Summary of the content on the page No. 1
®
GENESIS
LP Gas Grill Owner’s Guide
YOU MUST READ THIS OWNERS GUIDE
#
BEFORE OPERATING YOUR GAS GRILL
55545
DANGER
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flames.
3. Open lid
4. If odor continues, keep away from the
appliance and immediately call your gas
supplier or your fire department.
Leaking gas may cause a fire or explosion
which can cause serious bodily injury or
death, or damage to property.
WARNING
1. Do not store spare liquid propane
cylinder wi
Summary of the content on the page No. 2
Dangers & Warnings DANGER Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to property. WARNINGS Do not store a spare or disconnected liquid propane cylinder under or near this barbecue. Improper assembly may be dangerous. Please carefully follow the assembly instructions in this manual. ® After a period of storage, and/or nonuse, the Weber gas barbecue shoul
Summary of the content on the page No. 3
Contents Danger & Warnings..................................................................................A-2 Warranty ..................................................................................................A-4 Storage and Nonuse .................................................................................A-5 Cooking ...................................................................................................A-6 Cleaning .....................................................
Summary of the content on the page No. 4
Warranty Weber-Stephen Products Co. (Weber) hereby warrants to There are no other express warrants except as set forth ® herein and any applicable implied warranties of the ORIGINAL PURCHASER of this Weber gas grill that it merchantability and fitness are limited in duration to the will be free of defects in material and workmanship from period of coverage of this express written Limited Warranty. the date of purchase as follows: Some regions do not allow limitation on how long an implied warran
Summary of the content on the page No. 5
General Instructions ® Your Weber gas barbecue is a portable outdoor cooking Storage and/or Nonuse ® appliance. With the Weber gas barbecue you can grill, • The gas must be turned off at the liquid propane cylinder barbecue, roast and bake with results that are difficult to ® when the Weber gas barbecue is not in use. duplicate with indoor kitchen appliances. The closed lid ® • When the Weber gas barbecue is stored indoors, the ® and Flavorizer Bars produce that “outdoor” flavor in the gas suppl
Summary of the content on the page No. 6
General Instructions Cooking Cleaning ® ® WARNING: Do not move the Weber gas barbecue WARNING: Turn your Weber gas barbecue OFF and when operating or while barbecue is hot. wait for it to cool before cleaning. ® You can adjust the FRONT and BACK burners as desired. CAUTION: Do not clean your Flavorizer bars or The control settings: High (H), Medium (M), Low (L), or Off cooking grates in a self-cleaning oven. ® (O) are described in your Weber cookbook. The cookbook For availability of repla
Summary of the content on the page No. 7
Exploded View ® Genesis Silver-A LP 082603 1 2 3 26 27 4 28 29 30 5 31 6 32 7 33 8 34 35 36 9 37 10 38 11 39 12 13 14 40 15 41 16 42 43 17 44 45 18 46 19 34 20 47 21 48 22 49 23 50 24 25 51 A-7
Summary of the content on the page No. 8
Exploded View List 1. Hinge Pin 26. Hair Pin Cotter 2. Left Endcap 27. Right Endcap 3. Shroud 28. Thermometer Bezel Assembly 4. Handle 29. Thermometer Assembly 5. Warming Rack 30. Handle Hardware 6. Cooking Grates 31. Warm-Up™ Basket ® 7. Flavorizer Bars 32. Control Panel Knobs 8. Cooking Box 33. Control Panel 9. 1/4-20 keps nut 34. Control Panel Hardware ® 10. Slide Out Bottom Tray 35. Crossover Ignition Button ® 11. Work Surface 36. Crossover tube 12. Catch Pan Holder 37. Front / Rear Burner 1
Summary of the content on the page No. 9
Parts List Cooking Box Assembly - 1 ® Flavorizer Bars - 5 ™ Warm-Up Basket- 1 Warming Rack - 1 Cooking Grates - 2 Caster Frame - 1 Bottom Tray - 1 Catch-Pan Holder - 1 Wheel Frame - 1 Catch-Pan - 1 Swing Up Table - 1 Disposable Drip Pans - 2 Thermometer - 1 Bottom Rack - 1 1 inch Bolts (1/4 x 20 x 1 inch Bolt) - 6 Condiment basket - 1 Nylon Washer - 6 Left Trim Assembly - 1 Wrench - 1 7/16” Inch Wrench - 1 Side Table - 1 Right Trim Piece - 1 LP Tank - 1 A-9
Summary of the content on the page No. 10
Unpacking 1 3 4 2 A-10
Summary of the content on the page No. 11
• Arrow sticker to the front. 1 b a • Push down firmly until Bottom Rack Lock, "locks" under the rail. c Ba300.a B-a
Summary of the content on the page No. 12
2 a b • Push down firmly on both sides to ensure bottom rack is locked under the rails. WARNING: Do not go to next step if bottom rack is not locked in place B-b
Summary of the content on the page No. 13
3 • Install bolts at indicated locations. Use supplied tool to tighten. Recheck each bolt for tightness with a 7/16” open end wrench. B-c
Summary of the content on the page No. 14
4 B300_LP.e B-1
Summary of the content on the page No. 15
5 6 B-2
Summary of the content on the page No. 16
7 a b a 8 10 b 9 11 B-3
Summary of the content on the page No. 17
12 B-4
Summary of the content on the page No. 18
Gas Instructions Fill liquid propane cylinder cylinder are by weight or volume, as described in NFPA 58. Note - The liquid propane cylinder manufacturer is Please make sure your filling station fills your LP cylinder responsible for the materials, workmanship and by weight or volume. Ask your filling station to read purging performance of the cylinder. If the cylinder has a defect, and filling instructions on the LP cylinder before attempting malfunctions, or you have a question regarding the t
Summary of the content on the page No. 19
Gas Instructions Note: This is a new type of connection. It tightens clockwise We utilize various LP tank manufacturers. Some of the and will not allow gas to flow unless the connection is tight. tanks have differing top collar assembles. (The top collar The connection requires tightening by hand only. is the metal protective ring around the valve.) One series WARNING: Do not use a wrench to tighten the of tanks mount with the valve facing front. The other tanks connection. Using a wrench
Summary of the content on the page No. 20
Gas Instructions Remove control panel and burner control knobs Check for gas leaks You will need: Phillips screwdriver. After a period of nonuse, we recommend that you perform 1) Remove control knobs. the following maintenance procedures for your safety. 2) Remove screws through slots in trim with a Phillips WARNING: Check the hose before each use of the screwdriver. barbecue for nicks, cracking, abrasions or cuts. If 3) Pull up igniter button until it sticks in the up position the hose is fo
