Summary of the content on the page No. 1
R
R
E
E
B
B
E
E
W
W
® ®
GENESIS GOLD–C
GENESIS GOLD–C
Gas Grill
Owners Guide
DANGER
If you smell gas:
1. Shut off gas to the appliance.
Natural Gas
2. Extinguish any open flames.
3. Open lid
4. If odor continues, keep away from the
appliance and immediately call your gas
supplier or your fire department.
Leaking gas may cause a fire or explosion
which can cause serious bodily injury or
death, or damage to property.
WARNING
Do not store or use gasoline or other
flammable liquids or vapors wit
Summary of the content on the page No. 2
DANGER Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to property. WARNINGS Do not store a spare or disconnected liquid propane cylinder under or near this barbecue. Improper assembly may be dangerous. Please carefully follow the assembly instructions in this manual. After a period of storage, and/or nonuse, the Weber Gas Barbecue should be checked for gas le
Summary of the content on the page No. 3
Warranty Weber-Stephen Products Co. (Weber) hereby warrants to the ORIGINAL PURCHASER of this Weber Gas Grill There are no other express warrants except as set forth that it will be free of defects in material and herein and any applicable implied warranties of workmanship from the date of purchase as follows: merchantability and fitness are limited in duration to the period of coverage of this express written Limited Aluminum Castings, lifetime, 1 year paint Warranty. Some regions do not allow
Summary of the content on the page No. 4
Contents Danger & Warnings ....................................................................... A-2 Warranty ........................................................................................ A-3 General Instructions ...................................................................... A-5 Exploded View ............................................................................... A-6 Parts List ....................................................................................... A-
Summary of the content on the page No. 5
Storage General Instructions • The gas must be turned OFF at the natural gas Your Weber Gas Barbecue is a portable outdoor supply when the Weber Gas Barbecue is not in cooking appliance. With the Weber Gas Barbecue you use. can grill, barbecue, roast and bake with results that are • When the Weber Gas Barbecue is stored indoors, difficult to duplicate with indoor kitchen appliances. The the gas supply must be disconnected. closed lid and Flavorizer® Bars produce that “outdoor” flavor in the food
Summary of the content on the page No. 6
1 Genesis Gold-C NG 2 3 34 4 5 35 6 7 8 36 9 37 38 39 10 40 11 41 12 16 13 19 14 15 42 16 18 17 43 18 44 45 19 46 20 47 21 48 22 49 23 24 50 25 39 51 26 52 53 27 54 28 29 55 26 56 57 30 58 31 59 32 33 A-6
Summary of the content on the page No. 7
1. Hair Pin Cotter 34. Thermometer 2. Hinge Pin 35. Right Endcap 3. Left Endcap 36. Burner Control Knobs 4. Shroud 37. Control Panel 5. 1/4-20 x 1 1/4 inch bolt 38. Igniter Button 6. Handle lock 39. Control Panel Hardware 7. Handle 40. Side burner ™ 8. Warm-Up Basket 41. Side Burner Bracket Right side 9. Warming Rack 42. Sideburner support clip 10. Cooking Grates 43. Side Burner Bracket Left side ® 11. Flavorizer Bars 44. Crossover Tube 12. Cooking Box 45. Front and Back Burners 13. 1/4-20 keps
Summary of the content on the page No. 8
© 2000 Weber-Stephen Products Co., Weber, the silhouette, and the kettle configuration are registered trademarks ® of Weber-Stephen Products Co., 200 East Daniels Road, Palatine, IL, 60067-6266, U.S.A. This product is covered by one or more United States patents and patents in other nations globally. Printed in the U.S.A. A-8
Summary of the content on the page No. 9
Remove Packaging from Grill Remove Grill from Lower Packaging Remove all tape from packaging. Remove bottom rack from top of packaging. Remove outer box. Pull out WARNING: Lifting the barbecue from the lower bottom tray from cooking box. Remove packaging packaging requires at least two people. material from bottom tray, catch pan holder, catch pan, With two people: lift straight up and over lower and drip pan. packaging and cardboard support. A-9
Summary of the content on the page No. 10
You will need: 1/2 inch bolts (1/4 x 20 x 1/2 inch bolts) - 4 Phillips screwdriver 7/16 open-end or an adjustable wrench Nylon Washers - 4 Flavorizer Bars - 5 Left Work Surface - 1 Cooking Grates - 2 Condiment basket - 1 Right Work Surface with Side Burner - 1 Bottom Shelf - 1 12 Foot Hose - 1 Slide Out Buttom Tray - 1 Catch pan holder - 1 Catch Pan - 1 Disposable Drip Pans - 2 A-10
Summary of the content on the page No. 11
Assembly Instructions Install the slide out bottom tray Slide the bottom tray onto the mounting rails under the You will need: the slide out bottom tray(1), catch pan cooking box with finger grip toward you(1). holder(2), catch pan and one disposable drip pan. WARNING: Do not line bottom tray with aluminum foil. It can cause grease fires by trapping the grease and not allowing grease to flow into the catch pan. (1) (2) Hook the ends of the catch pan holder into the hole in the slide out bottom
