Summary of the content on the page No. 1
_L_E,/__ Owner's Manual
@
24 VOLT DC
20" Cordless Rechargeabie
REAR DISCHARGE
MULCHING MOWER
Model No.
917.386410
Safety
o Assembly
o Operation
o Maintenance
° Espafiol
• Repair Parts
CAUTION:
Read and follow all
Safety Rules and Instructions
before operating this equipment
Sears, Roebuck andCo., Hoffman Estates, IL 60179
Summary of the content on the page No. 2
Safety Rules ' 2 Maintenance Schedule 10 Product Specifications 11 Service and Adjustments 12 Maintenance ;7 Storage 14 Warranty 2 Troubleshooting 15-16 Assembly 5 Illustrated Parts List 28-30 Operation 6 Palls Ordering Back Cover ................. ,__ ..... - .... ± ,i i LIMITED TWO YEAR WARRANTY ON CRAFTSMAN POWER MOWER For two years from date of purchase, wllen this Craftsman Lawn Mower is main- tained, lubricated, and tuned up according to the operating and maintenance instructions in the ow
Summary of the content on the page No. 3
o The blade rums when the motor is running. your mower. IER143,970002 . Avoid accidental starting Do not play with the • Do not operate your mower if it switch button and Operator Presence Control vibrates abnormally. Excessive Bar when not in use. vibration is an indication of damage; PREPARATION: stop the motor and safely check for o Always thoroughly check the area to be the cause of vibration. Repair as mowed and clear it of all stones, sticks, wires, required. • Do not run the motor indoors
Summary of the content on the page No. 4
turers recomrnended parts only Use of any ', Keepallsafetydevices inplaceand o!her blade may result in serious personal working. injury or damage to your mower , To reduce fire hazard, keep the mot6[ • Store mower inside+ When not in use, mower free of grass, leaves or excessive should be stored indoors in a garage, grease and oil basement, etc. Storage area should be a dry, • Check grass catcher bag often for locked+up place - out of reach of children deterioration and wear. Replace worn ° Main
Summary of the content on the page No. 5
These accessories were available when and service centers. Most Sears this lawn mower was produced, They are stores can also order repair parts for also available at most Sears retail outlets you, when you provide the model number of your lawn mower. LAWN MOWER PERFORMANCE I:_AWN MOWER MAINTENANCE 9 Wheels Blades Blade adapters TO REMOVE LAWN MOWER FROM CARTON • Remove loose parts included with Upper Handle mower, Operator Presence Control Bar . Cut down two end corners of carton and lay end pan
Summary of the content on the page No. 6
KNOWYOUR LAWN MOWER READTHISOWNER'SMANUALANDSAFETYRULESBEFOREOPERATING YOURLAWNMOWER.Comparetheillustrationswithyourlawnmowertofamiliar- izeyourselfwiththelocationof vadd_us controlsand adjustments.Savethismanual for futurereference° Thesesymbols mayappearonyourlawnmoweror in literaturesuppliedwiththe product,Learnand understandtheirmeaning. WARNING AND FEET AWAY CAUTION OR _ DANGER. KEEP HANDS Operator Presence Control Bar Start Switch Button Load Indicator Handle Light Knob Battery Status Ligh
Summary of the content on the page No. 7
CHARGING • Your mower has been designed so that it is safe to continuously leave it Thebatteryhasbeencharged atthefactory on charge for extended periods of However, itwillbenecessary torecharge time. You can even leave it on battery andmakesureithasafullcharge before initialuse. _ harge during lhe off season if desired • Always charge mower indoors in a garage, The operation of any lawn carport, etc, where it is dry and protected mower can result in foreign objects from the weather. DO NOT expos
Summary of the content on the page No. 8
TOATTACHGRASSCATCHER TO INSTALL ATTACHMENTS t " Closetheflip lid.Fliplidrnustbe Yeur lawn mower was shipped ready to be closedwhileoperatinglawn used as a mulcher. To convert to bagging mower. or discharging: 6 Lift thereardooron thernower • Open rear door and remove mulcher housingand placethe grass plate Store mulcher plate in a safe catcherframeontotheformed place. tabsonthe reardoorhinge • You can now install catcher or optional bracket. clipping deflector o Thegrasscatcheris securedto • To
Summary of the content on the page No. 9
MULCHING MOWING TIPS MOWING TIPS IMPORTANT: For best performance, • Under certain conditions, such as very keep mower housing free of built-up tail grass, it may be necessary to raise grass and trash. See CLEANING in the height of cut to reduce pushing effort Maintenance section of this maeuaJ and to keep from overloading the engine and leaving clumps of grass clippings. It = The special mulching blade will may also be necessary to reduce recut the grass clippings many times and reduce them in s
Summary of the content on the page No. 10
CUSTOMER RESPONSIBILITIES SERVICE DATES 1 , Replaco blades more olten when mowing in 5_I]d¥ soil LUBRICATION CHART GENERAL RECOMMENDATIONS ( ) Wheel Adjusters o Always observe safety rules when performing any maintenance.. • "The warranty on this lawn mower does not cover items that have been subjected to operator abuse or negligence. To receive full value from the warranty, operator must maintain mower as in- structed in this manual. ,, Some adjustments will need to be, made periodically to pro
Summary of the content on the page No. 11
