Summary of the content on the page No. 1
GAS GRILL
Natural Gas Grill Owner’s Guide
Guía del Propietario de la Barbacoa de Gas Natural - Pg 32
Guide de l’utilisateur du barbecue au gaz naturel - Pg 53
Assembly, Ensamblaje, Assemblage - Pg 9
S-620/650
#89565
WARNING: Follow all leak-check
YOU MUST READ THIS OWNER’S GUIDE
procedures carefully in this manual prior
BEFORE OPERATING YOUR GAS GRILL
to barbecue operation. Do this even if the
barbecue was dealer-assembled.
DANGER
If you smell gas:
1. Shut off gas to the appliance.
NOT
Summary of the content on the page No. 2
2 WARNINGS DANGERS AND WARNINGS DANGER Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or death, or in a fi re or an explosion causing damage to property. WARNINGS Do not store a spare or disconnected liquid propane cylinder under or near this barbecue. Improper assembly may be dangerous. Please follow the assembly instructions carefully. ® After a period of storage, and/or nonuse, the Weber gas barbecue shoul
Summary of the content on the page No. 3
WARRANTY, GARANTÍA, GARANTIE 3 ® Weber-Stephen Products Co. (Weber) hereby warrants to the ORIGINAL PURCHASER of this Weber This Limited Warranty does not cover any failures or operating diffi culties due to accident, abuse, WARRANTY gas grill that it will be free of defects in material and workmanship from the date of purchase as follows: misuse, alteration, misapplication, vandalism, improper installation or improper maintenance or 3 service, or failure to perform normal and routine maintena
Summary of the content on the page No. 4
4 PARTS LIST, LISTE DES PIÈCES, LISTA DE PIEZAS Catch Pan Holder Drip Tray 1 1 1 1 Sostenedor del plato recolector Bandeja de goteo Support de l’égouttoir Plateau de recueil des gouttes ® Flavorizer Bar 13 12 Catch Pan 1 1 ® Barras Flavorizer Plato recolector ® Barre Flavorizer Egouttoir Smoker Bar - 1 Cooking Grate 3 3 Barra del ahumador Parrilla de cocción Barre du fumoir Grille de cuisson Smoker Box - 1 Caja del ahumador Warming Rack 1 1 Boîtier du fumoir Rejilla para calentar Grille de main
Summary of the content on the page No. 5
EXPLODED VIEW S-620 5 VISION ÉCLATÉE, DIAGRAMA DE DESPIECE 5 S620_NG_US ® WWW.WEBER.COM
Summary of the content on the page No. 6
6 EXPLODED VIEW LIST S-620 LISTA DEL DIAGRAMA DE DESPIECE, LISTE DE LA VISION ÉCLATÉE 1. Shroud Hardware 21. Catch Pan Holder 40. Caster Accesorios de la cubierta Soporte del plato recolector Rueda giratoria Roulette Structure de protection Support d’égouttoir 2. Shroud 22. Left Door 41. Locking Caster Cubierta Puerta izquierda Rueda giratoria con bloqueo Tôle de protection Porte gauche Roulette autobloquante 3. Thermometer 23. Door Handles Termómetro Asas de las puertas Thermomètre Poignées de
Summary of the content on the page No. 7
EXPLODED VIEW S-650 7 VISION ÉCLATÉE, DIAGRAMA DE DESPIECE 7 S650_NG_US ® WWW.WEBER.COM
Summary of the content on the page No. 8
8 EXPLODED VIEW LIST S-650 LISTA DEL DIAGRAMA DE DESPIECE, LISTE DE LA VISION ÉCLATÉE 1. Shroud Hardware 40. Smoker Bar 21. Water Baffl e / Heat Shield Barra del ahumador Accesorios de la cubierta Refl ector de agua / Pantalla térmica Barre du fumoir Structure de protection Protection contre l’eau/Cloison anti-chaleur 2. Shroud 41. Smoker Burner 22. Disposable Drip Pan Quemador del ahumador Cubierta Bandeja de goteo desechable Brûleur du fumoir Tôle de protection Egouttoir jetable 3. Thermometer
Summary of the content on the page No. 9
9 ASSEMBLY, ASSEMBLAGE, ENSAMBLAJE • Adjust doors, if necessary 9 • Si fuese necesario, ajuste la puerta 1 • Ajustez la porte si nécessaire 2 4 3 S-650 4 - 4 - 5 ® WWW.WEBER.COM
Summary of the content on the page No. 10
10 ASSEMBLY, ASSEMBLAGE, ENSAMBLAJE 6 3 - 3 - 7 8 ® WWW.WEBER.COM
Summary of the content on the page No. 11
ASSEMBLY, ASSEMBLAGE, ENSAMBLAJE 11 11 9 S-650 2 - 2 - 10 (1) 11 (2) (3) ® WWW.WEBER.COM
Summary of the content on the page No. 12
+ + + 12 ASSEMBLY, ASSEMBLAGE, ENSAMBLAJE AAA 12 AAA 2 - 1 - AAA ™ The Weber Grill Out Handle Light has a “Tilt Sensor”: Lid up - ON / Lid Closed - OFF. The power button (a) activates or deactivates the “Tilt Sensor.” For daytime use, deactivate the sensor by a pressing power button (a). ™ La Lámpara de Asa Weber Grill Out tiene un “sensor de inclinación”: tapa abierta - ENCENDIDA / tapa cerrada - APAGADA. El botón de encendido (a) activa o desactiva al “sensor de inclinación”. Pa
