Summary of the content on the page No. 1
GAS GRILL
Natural Gas Grill Owner’s Guide
Guía del Propietario de la Barbacoa de Gas Natural - Pg 32
Guide de l’utilisateur du barbecue au gaz naturel - Pg 53
Assembly, Ensamblaje, Assemblage - Pg 9
E/S-620/650
#89565
YOU MUST READ THIS OWNER’S GUIDE WARNING: Follow all leak-check
BEFORE OPERATING YOUR GAS GRILL procedures carefully in this manual prior
to barbecue operation. Do this even if the
barbecue was dealer-assembled.
DANGER
If you smell gas:
1. Shut off gas to the appliance.
NO
Summary of the content on the page No. 2
2 WARNINGS DANGER Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to property. WARNINGS Do not store a spare or disconnected liquid propane cylinder under or near this barbecue. Improper assembly may be dangerous. Please follow the assembly instructions carefully. ® After a period of storage, and/or nonuse, the Weber gas barbecue should be checked for gas lea
Summary of the content on the page No. 3
WARRANTY, GARANTÍA, GARANTIE 3 ® Weber-Stephen Products Co. (Weber) hereby warrants to the ORIGINAL PURCHASER of this Weber service, or failure to perform normal and routine maintenance, including but not limited to damage WARRANTY gas grill that it will be free of defects in material and workmanship from the date of purchase as follows: caused by insects within the burner tubes, as set out in this owner’s manual. Deterioration or damage due to severe weather conditions such as hail, hurricane
Summary of the content on the page No. 4
4 PARTS LIST, LISTE DES PIÈCES, LISTA DE PIEZAS Catch Pan Holder Drip Tray 1 1 1 1 Sostenedor del plato recolector Bandeja de goteo Support de l’égouttoir Plateau de recueil des gouttes ® Flavorizer Bar Catch Pan 13 12 1 1 ® Barras Flavorizer Plato recolector ® Barre Flavorizer Egouttoir Smoker Bar - 1 Cooking Grate 3 3 Barra del ahumador Parrilla de cocción Barre du fumoir Grille de cuisson Smoker Box - 1 Caja del ahumador Warming Rack 1 1 Boîtier du fumoir Rejilla para calentar Grille de main
Summary of the content on the page No. 5
EXPLODED VIEW E/S-620 5 VISION ÉCLATÉE, DIAGRAMA DE DESPIECE E/S620_NG_US 1 2 3 4 5 6 7 8 9 10 11 12 13 27 14 28 29 15 16 30 31 17 18 19 32 20 33 21 34 22 35 36 23 37 38 24 25 26 39 40 41 ® WWW.WEBER.COM
Summary of the content on the page No. 6
6 EXPLODED VIEW LIST S-620 LISTA DEL DIAGRAMA DE DESPIECE, LISTE DE LA VISION ÉCLATÉE 1. Shroud Hardware 21. Catch Pan Holder 40. Caster Accesorios de la cubierta Soporte del plato recolector Rueda giratoria Support d’égouttoir Roulette Structure de protection 2. Shroud 22. Left Door 41. Locking Caster Cubierta Puerta izquierda Rueda giratoria con bloqueo Porte gauche Roulette autobloquante Tôle de protection 3. Thermometer 23. Door Handles Termómetro Asas de las puertas Poignées de portes Ther
Summary of the content on the page No. 7
EXPLODED VIEW S-650 7 VISION ÉCLATÉE, DIAGRAMA DE DESPIECE E/S 650_NG_US 1 2 31 3 4 32 33 5 6 34 7 35 8 36 9 37 10 38 11 39 12 40 13 41 14 15 42 16 17 43 18 44 19 20 45 21 46 22 23 47 24 25 48 26 49 50 51 27 52 28 53 29 30 54 55 56 ® WWW.WEBER.COM
Summary of the content on the page No. 8
8 EXPLODED VIEW LIST S-650 LISTA DEL DIAGRAMA DE DESPIECE, LISTE DE LA VISION ÉCLATÉE 1. Shroud Hardware 40. Smoker Bar 21. Water Baffle / Heat Shield Barra del ahumador Accesorios de la cubierta Reflector de agua / Pantalla térmica Barre du fumoir Structure de protection Protection contre l’eau/Cloison anti-chaleur 2. Shroud 41. Smoker Burner 22. Disposable Drip Pan Quemador del ahumador Cubierta Bandeja de goteo desechable Brûleur du fumoir Tôle de protection Egouttoir jetable 42. Side Burner
Summary of the content on the page No. 9
9 ASSEMBLY, ASSEMBLAGE, ENSAMBLAJE • Adjust doors, if necessary • Si fuese necesario, ajuste la puerta 1 • Ajustez la porte si nécessaire 2 3 4 E/S-650 4 - 4 - 5 ® WWW.WEBER.COM
Summary of the content on the page No. 10
10 ASSEMBLY, ASSEMBLAGE, ENSAMBLAJE 3 - 3 - 6 7 8 ® WWW.WEBER.COM
Summary of the content on the page No. 11
ASSEMBLY, ASSEMBLAGE, ENSAMBLAJE 11 9 E/S-650 2 - 2 - 10 11 ® WWW.WEBER.COM
Summary of the content on the page No. 12
+ + + 12 ASSEMBLY, ASSEMBLAGE, ENSAMBLAJE AAA 12 AAA 2 - 1 - AAA ™ The Weber Grill Out Handle Light has a “Tilt Sensor”: Lid up - ON / Lid Closed - OFF. The power button (a) activates or deactivates the “Tilt Sensor.” For daytime use, deactivate the sensor by pressing power button (a). ™ La Lámpara de Asa Weber Grill Out tiene un “sensor de inclinación”: tapa abierta - ENCENDIDA / tapa cerrada - APAGADA. El botón de encendido (a) activa o desactiva al “sensor de inclinación”. Para
