Summary of the content on the page No. 1
GAS GRILL
Natural Gas Grill Owner’s Guide
Guía del propietario del asador de gas licuado de propano - Pg 19
Guide de l’utilisateur du grill à gaz PL - Pg 32
E/S -310/320, EP -310/320
#89557
#00000
WARNING: Follow all leak-check
YOU MUST READ THIS OWNER’S GUIDE
procedures carefully in this manual prior
BEFORE OPERATING YOUR GAS GRILL
to barbecue operation. Do this even if the
barbecue was dealer-assembled.
DANGER
If you smell gas:
1. Shut off gas to the appliance.
NOTICE TO INSTALLER: Th
Summary of the content on the page No. 2
2 WARNINGS DANGERS AND WARNINGS DANGER Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or death, or in a fi re or an explosion causing damage to property. WARNINGS Do not store a spare or disconnected liquid propane cylinder under or near this barbecue. Improper assembly may be dangerous. Please follow the assembly instructions carefully. ® After a period of storage, and/or nonuse, the Weber gas barbecue should b
Summary of the content on the page No. 3
WARRANTY,, GARANTÍA, GARANTIE 3 ® Weber-Stephen Products Co. (Weber) hereby warrants to the ORIGINAL PURCHASER of this Weber misuse, alteration, misapplication, vandalism, improper installation or improper maintenance or WARRANTY gas grill that it will be free of defects in material and workmanship from the date of purchase as follows: service, or failure to perform normal and routine maintenance, including but not limited to damage 3 caused by insects within the burner tubes, as set out in th
Summary of the content on the page No. 4
EXPLODED VIEW E/S/EP - 310 4 1 2 3 4 22 5 6 23 7 24 25 26 8 27 28 29 9 30 31 10 32 11 33 34 12 35 13 36 37 14 15 16 38 17 18 39 19 40 41 20 42 43 21 44 ® WWW.WEBER.COM
Summary of the content on the page No. 5
EXPLODED VIEW LIST E/S/EP - 310 5 LISTA DEL DIAGRAMA DE DESPIECE, LISTE DE LA VISION ÉCLATÉE 5 1. Shroud Hardware 18. Front Panel 35. Manifold Accesorios de la cubierta Panel delantero Múltiple Matériel de la structure Panneau avant Collecteur 2. Thermometer 19. Left Door 36. Right Frame Panel Termómetro Puerta izquierda Panel derecho del bastidor Thermomètre Porte gauche Pannaeau de coffrage droit 3. Thermometer Bezel 20. Right Door 37. Manifold Hose Aro biselado del termómetro Puerta d
Summary of the content on the page No. 6
EXPLODED VIEW E/S/EP - 320 6 1 2 3 4 24 5 6 25 7 26 27 8 28 9 29 30 31 10 11 32 33 12 34 13 35 36 14 37 15 38 39 16 17 18 40 19 20 41 21 42 43 22 44 45 23 46 ® WWW.WEBER.COM
Summary of the content on the page No. 7
EXPLODED VIEW LIST E/S/EP - 320 7 LISTA DEL DIAGRAMA DE DESPIECE, LISTE DE LA VISION ÉCLATÉE 7 1. Shroud Hardware 18. Disposable Drip Pan 35. Back Panel Accesorios de la cubierta Bandeja de goteo desechable Panel posterior Matériel de la structure Egouttoir jetable Panneau arrière 2. Thermometer 19. Catch Pan 36. Natural Gas Hose Termómetro Plato recolector Manguera del gas natural Thermomètre Egouttoir Tuyau à gaz naturel 3. Thermometer Bezel 20. Front Panel 37. Manifold Aro biselado del
Summary of the content on the page No. 8
GENERAL INSTRUCTIONS 8 ® ® Your Weber gas barbecue is a portable outdoor cooking appliance. With the Weber GENERAL INSTRUCTIONS OPERATING gas barbecue you can grill, barbecue, roast and bake with results that are diffi cult to WARNING: Only use this barbecue outdoors in a well- ® duplicate with indoor kitchen appliances. The closed lid and Flavorizer bars produce ventilated area. Do not use in a garage, building, breezeway that “outdoor” fl avor in the food. ® The Weber gas barbecue is porta
Summary of the content on the page No. 9
GENERAL INSTRUCTIONS 9 Slide out Bottom tray - Remove excess grease, then wash with warm soapy water, Preserve Your Stainless Steel GENERAL INSTRUCTIONS then rinse. Your grill or its cabinet, lid, control panel and shelves may be made from stainless steel. 9 To keep the stainless steel looking its best is a simple matter. Clean it with soap and ® Flavorizer bars and Cooking grates - Clean with a suitable brass bristle brush. As water, rinse with clear water and wipe dry. For stubborn particle
Summary of the content on the page No. 10
GAS INSTRUCTIONS 10 TYPE OF GAS 345 2 6 1 Your natural gas grill is factory built to operate using natural gas only. Never attempt to operate your grill on gases other than the type specifi ed on the grill rating plates. Your grill operates at 7” of water column pressure. If replacement of the hose becomes necessary, factory specifi ed parts are required. See your local dealer. ® For safety and design reasons, the conversion of a Weber grill from operation using Natural gas to operation using L
Summary of the content on the page No. 11
GAS INSTRUCTIONS 11 CHECK THE FLEXIBLE HOSE TO MANIFOLD CONNECTION The natural gas hose has been attached during the manuafacturing process. We 11 do recommend that the hose to gas manifold connnection be leak tested, following (1) guidelines in this Owner’s Guide, prior to barbecue operation. CHECK FOR GAS LEAKS DANGER Do not use an open fl ame to check for gas leaks. Be sure (2) there are no sparks or open fl ames in the area while you check for leaks. Sparks or open fl ames will result in
