOTING CHART 19 6 DANGER: No Step. 2 Lights INTERNATIONAL PICTORIALS 7 DANGER: Keep Feet And Hands Away 3 Engine Run IMPORTANT: The following pictorials are lo- From Rotating Blade. cated on your unit or on literature supplied 8 Declared airborne sound power level of 100 4 Engine Stop with the product. Before you operate the dB(A) is in
Summary of the content on the page No. 12
GB 2. Thoroughly inspect the area where the nor allow anyone near the machine while in OWNER’S INFORMATION equipment is to be used and remove all ob- operation. jects which may be thrown by the machine. Know your product: If you understand the unit 10. Never operate the mower with defective 3. WARNING – Petrol is highly flammable. and how the unit operates, you will get the best guards or shields, or without safety protec- performance. As you read this manual, compare tive devices in place. a. S
Summary of the content on the page No. 13
GB 3. Check the operating position of the seat (1). 3. If the battery (1) is put into service after the ASSEMBLY If the seat (1) needs to be adjusted, loosen battery date, the battery (1) must be the two wing bolts (5). Slide the seat (1) for- charged. See “How To Charge The Mainten- All fasteners are in the parts bag. Do not dis- ward or backward along the seat adjusting ance Free Battery”. card any parts or material until the unit is as- holes (3). Tighten the wing bolts (5). sembled. WARNING:
Summary of the content on the page No. 14
GB WARNING: Make sure the parking OPERATION WARNING: Always keep your brake will hold the unit. hands and feet away from the blade, deflector opening, and the NOTE: Illustrations and pictorials begin on mower housing when the engine runs. 5. Move the throttle control (7) to the SLOW page 2. position. 6. To stop the engine, turn the ignition key (3) How To Use The Shift Lever (Figure 13) to the OFF position. Remove the key. Location Of Controls (Figure 13) To change the forward speed or the direc
Summary of the content on the page No. 15
GB 4. If you must stop or start on a hill, always 2. Check the oil. Follow the procedure in the 3. Every time you use the unit, check the blade. have enough space for the unit to roll when engine manufacturer’s instructions. If the blade is bent or damaged, immediately you release the brake and engage the clutch. replace the blade. Also, make sure the nut 3. If necessary, add oil until the oil reaches the for the blade is tight. 5. Be very careful when you change directions FULL mark on the dips
Summary of the content on the page No. 16
GB 8. (Figure 18) Pull the connector tube (3) 9. Mount the blade (1) so that the hi–lift edges 12.Attach the wire to the spark plug. Mow for a through hole in rear plate (6). (7) are up. If the blade is upside down, the short distance and again check the operation blade will not cut correctly and can cause an of the blade rotation control. 9. Clean the connector tube (3) with soap and accident. 13.When you move the blade rotation control to water. the DISENGAGE position, all movement will 10.Fas
Summary of the content on the page No. 17
GB 4. (Figure 29) To access the belt guides (1), How To Check And Adjust The Drive How To Level The Mower Housing remove the battery and battery tray. See Brake (Figure 24) (Figure 25 and Figure 26) “How To Remove The Battery”. Completely push the clutch/brake pedal forward. If the mower housing is level, the blade will cut 5. Loosen the belt guides (1) at the drive Set the parking brake. Move the shift lever to the easier and the lawn will look better. pulley (2). neutral (N) position. Push the
Summary of the content on the page No. 18
GB 6. Disconnect the front hanger (9) from the storage as follows. recommended for this unit. In order to obtain axle support. See illustration “F”. proper replacement parts you must supply the 1. Drain the fuel from the carburettor and the model number of your mower (see nameplate). 7. Remove the mower drive belt (7) from the fuel tank. Change the engine oil. See the en- stack pulley (8). See illustration “G”. gine manufacturer’s instructions. Replacement parts are available from your local Hay
Summary of the content on the page No. 19
GB 3. Clean the air filter. 7. Clean the extension tube and the connector TROUBLE SHOOTING CHART tube (applies only to model with rear dis- 4. Replace the fuel filter. charge grass bag). PROBLEM: The engine will not start. PROBLEM: The engine stops when the 1. Follow the steps, “How To Start The Engine” PROBLEM: The mower housing does blades are engaged. in this book. not cut level. 2. Electric–Start Models: Clean the battery ter- 1. Check the wiring harness for damage or a 1. Check the air pre
Summary of the content on the page No. 20
CODE131B REPAIR PARTS CHASSIS & HOOD 2 13 1 8 11 10 14 15 7 3 9 16 4 2 6 12 70 5 17 57 58 31 25 27 18 28 22 21 29 50 20 23 30 58 19 24 55 32 16 33 59 31 16 34 47 35 53 16 26 51 46 37 31 16 48 45 36 44 38 16 16 39 43 16 49 40 41 42 20 F–040730L
