Summary of the content on the page No. 1
Dell™ Latitude™ D410 Service Manual
Before You Begin Mini PCI Card
System Components Display Assembly
Internal Card With Bluetooth® Wireless Technology Palm Rest
Hard Drive Fan
Memory Module and Modem Smart Card Reader
Coin-Cell Battery System Board
Center Control Cover Pin Assignments for I/O Connectors
Keyboard Flashing the BIOS
Notes, Notices, and Cautions
NOTE: A NOTE indicates important information that helps you make better use of your computer.
NOTICE: A NOTICE indicates eithe
Summary of the content on the page No. 2
Back to Contents Page Before You Begin Dell™ Latitude™ D410 Service Manual Preparing to Work Inside the Computer Recommended Tools Computer Orientation Screw Identification Preparing to Work Inside the Computer CAUTION: Only a certified service technician should perform repairs on your computer. Damage due to servicing that is not authorized by Dell is not covered by your warranty. Read and follow applicable instructions in the safety instructions in the Product Inf
Summary of the content on the page No. 3
Recommended Tools The procedures in this manual require the following tools: l #1 Phillips screwdriver l ¼-inch flat-blade screwdriver l Small plastic scribe l Flash BIOS update program CD or USB memory key with the flash BIOS update program. Computer Orientation 1 front 2 left 3 back 4 right Screw Identification When you are removing and replacing components, print "Screw Identification" as a tool to lay out and keep track of the screws. The placemat provides
Summary of the content on the page No. 4
Display Assembly (top — hinges): Palm Rest (top): Fan: (2 each — M2 x 6 mm) (5 each — M2.5 x 5 mm) (3 each) (1 each — M2 x 3 mm) Display Assembly (bottom — computer base): Computer Base: System Board: (2 each — M3 x 5 mm) (12 each — M2.5 x 5 mm) (3 each) door for internal card with Bluetooth® Wireless Technology (1 each — M2 x 3 mm) Back to Contents Page
Summary of the content on the page No. 5
Back to Contents Page Flashing the BIOS 1. Ensure that the AC adapter is plugged in and that the main battery is installed properly. NOTE: If you use a BIOS update program CD to flash the BIOS, set up the computer to boot from a CD before inserting the CD. 2. Insert the BIOS update program CD, and turn on the computer. Follow the instructions that appear on the screen. The computer continues to boot and updates the new BIOS. When the flash update is complete, the computer wil
Summary of the content on the page No. 6
Back to Contents Page Internal Card With Bluetooth® Wireless Technology Dell™ Latitude™ D410 Service Manual Removing the Internal Card With Bluetooth® Wireless Technology Replacing the Internal Card With Bluetooth® Wireless Technology Removing the Internal Card With Bluetooth® Wireless Technology CAUTION: Before performing the following procedures, read the safety instructions in your Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by u
Summary of the content on the page No. 7
3. Replace the battery. Back to Contents Page
Summary of the content on the page No. 8
Back to Contents Page Coin-Cell Battery Dell™ Latitude™ D410 Service Manual Removing the Coin-Cell Battery Replacing the Coin-Cell Battery Removing the Coin-Cell Battery CAUTION: Before you begin any of the procedures in this section, follow the safety instructions located in the Product Information Guide. CAUTION: To prevent static damage to components inside your computer, discharge static electricity from your body before you touch any of your computer's electronic com
Summary of the content on the page No. 9
Replacing the Coin-Cell Battery 1. Affix the replacement battery with the double-sided tape on the system board. 2. Replace the coin-cell battery cover. Back to Contents Page
Summary of the content on the page No. 10
Back to Contents Page Center Control Cover Dell™ Latitude™ D410 Service Manual Removing the Center Control Cover Replacing the Center Control Cover Removing the Center Control Cover CAUTION: Before you begin any of the procedures in this section, follow the safety instructions located in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as t
Summary of the content on the page No. 11
Back to Contents Page Display Assembly Dell™ Latitude™ D410 Service Manual Removing the Display Assembly Replacing the Display Assembly Removing the Display Assembly CAUTION: Before you begin any of the procedures in this section, follow the safety instructions located in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) o
Summary of the content on the page No. 12
8. Pull up on the pull-tab to disconnect the display cable from the system board. 9. Remove the two M2 x 6-mm screws from the left and right hinges. 10. Lift the display away from the computer and lay it aside. 1 M2 x 6-mm screws (2) 2 display cable 3 system board connector Replacing the Display Assembly 1. Align the display assembly over the screw holes in the base of the computer. 2. Replace the screws taken from the left and right hinges.
Summary of the content on the page No. 13
8. Turn the computer over and replace the two screws labeled "D" on the computer base. Back to Contents Page
Summary of the content on the page No. 14
Back to Contents Page Fan Dell™ Latitude™ D410 Service Manual Removing the Fan Replacing the Fan Removing the Fan CAUTION: Before you begin any of the procedures in this section, follow the safety instructions located in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer. 1. Follow the instructions in "P
Summary of the content on the page No. 15
Summary of the content on the page No. 16
Back to Contents Page Hard Drive Dell™ Latitude™ D410 Service Manual Removing the Hard Drive Replacing the Hard Drive CAUTION: If you remove the hard drive from the computer when the drive is hot, do not touch the metal housing of the hard drive. CAUTION: Before you begin any of the procedures in this section, follow the safety instructions located in the Product Information Guide. NOTICE: To prevent data loss, shut down your computer before removing the hard drive. Do not
Summary of the content on the page No. 17
Summary of the content on the page No. 18
Back to Contents Page Keyboard Dell™ Latitude™ D410 Service Manual Removing the Keyboard Replacing the Keyboard Removing the Keyboard CAUTION: Before you begin any of the procedures in this section, follow the safety instructions located in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer. 1. Follow the
Summary of the content on the page No. 19
Replacing the Keyboard 1. Reconnect the keyboard connector to the to the system board connector/tab. 2. Gently slide the bottom of the keyboard into the base of the computer. NOTE: You may need to push the bottom of the keyboard down slightly into the computer base to slide the keyboard into the base of the computer. 3. Replace the two M2 x 3-mm screws across the top of the keyboard. 4. Replace the center control cover. Back to Contents Page
Summary of the content on the page No. 20
Back to Contents Page Mini PCI Card Dell™ Latitude™ D410 Service Manual Removing the Mini PCI Card Replacing the Mini PCI Card Removing the Mini PCI Card CAUTION: Before you begin any of the procedures in this section, follow the safety instructions located in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the comput
