Summary of the content on the page No. 1
GAS GRILL
LP Gas Grill Owner’s Guide
Guía del propietario del asador de gas licuado de propano - Pg 19
Guide de l’utilisateur du grill à gaz PL - Pg 32
E/EP - 210/310
#89960
#00000
YOU MUST READ THIS OWNER’S GUIDE WARNING: Follow all leak-check
BEFORE OPERATING YOUR GAS GRILL procedures carefully in this manual prior
to barbecue operation. Do this even if the
barbecue was dealer-assembled.
DANGER
If you smell gas:
NOTICE TO INSTALLER: These instructions
1. Shut off gas to the appliance.
Summary of the content on the page No. 2
2 WARNINGS DANGERS AND WARNINGS DANGER Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to property. WARNINGS Do not store a spare or disconnected liquid propane cylinder under or near this barbecue. Improper assembly may be dangerous. Please follow the assembly instructions carefully. ® After a period of storage, and/or nonuse, the Weber gas barbecue should b
Summary of the content on the page No. 3
WARRANTY, GARANTÍA, GARANTIE 3 ® service, or failure to perform normal and routine maintenance, including but not limited to damage Weber-Stephen Products Co. (Weber) hereby warrants to the ORIGINAL PURCHASER of this Weber WARRANTY WARRANTY caused by insects within the burner tubes, as set out in this owner’s manual. gas grill that it will be free of defects in material and workmanship from the date of purchase as follows: Deterioration or damage due to severe weather conditions such as hail,
Summary of the content on the page No. 4
4 EXPLODED VIEW E/EP 210 VISION ÉCLATÉE, DIAGRAMA DE DESPIECE Spirit_210_LP_US_09 ® WWW.WEBER.COM
Summary of the content on the page No. 5
EXPLODED VIEW LIST E/EP 210 5 LISTA DEL DIAGRAMA DE DESPIECE, LISTE DE LA VISION ÉCLATÉE 5 1. Shroud Hardware 18. Front Panel 35. Right Trim Piece Accesorios de la cubierta Panel frontal Pieza de adorno derecha Kit d’assemblage de boîtier Panneau avant Élément de décoration droit 2. Thermometer 19. Left Door 36. Matchstick Holder Termómetro Puerta izquierda Portacerillos Thermomètre Porte gauche Porte-allumettes 3. Thermometer Bezel 20. Right Door 37. Caster Moldura decorativa del termómetro Pue
Summary of the content on the page No. 6
6 EXPLODED VIEW E/EP 310 VISION ÉCLATÉE, DIAGRAMA DE DESPIECE Spirit_310_LP_US_09 ® WWW.WEBER.COM
Summary of the content on the page No. 7
EXPLODED VIEW LIST E/EP 310 7 LISTA DEL DIAGRAMA DE DESPIECE, LISTE DE LA VISION ÉCLATÉE 7 1. Shroud Hardware 18. Front Panel 35. Drip Tray Accesorios de la cubierta Panel frontal Bandeja de goteo Kit d’assemblage de boîtier Panneau avant Bac d’égouttage 2. Thermometer 19. Left Door 36. Right Trim Piece Termómetro Puerta izquierda Pieza de adorno derecha Thermomètre Porte gauche Élément de décoration droit 3. Thermometer Bezel 20. Right Door 37. Matchstick Holder Moldura decorativa del termómetr
Summary of the content on the page No. 8
GENERAL INSTRUCTIONS 8 ® ® ® Your Weber gas barbecue is a portable outdoor cooking appliance. With the Weber WARNING: Your Weber gas barbecue shall not be used GENERAL INSTRUCTIONS gas barbecue you can grill, barbecue, roast and bake with results that are difficult to under overhead combustible construction. ® duplicate with indoor kitchen appliances. The closed lid and Flavorizer Bars produce ® WARNING: Your Weber gas barbecue is not intended to be that “outdoor” flavor in the food. ®
Summary of the content on the page No. 9
GENERAL INSTRUCTIONS 9 Slide out Bottom tray - Remove excess grease, then wash with warm soapy water, Preserve Your Stainless Steel - Your grill or its cabinet, lid, control panel and shelves GENERAL INSTRUCTIONS then rinse. may be made from stainless steel. To keep the stainless steel looking its best is a 9 simple matter. Clean it with soap and water, rinse with clear water and wipe dry. For ® Flavorizer bars and Cooking grates - Clean with a suitable brass bristle brush. As stubborn parti
Summary of the content on the page No. 10
GAS INSTRUCTIONS 10 To Connect the hose to the cylinder: 1) Open base cabinet doors. 2) Pass the regulator hose through the side panel opening to the inside of the base cabinet. 3) Slide the hose retention bracket (1) along the hose and through the side panel opening to the inside of the base cabinet. 4) Position the hose retention bracket on the right inside panel and secure with two hex/washer/bolts (2). WARNING: The hose must be secured to the side panel with the Hose Retention Bracket
Summary of the content on the page No. 11
GAS INSTRUCTIONS 11 REMOVE CONTROL KNOBS & CONTROL PANEL FOR LEAK TESTING 1 2 11 You will need: Phillips screwdriver. 1) Take off the burner control knobs. 2) Remove screw and washer from back of control panel with a Phillips screwdriver. 3) Remove machine screw from lower left and right side of control panel with a 3 Phillips screwdriver. 4) Tilt the back edge of the control panel up. Carefully lift control panel up and away from frame. 5) Disconnect the igniter wires from the ignition modul
