Summary of the content on the page No. 1
GAS GRILL
LP Gas Grill Owner’s Guide
Guía del propietario del asador de gas licuado de propano - Pg 34
Guide de l’utilisateur du grill à gaz PL - Pg 57
Assembly, Ensamblaje, Assemblage - Pg 9
S-420/450
#89559
WARNING: Follow all leak-check
YOU MUST READ THIS OWNER’S GUIDE
procedures carefully in this manual prior
BEFORE OPERATING YOUR GAS GRILL
to barbecue operation. Do this even if the
barbecue was dealer-assembled.
DANGER
If you smell gas:
1. Shut off gas to the appliance.
NOTICE TO
Summary of the content on the page No. 2
2 WARNINGS DANGERS AND WARNINGS DANGER Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or death, or in a fi re or an explosion causing damage to property. WARNINGS Do not store a spare or disconnected liquid propane cylinder under or near this barbecue. Improper assembly may be dangerous. Please follow the assembly instructions carefully. ® After a period of storage, and/or nonuse, the Weber gas barbecue shoul
Summary of the content on the page No. 3
WARRANTY, GARANTÍA, GARANTIE 3 ® Weber-Stephen Products Co. (Weber) hereby warrants to the ORIGINAL PURCHASER of this Weber misuse, alteration, misapplication, vandalism, improper installation or improper maintenance or WARRANTY gas grill that it will be free of defects in material and workmanship from the date of purchase as follows: service, or failure to perform normal and routine maintenance, including but not limited to damage 3 caused by insects within the burner tubes, as set out in th
Summary of the content on the page No. 4
4 PARTS LIST, LISTE DES PIÈCES, LISTA DE PIEZAS Catch Pan Holder Drip Tray 1 1 1 1 Sostenedor del plato recolector Bandeja de goteo Support de l’égouttoir Plateau de recueil des gouttes ® Flavorizer Bar Catch Pan 1 1 ® 9 8 Barras Flavorizer Plato recolector ® Barre Flavorizer Egouttoir Smoker Bar Cooking Grate - 1 2 2 Barra del ahumador Parrilla de cocción Barre du fumoir Grille de cuisson Smoker Box - 1 Caja del ahumador Warming Rack 1 1 Boîtier du fumoir Rejilla para calentar Grille de mainti
Summary of the content on the page No. 5
EXPLODED VIEW S-420 5 VISION ÉCLATÉE, DIAGRAMA DE DESPIECE S420_LP_US 5 ® WWW.WEBER.COM
Summary of the content on the page No. 6
6 EXPLODED VIEW LIST S-420 LISTA DEL DIAGRAMA DE DESPIECE, LISTE DE LA VISION ÉCLATÉE 1. Shroud Hardware 19. Drip Tray 37. Frame Support Accesorios de la cubierta Soporte del bastidor Bandeja de goteo Structure de protection Support du cadre Plateau-égouttoir 2. Shroud 20. Catch Pan 38. Back Panel Cubierta Panel trasero Plato recolector Panneau arrière Tôle de protection Egouttoir 3. Thermometer 21. Catch Pan Holder 39. Right Frame Panel Termómetro Panel derecho del bastidor Soporte del plato r
Summary of the content on the page No. 7
EXPLODED VIEW S-450 7 VISION ÉCLATÉE, DIAGRAMA DE DESPIECE 7 S450_LP_US ® WWW.WEBER.COM
Summary of the content on the page No. 8
8 EXPLODED VIEW LIST S-450 LISTA DEL DIAGRAMA DE DESPIECE, LISTE DE LA VISION ÉCLATÉE 1. Shroud Hardware 21. Water Baffl e / Heat Shield 41. Side Burner Accesorios de la cubierta Refl ector de agua / Pantalla térmica Quemador lateral Structure de protection Protection contre l’eau/Cloison anti-chaleur Brûleur latéral 2. Shroud 22. Disposable Drip Pan 42. Cookbox Cubierta Bandeja de goteo desechable Caja de cocción Tôle de protection Egouttoir jetable Boîtier de cuisson 3. Thermometer 23. Drip Tra
Summary of the content on the page No. 9
ASSEMBLY, ASSEMBLAGE, ENSAMBLAJE 9 • Adjust doors, if necessary 9 • Si fuese necesario, ajuste la puerta 1 • Ajustez la porte si nécessaire 2 3 4 S-450 4 - 4 - 5 ® WWW.WEBER.COM
Summary of the content on the page No. 10
10 ASSEMBLY, ASSEMBLAGE, ENSAMBLAJE 6 3 - 3 - 7 8 ® WWW.WEBER.COM
Summary of the content on the page No. 11
ASSEMBLY, ASSEMBLAGE, ENSAMBLAJE 11 11 9 S-450 2 - 2 - 10 (1) 11 (2) (3) ® WWW.WEBER.COM
Summary of the content on the page No. 12
+ + + 12 ASSEMBLY, ASSEMBLAGE, ENSAMBLAJE AAA 12 AAA 2 - 1 - AAA ™ The Weber Grill Out Handle Light has a “Tilt Sensor”: Lid up - ON / Lid Closed - OFF. The power button (a) activates or deactivates the “Tilt Sensor.” For daytime use, deactivate the sensor by a pressing power button (a). ™ La Lámpara de Asa Weber Grill Out tiene un “sensor de inclinación”: tapa abierta - ENCENDIDA / tapa cerrada - APAGADA. El botón de encendido (a) activa o desactiva al “sensor de inclinación”. Pa