Summary of the content on the page No. 13
GENERAL INSTRUCTIONS 13 ® ® Your Weber gas barbecue is a portable outdoor cooking appliance. With the Weber OPERATING gas barbecue you can grill, barbecue, roast and bake with results that are difficult to ® WARNING: Only use this barbecue outdoors in a well- duplicate with indoor kitchen appliances. The closed lid and Flavorizer bars produce that “outdoor” flavor in the food. ventilated area. Do not use in a garage, building, breezeway ® The Weber gas barbecue is portable so you can easil
Summary of the content on the page No. 14
14 GENERAL INSTRUCTIONS Slide out Bottom tray - Remove excess grease, then wash with warm soapy water, Do not use cleaners that contain acid, mineral spirits or xylene. Rinse well after then rinse. cleaning. ® Flavorizer bars and Cooking grates - Clean with a suitable brass bristle brush. As Preserve Your Stainless Steel - Your grill or its cabinet, lid, control panel and shelves needed, remove from grill and wash with warm soapy water, then rinse with water. may be made from stainless steel.
Summary of the content on the page No. 15
GAS INSTRUCTIONS 15 TYPE OF GAS Your natural gas grill is factory built to operate using natural gas only. Never attempt to operate your grill on gases other than the type specified on the grill rating plates. Your grill operates at 4.5” of water column pressure. If replacement of the hose becomes necessary, factory specified parts are required. See your local dealer. ® For safety and design reasons, the conversion of a Weber grill from operation using Natural gas to operation using LP gas re
Summary of the content on the page No. 16
16 GAS INSTRUCTIONS 2) Remove the two screws that secure the control panel to the frame. 3) Remove the control panel. Tilt panel forward and lift up and away from grill. Completely remove the control panel (3) from the cooking box assembly exposing the valves, burners, igniter, and manifold. 3 2 1 CHECK THE FLEXIBLE HOSE TO MANIFOLD CONNECTION The natural gas hose has been attached during the manuafacturing process. We do recommend that the hose to gas manifold connnection be leak tested, fo
Summary of the content on the page No. 17
GAS INSTRUCTIONS 17 CHECK: 1) Bulkhead and gas supply hose connection. E/S-620 2) Bulkhead to regulator connection. 3) Regulator to hose connection. 4) Main gas line to manifold connections. WARNING: If there is a leak at connection (1, 2, 3, or 4), retighten the fitting with a wrench and recheck for leaks with soap and water solution. If a leak persists after re-tightening the fitting, turn off the gas. DO NOT OPERATE THE GRILL. Contact the Customer Service Representative in your area
Summary of the content on the page No. 18
GAS INSTRUCTIONS 18 CHECK: 1) Main gas line to manifold connection. E/S-650 2) Rotisserie (I.R. Burner) gas line connection. 3) Bulkhead and gas supply hose connection. 4) Bulkhead to regulator connection. 5) Regulator to hose connection. WARNING: If there is a leak at connection (1, 2, 3, 4, or 5), retighten the fitting with a wrench and recheck for leaks with soap and water solution. If a leak persists after re-tightening the fitting, turn off the 2 gas. DO NOT OPERATE THE GRILL. Conta
Summary of the content on the page No. 19
OPERATING INSTRUCTIONS 19 GRILLING METHODS Note: If grill looses heat while cooking refer to the troubleshooting section of this manual. You can adjust the individual burners as desired. The control settings are START/HI, MEDIUM, LOW, or OFF. If burners go out during cooking, turn off all burners and wait 5 minutes before relighting. WARNING: Check the bottom tray and catch pan for grease build-up before each use. Remove excess grease to avoid a grease fire in the bottom tray. PREHEATING D
Summary of the content on the page No. 20
20 OPERATING INSTRUCTIONS GRILLING TIPS & HELPFUL HINTS • Always preheat the grill before cooking. Set all burners on “HI” heat and close lid; • Foods placed on the cooking grate directly above burners may require turning or heat for 10 minutes, or until thermometer registers 500˚-550˚F (260˚-288˚C). moving to a less hot area. • Sear meats and cook with the lid down for perfectly grilled food every time. • Use tongs rather than a fork for turning and handling meats to avoid losing natural • G
