Summary of the content on the page No. 1
Summary of the content on the page No. 2
Information in this document is subject to change without notice. Caution Markings for Lithium/Ion Battery - The following or similar texts shall be provided on battery pack of equipment or in both the Sony, VAIO and CLIE are trademarks or registered trademarks of operating and the service instructions. Sony. Microsoft, Windows, Windows Media, Outlook, Bookshelf and other Microsoft products are trademarks or registered trademarks CAUTION: Danger of explosion if battery is incorrectly replaced. o
Summary of the content on the page No. 3
TABLE OF CONTENTS Section Title Page CHAPTER 1. BLOCK DIAGRAM ............................... 1-1 (to 1-2) CHAPTER 2. FRAME HARNESS DIAGRAM ........ 2-1 (to 2-2) CHAPTER 3. EXPLODED VIEWS AND PARTS LIST 3-1. Main Section .................................................................... 3-1 3-2. LCD Section .................................................................... 3-3 3-3. Port Assy Section ............................................................. 3-5 3-4. Accessories ..........
Summary of the content on the page No. 4
CHAPTER 1. BLOCK DIAGRAM ModeBitRom microchip CPU TDM CN 30P 93LC56BT Transmeta DDR SDRAM SDRAM Crusoe(TM) PCI Debug CN 256Mb; 4 µDIMM CN TM5800 867MHz AD25 128MB 1010 000x (AD11) PCI Bus (3.3V) i.LINK PC Card MPEG2 Inverter LAN TI RICOH Encoder Realtek Graphics TSB43AB R5C475II Fujitsu CN 6P RTL8100BL ATI 22PDT (CSP144) MB86393 AD22 IDE(Primary) AD20 AD29 AD21 RAGE- LAN CN REQ4,GNT4 50P CN REQ0, GNT0 REQ2,GNT2 REQ5,GNT5 CN 6P Mobility M6(A22) VGA CN AD23 BT,HDD, REQ3,GNT3 Serial/Parall
Summary of the content on the page No. 5
CHAPTER 2. FRAME HARNESS DIAGRAM LCD HOUSING ASSY MIC IFX-166 BOARD From board to connector (direct connection) Harness (with connectors on both ends) Harness (soldering on either end) LITHIUM ION BATTERY PACK INVERTER HARNESS CN2602 Rear 61 LCD UNIT CN2102 POWER JOG CAMERA 30 29 BUTTON DIAL SHUTTER MODEM SWX-83 BOARD CARD 2 1 SIDE A 2 1 Side R MODULAR NICKEL HYDROGEN 1 16 LCD HARNESS HARNESS MODULAR CN1211 BATTERY 1 2 JACK CN2601 HARNESS (DC JACK) CN5300 CN1501 126 1 50 HARNESS (MDC TO CNX) Sid
Summary of the content on the page No. 6
CHAPTER 3. Ref.No. Part No. Description Ref.No. Part No. Description EXPLODED VIEWS AND PARTS LIST 1 4-655-327-01 RETAINER, SPEAKER 16 1-823-465-11 FFC 12P 2 1-544-951-11 LOUD SPEAKER 17 A-8067-126-A SWX-83 NON-BT ASSY (S) NOTE: 3 4-643-073-11 SHEET (SPEAKER), ADHESIVE 18 1-823-466-11 CABLE, FLEXIBLE FLAT 16P The components identified by mark 0 or • The mechanical parts with no reference number in the 4 4-641-838-01 CUSHION (SP) *19 4-656-219-01 HEAT SINK dotted line with mark 0 are critical for
Summary of the content on the page No. 7
Ref.No. Part No. Description 3-2. LCD Section 101 X-4623-818-2 COVER SUB ASSY, HINGE 102 X-4623-812-3 BEZEL SUB ASSY (B), LCD 103 4-646-976-11 CUSHION (LATCH) 104 4-643-078-11 RUBBER (UNDER), BLIND 105 A-8067-128-A LCD 8.9WSXGA ASSY (S) 106 1-476-913-11 INVERTER UNIT 107 1-961-294-11 INVERTER HARNESS (6PIN) 108 1-961-422-12 LCD HARNESS 109 4-655-335-01 HINGE (L) 110 4-655-343-01 PLATE (CAMERA), ORNAMENTAL 111 X-4623-813-1 COVER SUB ASSY, CAMERA 112 4-655-341-01 HOLDER, RING 113 4-655-336-01 RING
Summary of the content on the page No. 8
Ref.No. Part No. Description 3-3. Port Assy Section 201 4-655-763-01 FOOT, RUBBER 202 4-655-758-02 CABINET (LOWER) * 203 4-655-760-01 PLATE, CONNECTOR 204 A-8066-914-A COMPLETE PWB CNX-147 205 1-794-548-11 CONNECTOR, USB (A) * 206 4-656-128-01 BRACKET 207 1-823-344-13 CABLE, I/F 208 4-655-761-01 HOLDER, CONNECTOR 209 4-656-127-02 ESCUTCHEON (CONNECTOR) 211 210 X-4624-077-2 CABINET (UPPER) SUB ASSY 211 4-655-762-01 LABEL, CONNECTOR 212 4-659-565-01 SHEET (PORT REPLICATOR) 213 4-659-666-01 GASKET
Summary of the content on the page No. 9
Ref.No. Part No. Description 3-4. Accessories ACCESSORIES 301 312 *********** Power Cord i Link Connecting Cable 0301 1-757-562-31 CORD, POWER 303 1-757-673-12 CORD, CONNECTION 306 4-655-329-01 CAP (IN BAG), SENSOR 0307 1-476-942-31 ADAPTOR, AC 308 A-8067-449-A BP51A/L (U) ASSY (S) 309 PORT ASSY 312 1-823-439-11 CORD, I LINK CONNECTION 313 4-657-363-01 CLAMP 303 314 X-4625-087-1 STAND ASSY AV Connecting Cable 4-665-258-01 QUICK START, 2290U LOOK AT EXPLODED VIEWS OF THE PART 313 ****************
Summary of the content on the page No. 10
PCG-C1MW/C1MWP (AM) List of PCG-C1 Series for American Area (As of June, 2002) Service Manual Model Parts No. PCG-C1XS 9-872-053-11 PCG-C1VN 9-872-126-11 PCG-C1VP 9-874-422-11 PCG-C1VPK PCG-C1MV PCG-C1MV/M 9-874-449-01 PCG-C1MVP PCG-C1MVP/M PCG-C1MW 9-874-577-01 * PCG-C1MWP * : Additional Model American Area : North, Central and South Americas This manual and the constituent data may not be replicated, copied nor reprinted in whole or in part without prior written authorization of Sony Corporati
Summary of the content on the page No. 11
Revision History Suffix Ver. Date Contents QM No. -01 Ver. 1 2002.06.24 First Edition [Confidential] PCG-C1MW/C1MWP (AM)