Summary of the content on the page No. 12
12 GAS INSTRUCTIONS Check: 1) Hose-to-manifold connection. 210/310 WARNING: If there is a leak at connection (1), retighten the fitting with a wrench and recheck for leaks with soap and water solution. If a leak persists after retightening the fitting, turn OFF the gas. DO NOT OPERATE THE GRILL. Contact the Customer Service Representative in your area using the contact information on our web site. ® Log onto www.weber.com . 2) Regulator-to-cylinder connection. 3) The hose-to-regulator c
Summary of the content on the page No. 13
GAS INSTRUCTIONS 13 SAFE HANDLING TIPS FOR LIQUID PROPANE GAS WARNING: Replacement LP tanks must match the regulator GAS INSTRUCTIONS CYLINDERS connection supplied with this barbecue. 13 � Liquid Propane (LP) gas is a petroleum product as are gasoline and natural gas. LIQUID PROPANE CYLINDER REQUIREMENTS LP gas is a gas at regular temperatures and pressures. Under moderate pressure, � Check to be sure cylinders have a D.O.T. certification (1), and date tested (2) is inside a cylinder, LP g
Summary of the content on the page No. 14
OPERATING INSTRUCTIONS 14 MAIN BURNER LIGHTING MAIN BURNER LIGHTING 1) Open the lid. 2) Make sure all burner control knobs are turned OFF. (Push control knob down and turn clockwise to ensure that it is in the OFF position.) 2 5 OFF APAGADO WARNING: The burner control knobs must be in the OFF ARRETE 1 position before turning on the liquid propane cylinder tank valve. If they are not in the OFF position, when you turn on the LP cylinder valve, the “excess gas flow control” feature 4 will
Summary of the content on the page No. 15
OPERATING INSTRUCTIONS 15 DANGER MAIN BURNER MANUAL LIGHTING 15 When the “excess gas flow control” feature is activated, 2 a small amount of gas is still flowing to the burners. After OFF APAGADO turning OFF the cylinder and burner control knobs, wait at ARRETE 1 least 5 minutes for the gas to clear before attempting to light the barbecue. Failure to do so may result in an explosive 1 flame-up, which can cause serious bodily injury or death. 5 3) Turn the cylinder on by turning the cylin
Summary of the content on the page No. 16
MAINTENANCE 16 ® WEBER SPIDER/INSECT SCREENS ® Your Weber gas barbecue, as well as any outdoor gas appliance, is a target for spiders and other insects. They can nest in the venturi section (1) of the burner tubes. This blocks the normal gas flow, and can cause the gas to flow back out of the combustion air opening. This could result in a fire in and around the combustion air openings, under the control panel, causing serious damage to your barbecue. The burner tube combustion air opening is
Summary of the content on the page No. 17
MAINTENANCE 17 MAIN BURNER CLEANING PROCEDURE 17 Turn off the gas supply. Remove the manifold (See “Replacing Main Burners”). Look inside each burner with a flashlight. Clean the inside of the burners with a wire (a straightened-out coat hanger will work). Check and clean the air shutter opening at the ends of the burners. Check and clean the valve orifices at the base of the valves. Use a Steel bristle brush to clean outside of burners. This is to make sure all the burner ports are fully op
Summary of the content on the page No. 18
MAINTENANCE 18 4) Remove the two nuts (a) that hold the manifold support bracket to the cooking box. Allow the manifold support bracket to pivot down away from the cookbox, releasing the valve assembly from the burners (b). a b 5) Slide the burner assembly out from under the guide screw and washer (a) in the corners of the cooking box. 6) Lift and twist the burner assembly slightly, to separate the crossover tube (b) from the burners. Remove the burners from the cooking box. 7) To reinstall
Summary of the content on the page No. 19
BARBACOA DE GAS Guía del Propietario de la Barbacoa de Gas Propano Licuado E/EP - 210/310 #89960 #00000 DEBE LEER ESTA GUÍA DEL PROPIETARIO NOTA IMPORTANTE: Antes de ANTES DE PONER A FUNCIONAR LA poner a funcionar la asador, BARBACOA DE GAS siga cuidadosamente todos los procedimientos en este manual para PELIGRO verificar que no existan fugas. Haga esto aun y cuando la asador haya sido Si huele a gas: ensamblada por el distribuidor. 1. Cierre el suministro de gas al artefacto. 2. Apa
Summary of the content on the page No. 20
20 ADVERTENCIAS DANGERS AND WARNINGS PELIGRO El hacer caso omiso de los avisos de peligros, advertencias y precauciones contenidos en este Manual del Propietario pudiera resultar en lesiones corporales serias o la muerte, o en un fuego o explosión que cause daños a la propiedad. ADVERTENCIAS No almacene un tanque de propano licuado desconectado o de repuesto debajo o cerca de este asador. El ensamblaje incorrecto puede ser peligroso. Por favor siga cuidadosamente las instrucciones de en
