Summary of the content on the page No. 1
®
GENESIS
Natural Gas Grill Owners Guide
YOU MUST READ THIS OWNERS GUIDE
#
BEFORE OPERATING YOUR GAS GRILL
DANGER
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flames.
3. Open lid
4. If odor continues, keep away from the
appliance and immediately call your gas
supplier or your fire department.
Leaking gas may cause a fire or explosion
which can cause serious bodily injury or
death, or damage to property.
WARNING
1. Do not store spare liquid propane
cylinder withi
Summary of the content on the page No. 2
Dangers & Warnings DANGER Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to property. WARNINGS Do not store a spare or disconnected liquid propane cylinder under or near this barbecue. Improper assembly may be dangerous. Please carefully follow the assembly instructions in this manual. ® After a period of storage, and/or nonuse, the Weber gas barbecue shoul
Summary of the content on the page No. 3
Contents Danger & Warnings..................................................................................A-2 Warranty ..................................................................................................A-4 General Instructions .................................................................................A-5 Cooking ...................................................................................................A-6 Cleaning ...................................................
Summary of the content on the page No. 4
Warranty Weber-Stephen Products Co. (Weber) hereby warrants to There are no other express warrants except as set forth ® herein and any applicable implied warranties of the ORIGINAL PURCHASER of this Weber gas grill that it merchantability and fitness are limited in duration to the will be free of defects in material and workmanship from period of coverage of this express written Limited Warranty. the date of purchase as follows: Some regions do not allow limitation on how long an implied warran
Summary of the content on the page No. 5
General Instructions ® Your Weber gas barbecue is a portable outdoor cooking Storage ® appliance. With the Weber gas barbecue you can grill, The gas must be turned OFF at the natural gas ® barbecue, roast and bake with results that are difficult to supply when the Weber gas barbecue is not in use. ® duplicate with indoor kitchen appliances. The closed lid When the Weber gas barbecue is stored indoors, ® and Flavorizer bars produce that “outdoor” flavor in the the gas supply must be disconne
Summary of the content on the page No. 6
General Instructions Cooking Cleaning ® ® WARNING: Do not move the Weber gas barbecue WARNING: Turn your Weber gas barbecue OFF and when operating or while barbecue is hot. wait for it to cool before cleaning. ® You can adjust the FRONT and BACK burners as desired. CAUTION: Do not clean your Flavorizer bars or The control settings: High (H), Medium (M), Low (L), or Off cooking grates in a self-cleaning oven. ® (O) are described in your Weber cookbook. The cookbook For availability of repla
Summary of the content on the page No. 7
Exploded View ® 1 Genesis Silver-A NG 100401 2 3 25 26 4 27 5 28 6 29 7 30 8 31 32 33 9 34 10 35 11 36 12 13 14 37 15 38 16 39 17 40 41 31 18 42 19 20 43 21 44 22 45 23 24 46 A-7
Summary of the content on the page No. 8
Exploded View List 1. Hinge Pin 24. Hubcap 2. Left Endcap 25. Hair Pin Cotter 3. Shroud 26. Right Endcap 4. Handle 27. Thermometer 5. Warming Rack 28. Handle Hardware 6. Cooking Grates 29. Control Panel Knobs ® 7. Flavorizer Bars 30. Control Panel 8. Cooking Box 31. Control Panel Hardware ® 9. 1/4-20 keps nut 32. Crossover Ignition Button ® 10. Slide Out Bottom Tray 33. Crossover tube 11. Work Surface 34. Front / Rear Burner 12. Catch Pan Holder 35. Manifold Hardware 13. Left Rear Trim Assembly
Summary of the content on the page No. 9
Parts List Cooking Box Assembly - 1 Right Trim Piece - 1 ® Flavorizer Bars - 5 Warming Rack - 1 Cooking Grate - 2 Caster Frame - 1 Bottom Tray - 1 Catch-Pan Holder - 1 Wheel Frame - 1 Catch-Pan - 1 Disposable Drip Pans - 2 Thermometer - 1 Bottom Rack - 1 1 inch Bolts (1/4 x 20 x 1 inch Bolt) - 6 Nylon Washer - 6 Left Trim Assembly - 1 Wrench - 1 7/16 inch Wrench - 1 Side Table - 1 Hose - 1 A-9
Summary of the content on the page No. 10
Unpacking 1 3 4 2 A-10
Summary of the content on the page No. 11
• Arrow sticker to the front. 1 b a • Push down firmly until Bottom Rack Lock, "locks" under the rail. c Ba201.d B-a
Summary of the content on the page No. 12
2 a b • Push down firmly on both sides to ensure bottom rack is locked under the rails. WARNING: Do not go to next step if bottom rack is not locked in place B-b
Summary of the content on the page No. 13
3 • Install bolts at indicated locations. Use supplied tool to tighten. Finish tightening bolt with metal wrench provided or a 7/16” wrench. B-c
Summary of the content on the page No. 14
4 5 B205_NG.a B-1
Summary of the content on the page No. 15
6 7 a b B-2
Summary of the content on the page No. 16
8 10 9 11 B-3
Summary of the content on the page No. 17
B-4
Summary of the content on the page No. 18
Gas Instructions Gas Line Piping Install Gas Supply If the length of the line required does not exceed 50 General Specifications for Piping feet, use a 5/8" O.D. tube. One size larger should be Note - Contact your local municipality for building used for lengths greater than 50 feet. codes regulating outdoor gas barbecue installations. Gas piping may be copper tubing, type K or L; In absence of Local Codes, you must confirm to the polyethylene plastic tube, with a minimum wall latest editio
Summary of the content on the page No. 19
Gas Instructions Check the flexible hose to manifold connection See Page C-3 Check that all burner valves are off Valves are shipped in the OFF position, but you should The Natural gas hose has been attached during the check to be sure that they are turned OFF. Check by manufacturing process. We do recommend that the hose pushing down and turning clockwise. If they do not turn, to gas manifold connection be leak tested, following they are off. Proceed to the next step. If they do turn guidelin
Summary of the content on the page No. 20
Gas Instructions Gas will not flow unless the quick disconnect is properly Check for gas leaks engaged. Turn on gas supply. DANGER Check for leaks by wetting the connections with the soap Do not use an open flame to check for gas and water solution and watching for bubbles. If bubbles leaks. Be sure there are no sparks or open form or if a bubble grows, there is a leak. Note - Since some leak test solutions, including soap and flames in the area while you check for leaks. water, may be slight