PRODUCT SPECIFICATIONS MODEL NUMBER 917o3864!0 POWER 24V DC BATTERY / 17 AMP-HOUR 40 AMP FUSE BLADE SPEED 3200 RPM CUTTING WIDTH 20" CHARGER 12-16 HOUR RECHARGE BLADE BOLT TORQUE: 35-40 FT LBS blade bolt, turning clockwise. TIRES • The recommended tightening o Keep tires free of gasoline, oil, or insect torque is 35-40 ft. Ibs control chemicals which can harm rubber. ,' Avoid stumps, stones, deep ruts, sharp IMPORTANT: Blade bolt is grade 8 heat treated objects and other hazards that may cause t
Summary of the content on the page No. 12
CLEANING GRASS CATCHER I CAUTION: Remove fuse from motor and o The grass catcher may be hosed v_ith water, but must be dry when used., ptace it in a safe place away from mower Remove grass catcher from mower " Turn lawn mower on its side.. Clean the before cleaning underside of your lawn mower by scraping to • Check your grass catcher often for ; remove build-up of grass and trash damage or deterioration Through o Keep finished surfaces and wheels free of all norrnal use it will wear. If catcher
Summary of the content on the page No. 13
- Be sure controller board is secured Recharge battery immediately aftereach use. propedy. - Be sure all leads are routed and o Recharge battery continuously when mower is not in use. installed properly. . Always charge battery indoors in a dry, - Be sure all hardware is lighlened securely protected place. ° DO NOTcharge in extreme hot or cold Top Grille temperatures. Charge mower battery in a location where temperature is more than Indicator 50°F (10°C) but less than 100°F (37°C). Board BAI'TER
Summary of the content on the page No. 14
Lower Handle Immediatelyprepareyourlawn , mowerforslorageat theend of Ihe Squeeze to seasonor if theunitwill notbeused Fold for30daysor more. LAWN MOWER Whenlawnmowe[isto bestoredfor a periodof time,cleanit thoroughly, removeall dirt,grease,leaves,etc. Storeina clean,dry area. o Cleanentirelawnmower(See Hairpin Cotier Mounting Pin "CLEANING"inthe Maintenance sectionof thismanual). Operator Presence Mowing Position . Lubricate as shown in the Mainte- Control Bar nance section of this manual. ,, B
Summary of the content on the page No. 15
TROUBLESHOOTING CHART CORRECTION CAUSE =ROBLEM , Install fuse o Fuse has been ]oes not start removed from mower • Remove charger plug from o Charger has not been mower charge pod unplugged from mower charge port • Charge battery o Battery may need [o be recharged ° Remove fuse, turn mower o Blade does not rotate freely on itssideandcheckblade. or mower deck is clogged Make sure it is free to rotate. Also check {or clogging, • Raise mower cutting height • Grass too high or thick _oor performance
Summary of the content on the page No. 16
CORRECTION -CAUSE PROBLEM o Remove fuse and o If high current light stays '7lower stops turn mower all its side. on momedtarily after Make sure blade is free to mower stops, load is too rotate. Also check mower much for m_wer. fol clogging. o Batteries may be low, near If low power light stays the need of charging. on, mower slows down, Recharge batteries, lhen stops. o Grass may be too heaw for remaining battery capacity Try the following: • Walk slower. ,, Reduce cutting width o Raise mower cu
Summary of the content on the page No. 17
CRAFTSMAN Model No. 917.386410 Reglas de Seguridad 15 Programa de Mantenimienfo 22 Especificaciones del Producto 23 Servicio y Adjusles 24 Mantenimiento 22 Almacenamiento 25 Garantia 15 Idenlificaci6n de problemas 26 Montaje 18 Partes de repuesto Vea el manual Qperaci6n 19 ingles del dueRo Orden de Parles Conlratapa GARANTiA LIMITADA DE DOS ANOS PARA LA SEGADORA A MOTOR CRAFTSMAN Per dos (2) ar3os, a partir de la lecha de compra, cuando esta Segadora Craftsman se mantenga, lubrique y aline segun
Summary of the content on the page No. 18
• Nouse accesorios quenohayan sido su segadora, pare el molor y esl _completamente recomendados porelfabricanle Elusode seguro de qua la cuchilla y cualqL_i£r otra parte dichos accesorios puede serpe[igros_ movible se hallan parado Entonces remueva el alambre de la bujia pare prevenir ananques • Lacuchifla viracuando elmotor esta en marcha accidenlales Evile ananqLles acoidentales Nojuegue No cot!linue haciendo funcionar su segadore si le conelbo!6n delintemJplor ylabane de pega a un objelo extr
Summary of the content on the page No. 19
niiios MANTENIMIENTO Y ALMACENAMIEN-TO: o Car,serve la segadora con mocha • Revlse la cuchilla asi come los pemos de montaje euidado Para que pueda oblener meiores del motor con [rect.lencia pareasegurarse que y segUros resultados, maatenga la asian bien apretados cuchilla afilada y limpia Siga tas , Revise (odes los pemos, tee(cos y tomillos a instruceiones del labricanla c_Jando vnya late(vales, pare vedficar si as(Anaprelados en a cambiar los accasados to(me adecuada, y asegurarse qua la sega
Summary of the content on the page No. 20
Estos accesofios estaban disponibtes cuando pedir partes de repuesto para usted, si se produjo la segadora Tambi_n est&n los proporciona el numero del modelo de disponibles en la mayoria de las tiendas de su segadora Algunos de estos Sears y en los centros de servicio La mayoria accesorios ta! vez no se apliquen a su de las tiendas Sears tambien pueden mandar a segadora RENDIMIENTO DE LA SEGADORA It Re=erector MANTENIMtENTO DE LA SEGADORA J AUaf)l_dor_ r* Cttr !_lla_ lie ctJ¢1111511 PARA REMOVER