Summary of the content on the page No. 12
Install Flavorizer® Bars and Cooking Grates Installing the warming rack You will need: five Flavorizer Bars and two cooking You will need: warming rack. grates. Set the warming rack into the slots at the rear of the Place the Flavorizer Bars side by side in the cooking cooking box. box. Set the cooking grates onto the ledges in the cooking box with the rounded sides up. Install the bottom shelf You will need: Bottom shelf. Set the bottom shelf in place between the two frame connectors underneath
Summary of the content on the page No. 13
Installing Work Surfaces & Gas Connection Guidelines Install Left Work Surface Check that all burner valves are off You will need left work surface, two 1/2 inch bolts, two You will need: burner control knobs. nylon washers and a 7/16 inch or adjustable wrench. Valves are shipped in the OFF position, but you should Insert the left work surface tabs in the slots in the check to be sure that they are turned OFF. Put the frame(1). Slip washers on the bolts and insert the bolts knob on each valve. C
Summary of the content on the page No. 14
Connect side burner to manifold Install Gas Supply WARNING: Make sure gas supply is off. General Specifications for Piping Connect the side burner hose as follows: Note - Contact your local municipality for building 1) Slide back the collar of the quick disconnect on the codes regulating outdoor gas barbecue manifold. installations. In absence of Local Codes, you must 2) Push the male fitting of the side burner hose into confirm to the latest edition of ANSI Z223.1. WE the quick disconnect, an
Summary of the content on the page No. 15
Gas Line Piping Check for gas leaks If the length of the line required does not exceed 50 DANGER feet, use a 5/8" O.D. tube. One size larger should be Do not use an open flame to check for gas used for lengths greater than 50 feet. leaks. Be sure there are no sparks or open Gas piping may be copper tubing, type K or L; flames in the area while you check for polyethylene plastic tube, with a minimum wall leaks. Sparks or open flames will result in thickness of .062 inch; or standard weight
Summary of the content on the page No. 16
Check: Reinstall control panel (after checking for gas 1) Hose to manifold connection leaks) 2) Manifold to side burner hose connection (1) Set the control panel in place over both sides of WARNING: If there is a leak at connection(1), the frame. Hold the crossover ignition button up retighten the fitting with a wrench and recheck for while setting the control panel in place. leaks with soap and water solution. If a leak persists after retightening the fitting, turn OFF the gas. DO NOT OPERATE
Summary of the content on the page No. 17
Operating 1) Open the lid. Lighting 2) Make sure all burner control knobs are turned Summary lighting instructions are on the control panel. OFF. (Push each burner control knob down and turn DANGER clockwise to ensure that they are in the off position.) Failure to open the lid while igniting the 3) Turn the gas supply valve on. WARNING: Do not lean over the open barbecue. barbecue’s burners, or not waiting 5 min- Keep your face and body at least one foot away utes to allow the gas to clear i
Summary of the content on the page No. 18
WARNING: If the burner does not light, turn the Manual Lighting Front burner control knob to OFF and wait 5 minutes to let the gas clear before you try again or DANGER try to light with a match. Failure to open lid while igniting the 7) After the FRONT burner is lit you can turn on the barbecue’s burners, or not waiting 5 min- other burner or burners. utes to allow the gas to clear if the barbe- Note - Always light the FRONT burner first. The other cue does not light, may result in an explo-
Summary of the content on the page No. 19
Lighting the side burner if the main burners are lit. Lighting the Side Burner 1) Open the side burner lid. 2) Push down and turn the side burner control to HI. The side burner has a separate ignition system from 3) Press the side burner igniter button several times so the main cooking box. it clicks each time. DANGER 1 2 Failure to open the lid while igniting the side burner, or not waiting 5 minutes to allow the gas to clear if the side burner does not light, may result in an explosive flame
Summary of the content on the page No. 20
Check that the areas under the control panel and Cooking the slide out bottom tray are free from debris that WARNING: Do not move the Weber Gas Barbe- might obstruct the flow of combustion or ventilation air. cue when operating or while barbecue is hot. The Spider stopper guards should also be checked You can adjust the FRONT and BACK burners as for any obstructions. (See “Maintenance” Section.) desired. The control settings: High (H), Medium (M), Low (L), or Off (O) are described in your
