Summary of the content on the page No. 1
®
# 42373
SUMMIT
®
SUMMIT SILVER A
BUILT-IN NATURAL GAS GRILL OWNER'S GUIDE
YOU MUST READ THIS OWNERS GUIDE BEFORE OPERATING YOUR GAS GRILL
DANGER
WARNING: Follow all leak-check proce-
If you smell gas:
dures carefully in this manual prior to
1. Shut off gas to the appliance.
barbecue operation. Do this even if the
2. Extinguish any open fl ames.
barbecue was dealer-assembled.
3. Open lid
4. If odor continues, keep away from the
appliance and immediately call your gas
NOTICE TO
Summary of the content on the page No. 2
DANGERS & WARNINGS DANGER Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or death, or in a fi re or an explosion causing damage to property. WARNINGS Do not store a spare or disconnected liquid propane cylinder under or near this barbecue. Improper assembly may be dangerous. Please carefully follow the assembly instructions in this manual. ® After a period of storage, and/or nonuse, the Weber gas barbecue sh
Summary of the content on the page No. 3
WARRANTY The natural gas supply is easy to use and gives you more Warranty cooking control than charcoal fuel. Weber-Stephen Products Co. (Weber) hereby warrants to the ORIGINAL ® PURCHASER of this Weber gas grill that it will be free of defects in mate- These instructions will give you the minimum require- rial and workmanship from the date of purchase as follows: ® ments for assembling your Weber gas barbecue. Please read the instructions carefully before using Aluminum Castings, lifeti
Summary of the content on the page No. 4
GENERAL INSTRUCTIONS CLEANING ® WARNING: Turn your Weber gas barbecue OFF and Gas Supply Testing ® wait for it to cool before cleaning. Disconnect your Weber gas barbecue when the gas ® CAUTION: Do not clean your Flavorizer bars or supply is being tested at high pressures. This appliance cooking grates in a self-cleaning oven. and its individual shutoff valve must be disconnected For availability of replacement cooking grates and from the gas supply piping system during any pressure
Summary of the content on the page No. 5
GAS INSTRUCTIONS Check for gas leaks (1) DANGER Do not use an open fl ame to check for gas (2) leaks. Be sure there are no sparks or open fl ames in the area while you check for leaks. Sparks or open fl ames will result in a fi re or explosion which can cause serious bodily (3) injury or death and damage to property. WARNING: You should check for gas leaks every time you disconnect and reconnect a gas fi tting. Note - All factory-made connections have been thoroughly checked for gas leaks.
Summary of the content on the page No. 6
- + - + GAS INSTRUCTIONS Reinstall control panel Remove the Front Panel by sliding the panel up and out of Parts required: control panel, screws, and burner control the slots. knobs. Place the control panel back onto the control panel brackets on either side of the front of the cooking box. Line up screws with screw holes on both the control panel and control panel brackets. Tighten screws. (1) (2) Reinstall burner control knobs & igniter wires (if necessary). Check: Place corresponding co
Summary of the content on the page No. 7
OPERATING INSTRUCTIONS Direct cooking Grilling Methods The Direct Method, similar to broiling, means the food is cooked directly over the heat source. For even cooking, food NOTE: If grill looses heat while cooking refer to the should be turned once halfway through the grilling time. troubleshooting section of this manual. Use the Direct method for foods that take less than 25 minutes You can adjust the Left and Right burners in each burner to cook: steaks, chops, kabobs, sausages, vegeta
Summary of the content on the page No. 8
OPERATING INSTRUCTIONS Indirect cooking Grilling Tips & Helpful Hints The Indirect Method is similar to roasting, but with the added Always preheat the grill before cooking. Set all burners benefi ts of that grilled texture, fl avor, and appearance you on HIGH heat and close lid; heat for 10 minutes, or until can’t get from an oven. To set up for Indirect cooking, gas thermometer registers 500˚-550˚F (260˚-288˚C). burners are lit on either side of the food but not directly be- Sear meats
Summary of the content on the page No. 9
OPERATING INSTRUCTIONS Lighting Summary lighting instructions are on the control panel. 1 DANGER 4,5,8 Failure to open the lid while igniting the barbecue's burners, or not waiting 5 minutes to allow the gas to clear if the barbecue does not light, may result in an 7 explosive fl ame-up which can cause serious bodily injury or death. ® Crossover Ignition System 2 ® Note - The Crossover ignition system ignites the set of left burners with a spark from the igniter electrode inside the 6 Ga
Summary of the content on the page No. 10
OPERATING INSTRUCTIONS Manual Lighting 1 DANGER Failure to open lid while igniting the 4,5,7 barbecue's burners, or not waiting 5 minutes to allow the gas to clear if the barbecue does not light, may result in an explosive fl ame-up which can cause 6 serious bodily injury or death. 1) Open the lid. 2) Make sure all burner control knobs are turned OFF. 2 (Push each burner control knob down and turn 3 clockwise to ensure they are in the off position.) 3) Turn the gas supply valve on. 4) Pu
Summary of the content on the page No. 11
MAIN BURNER TROUBLESHOOTING Problem Check Cure Burners burn with a yellow or Inspect Spider / Insect Screens for Clean Spider / Insect Screens. orange fl ame, in conjunction possible obstructions. (Blockage (See Section “Annual with the smell of gas. of holes.) Maintenance”) Burner does not light, or fl ame Is LP fuel low or empty? Refi ll LP cylinder. is low in HIGH position. Is fuel hose bent or kinked? Straighten fuel hose. Does the Left burner light with a If you can light the Left burner m
Summary of the content on the page No. 12
MAINTENANCE ® Lightly tap the burner to get debris and dirt out of the WEBER SPIDER /INSECT SCREENS ® burner tube. Once the spider/insect screens and burners Your Weber gas barbecue, as well as any outdoor gas are clean replace the burners. appliance, is a target for spiders and other insects. They If the spider/insect screen becomes damaged or cannot be can nest in the venturi section(1) of the burner tubes. This cleaned, call Weber-Stephen Products Customer Service blocks the normal gas
Summary of the content on the page No. 13
- + - + MAINTENANCE 9. Remove screws from the manifold assembly: Replacing Main Burners (a) Locate the screws on both sides of the manifold frame. (b) Remove the screws from manifold frame. ® 1. Your Summit gas grill must be OFF and cool. 2. Turn gas OFF at source. 3. Disconnect regulator. 4. Remove cooking grates. 5. Remove Smoker box. ® 6. Remove Flavorizer bars. 7. To remove control panel refer to “Remove the control panel” under “Check for Gas Leaks.” 8. Disconnect all ignition wires fr
Summary of the content on the page No. 14
MAINTENANCE 11. Lift and twist the burner assembly slightly, to sepa- CAUTION: The burner openings (1) must be posi- ® rate the Crossover tube (a) from the burners (b). tioned properly over the ® 12. Remove the Crossover tube. valve orifi ces (2). (2) (b) (b) (a) (1) 13. Pull the selected burner(s) tube(s) from manifold frame and replace with a new burner tube. 14. To reinstall the manifold assembly, reverse steps 7 through 13. Check proper assembly before fastening manifold in place. WAR
Summary of the content on the page No. 15
MAINTENANCE ® Crossover Ignition System Operations ® If the Crossover ignition system fails to ignite the LEFT burner in a burner set, light the LEFT burner with a match. If the LEFT burner lights with a match, then check the ® Crossover ignition system. Check that both ignition wires(1,2) are attached prop- erly. ® Check that the Crossover ignition button is activating. Replace battery with a like brand battery. You should hear the igniter sparking. ® If the Crossover ignition system