Summary of the content on the page No. 13
GENERAL INSTRUCTIONS 13 ® ® Your Weber gas barbecue is a portable outdoor cooking appliance. With the Weber STORAGE AND/OR NONUSE ® gas barbecue you can grill, barbecue, roast and bake with results that are diffi cult to • The gas must be turned off at the liquid propane cylinder when the Weber gas 13 ® duplicate with indoor kitchen appliances. The closed lid and Flavorizer Bars produce barbecue is not in use. that “outdoor” fl avor in the food. ® • When the Weber gas barbecue is stored indoor
Summary of the content on the page No. 14
14 GENERAL INSTRUCTIONS Slide out Bottom tray - Remove excess grease, then wash with warm soapy water, Do not use cleaners that contain acid, mineral spirits or xylene. Rinse well after cleaning. then rinse. ® Flavorizer bars and Cooking grates - Clean with a suitable brass bristle brush. As Preserve Your Stainless Steel needed, remove from grill and wash with warm soapy water, then rinse with water. Your grill or its cabinet, lid, control panel and shelves may be made from stainless steel.
Summary of the content on the page No. 15
GAS INSTRUCTIONS 15 GAS INSTRUCTIONS To Connect the hose to the cylinder: 15 1) Locate hose retention clip (a) on regulator hose. Secure into slot (b) on underside of tank scale. WARNING: The hose must be secured to the tank scale with the Hose Retention Clip. Failure to do so could cause damage to the hose resulting in a fi re or explosion which can cause serious bodily injury or death, and damage to property. Some LP tanks have differing top collar assembles. (The top collar is the met
Summary of the content on the page No. 16
16 GAS INSTRUCTIONS CHECK FOR GAS LEAKS ® WARNING: The gas connections of your Summit gas grill have been factory tested. We do however recommend that you leak check all gas connections before operating your ® Summit gas grill. REMOVE CONTROL PANEL Part required: Phillips Screwdriver. 1) Remove the burner control knobs. 2) Remove the two screws that secure the control panel to the frame. 3) Remove the control panel. Tilt panel forward and lift up and away from grill. Completely remove t
Summary of the content on the page No. 17
GAS INSTRUCTIONS 17 Check: 1) Bulkhead and gas supply hose connection. 17 S-420 2) Main gas line to manifold connections. 1 WARNING: If there is a leak at connection (1, or 2), retighten the fi tting with a wrench and recheck for leaks with soap and water solution. If a leak persists after re-tightening the fi tting, turn off the gas. DO NOT OPERATE THE GRILL. Contact the Customer Service Representative in your area using the contact information on ® our web site. Log onto www.weber.com .
Summary of the content on the page No. 18
18 GAS INSTRUCTIONS Check: 1) Main gas line to manifold connection. S-450 2) Rotisserie (I.R. Burner) gas line connection. 3) Bulkhead and gas supply hose connection. WARNING: If there is a leak at connection (1, 2, or 3), retighten the fi tting with a wrench and recheck for leaks with soap and water solution. If a leak persists after re-tightening the fi tting, turn off the gas. DO NOT OPERATE THE GRILL. Contact the Customer Service Representative in your area using the contact informati
Summary of the content on the page No. 19
GAS INSTRUCTIONS 19 GAS INSTRUCTIONS REFILLING THE LIQUID PROPANE CYLINDER We recommend that you refi ll the LP cylinder before it is completely empty. 19 (3) (1) Removal of the LP cylinder 1) Close cylinder valve (turn clockwise). (2) 2) Unscrew regulator coupling by turning counterclockwise, by hand only. 3) Loosen cylinder lock wing nut and turn cylinder lock up out of the way. 4) Lift cylinder off. To fi ll, take the LP cylinder to a gas propane dealer, or look up “gas-propane” in the phone
Summary of the content on the page No. 20
20 OPERATING INSTRUCTIONS GRILLING METHODS ARRÊTÉ Note: If grill looses heat while cooking refer to the troubleshooting section of this manual. OFF You can adjust the individual burners as desired. The control settings are START/HI, APAGADO MEDIUM, LOW, or OFF. If burners go out during cooking, turn off all burners and wait 5 minutes before relighting. WARNING: Check the bottom tray and catch pan for grease build-up before each use. Remove excess grease to avoid a grease fi re in the botto