Summary of the content on the page No. 12
12 GAS INSTRUCTIONS Check: GAS INSTRUCTIONS 1) Hose to manifold connection 2) Side burner hose to manifold connection and side burner hose to side burner gas 320 line connection. * The grill illustrated may WARNING: If there is a leak at connection (1), retighten the have slight differences fi tting with a wrench and recheck for leaks with soap and than the model purchased. water solution. If a leak persists after retightening the fi tting, turn OFF the gas. DO NOT OPERATE THE GRILL. Conta
Summary of the content on the page No. 13
O O D D A A G G A A P P A A OPERATING INSTRUCTIONS 13 MAIN BURNER LIGHTING MAIN BURNER LIGHTING 13 1) Open the lid. 2) Make sure all burner control knobs are turned OFF. (Push control knob down and turn clockwise to ensure that it is in the OFF position.) 2 3) Turn the gas supply valve on. 1 WARNING: Do not lean over the open barbecue. Keep your face and body at least one foot away from the matchlight hole when lighting the barbecue. 4 4) Push BURNER 1 control knob down and turn to START/HI
Summary of the content on the page No. 14
14 OPERATING INSTRUCTIONS LIGHTING THE SIDE BURNER OPERATING INSTRUCTIONS 320 DANGER Failure to open the lid while igniting the side burner, or not waiting 5 minutes to allow the gas to clear if the side burner does not light, may result in an explosive fl ame-up which can cause serious bodily injury or death. WARNING: Check hose before each use of barbecue for nicks, cracking, abrasions or cuts. If the hose is found to be damaged ® 1 in any way, do not use the barbecue. Replace using on
Summary of the content on the page No. 15
TROUBLESHOOTING 15 PROBLEM CHECK CURE 15 Burners burn with a yellow or orange fl ame, in Inspect Spider / Insect Screens for possible obstructions. Clean Spider / Insect Screens. (See Section “Annual conjunction with the smell of gas. (Blockage of holes.) Maintenance”) Burner does not light, or fl ame is low in “HI” Is fuel hose bent or kinked? Straighten fuel hose. position. Does the burner light with a match? If you can light the Left burner with a match, then check the electronic ignition sy
Summary of the content on the page No. 16
16 MAINTENANCE SIDE BURNER MAINTENANCE (3) WARNING: All gas controls and supply valves should be in the “OFF” position. Make sure black wire is connected between the igniter and electrode. Make sure white wire is connected between the igniter and grounding clip. (1) Spark should be a white/blue color, not yellow. (2) 1) Igniter Wire 2) Ground wire 3) Burner Side Burner Grate Side Burner Grate Side Burner Cap Side Burner cap Side Burner Ring & Head Side Burner Ring & Head Igniter Electrode Ign
Summary of the content on the page No. 17
MAINTENANCE 17 MAIN BURNER FLAME PATTERN ® 17 The Weber gas barbecue burners have been factory set for the correct air and gas mixture. The correct fl ame pattern is shown. 1) Burner tube 2) Tips occasionally fl icker yellow 1 3) Light blue 4) Dark blue 2 If the fl ames do not appear to be uniform throughout the burner tube, follow the burner cleaning procedures. 3 4 MAIN BURNER CLEANING PROCEDURE Turn off the gas supply. Remove the manifold (See “Replace Main Burners”). Look inside each burner
Summary of the content on the page No. 18
18 MAINTENANCE 5) Slide the burner assembly out from under the guide screw and washer (a) in the corners of the cooking box. a 6) Lift and twist the burner assembly slightly, to separate the crossover tube (b) from the burners. Remove the burners from the cooking box. 7) To reinstall the burners, reverse 3) through 7). CAUTION: The burner openings (c) must be positioned properly over the valve orifi ces (d). Check proper assembly before fastening manifold in place. WARNING: After reinstall
Summary of the content on the page No. 19
BARBACOA DE GAS Guía del Propietario de la Barbacoa de Gas Natural E/S -310/320, EP -310/320 #89557 #00000 ADVERTENCIA: Antes de poner DEBE LEER ESTA GUÍA DEL PROPIETARIO a funcionar la barbacoa, siga ANTES DE PONER A FUNCIONAR LA cuidadosamente todos los procedimientos BARBACOA DE GAS en este manual para verifi car que no existan fugas. Haga esto aun y cuando PELIGRO la barbacoa haya sido ensamblada por el Si usted huele gas: distribuidor. 1. Cierre el suministro de gas al artefact
Summary of the content on the page No. 20
20 ADVERTENCIAS DANGERS AND WARNINGS PELIGRO El hacer caso omiso de los avisos de peligros, advertencias y precauciones contenidos en este Manual del Propietario pudiera resultar en lesiones corporales serias o la muerte, o en un fuego o explosión que cause daños a la propiedad. ADVERTENCIAS No almacene un tanque de propano licuado desconectado o de repuesto debajo o cerca de este asador. El ensamblaje incorrecto puede ser peligroso. Por favor siga cuidadosamente las instrucciones de e