Summary of the content on the page No. 13
GENERAL INSTRUCTIONS 13 ® ® Your Weber gas barbecue is a portable outdoor cooking appliance. With the Weber OPERATING gas barbecue you can grill, barbecue, roast and bake with results that are diffi cult to WARNING: Only use this barbecue outdoors in a well- 13 ® duplicate with indoor kitchen appliances. The closed lid and Flavorizer bars produce ventilated area. Do not use in a garage, building, breezeway that “outdoor” fl avor in the food. ® The Weber gas barbecue is portable so you can ea
Summary of the content on the page No. 14
14 GENERAL INSTRUCTIONS Slide out Bottom tray - Remove excess grease, then wash with warm soapy water, Do not use cleaners that contain acid, mineral spirits or xylene. Rinse well after then rinse. cleaning. ® Flavorizer bars and Cooking grates - Clean with a suitable brass bristle brush. As Preserve Your Stainless Steel needed, remove from grill and wash with warm soapy water, then rinse with water. Your grill or its cabinet, lid, control panel and shelves may be made from stainless steel. T
Summary of the content on the page No. 15
GAS INSTRUCTIONS 15 TYPE OF GAS 345 2 6 1 Your natural gas grill is factory built to operate using natural gas only. Never attempt to 15 operate your grill on gases other than the type specifi ed on the grill rating plates. Your grill operates at 4.5” of water column pressure. If replacement of the hose becomes necessary, factory specifi ed parts are required. See your local dealer. ® For safety and design reasons, the conversion of a Weber grill from operation using Natural gas to operation us
Summary of the content on the page No. 16
16 GAS INSTRUCTIONS 2) Remove the two screws that secure the control panel to the frame. 3) Remove the control panel. Tilt panel forward and lift up and away from grill. Completely remove the control panel (3) from the cooking box assembly exposing the valves, burners, igniter, and manifold. 3 2 1 CHECK THE FLEXIBLE HOSE TO MANIFOLD CONNECTION The natural gas hose has been attached during the manuafacturing process. We do recommend that the hose to gas manifold connnection be leak tested, f
Summary of the content on the page No. 17
GAS INSTRUCTIONS 17 Check: 1) Bulkhead and gas supply hose connection. 17 S-620 2) Bulkhead to regulator connection. 3) Regulator to hose connection. 1 4) Main gas line to manifold connections. WARNING: If there is a leak at connection (1, 2, 3, or 4), retighten the fi tting with a wrench and recheck for leaks with soap and water solution. 2 If a leak persists after re-tightening the fi tting, turn off the gas. DO NOT OPERATE THE GRILL. Contact the Customer Service Representative in your
Summary of the content on the page No. 18
GAS INSTRUCTIONS 18 Check: S-650 1) Main gas line to manifold connection. 2) Rotisserie (I.R. Burner) gas line connection. 3) Bulkhead and gas supply hose connection. 4) Bulkhead to regulator connection. 5) Regulator to hose connection. WARNING: If there is a leak at connection (1, 2, 3, 4, or 5), retighten the fi tting with a wrench and recheck for leaks with soap and water solution. If a leak persists after re-tightening the fi tting, turn off the gas. 2 DO NOT OPERATE THE GRILL. Contact
Summary of the content on the page No. 19
OPERATING INSTRUCTIONS 19 GRILLING METHODS ARRÊTÉ 19 Note: If grill looses heat while cooking refer to the troubleshooting section of this manual. OFF You can adjust the individual burners as desired. The control settings are START/HI, APAGADO MEDIUM, LOW, or OFF. If burners go out during cooking, turn off all burners and wait 5 minutes before relighting. WARNING: Check the bottom tray and catch pan for grease build-up before each use. Remove excess grease to avoid a grease fi re in the bo
Summary of the content on the page No. 20
20 OPERATING INSTRUCTIONS GRILLING TIPS & HELPFUL HINTS � Always preheat the grill before cooking. Set all burners on “HI” heat and close lid; � Trim excess fat from steaks, chops and roasts, leaving no more than a scant ¼ inch heat for 10 minutes, or until thermometer registers 500˚-550˚F (260˚-288˚C). (6.4mm) of fat. Less fat makes cleanup easier, and is a virtual guarantee against � Sear meats and cook with the lid down for perfectly grilled food every time. unwanted fl are-ups. � Grilling
