Summary of the content on the page No. 1
12202UK_#387-2005_02/05bt_rk 1
Assembly Instruction for
flat bed BBQ Art.-No. 12202
IMPORTANT:
READ ALL INSTRUCTIONS AND OPERATIONS
BEFORE OPERATING THIS UNIT.
FOLLOW THE CORRECT LIGHTING AND USAGE
PROCEDURES. HANDLE METAL PARTS WITH CARE
TO AVOID INJURIES. FOLLOW ALL STEPS IN
ORDER. NEVER ALLOW CHILDREN TO OPERATE
THIS UNIT.
Summary of the content on the page No. 2
2 Contents: 1.: Technical data 2.: Function 3.: Single part list 4.: Fixing elements 5.: Exploring drawing 6.: Mounting steps 7.: Preparation 8.: Installation 9.: Warning and safety points 10.: Safety precautions 11.: Lighting instructions 12.: Storage 13.: Cleaning instructions 14.: Barbecue Safety Hints Warnings: Ensure to use this appliance outdoors. Do not attempt to move this appliance during operation. Never leave fuel cylinder attached to regulator if disconnected from burner tube. Attent
Summary of the content on the page No. 3
3 1.:Technical Data Gas: LPG (Propane) Gas Bottle: Propane Gas Bottle with 27mm Clip valve Pressure: Propane at 37 Mbar 3+ (28-30/37) Consumption: 800 g / h Power: approx. 11 kW Weight: approx. 26,8 kg Overall dimensions: approx. W 115 cm, D 58 cm, H 113 cm Cooking Area: approx. 24 x 49 cm (2x) Burner set: adjustable Ignition: Piezo Ignitor Lava rocks: 1 Bag The capacity of a 13kg Propane Gas Bottle is sufficient for a heating period of approx. 15 hours with full power. You have purchased a hi
Summary of the content on the page No. 4
4 2.: Function a) Pilot Gas Control Ignition: With all gas controls on the Barbecue in the 'OFF' position, turn the gas cylinder valve to the on position at the regulater. Push in the Barbecue ignition gas control knob and turn anticlockwise until spring resistance is felt. Hold in this position for 3-5 seconds to allow gas flow, and then continue to turn anticlockwise to 'HIGH"' position. Keep the knob pressed in until the burner is seen to be alight. When the burner is alight, adjacent burner
Summary of the content on the page No. 5
5 3.: Single part list 1. Lid Sheet II 1 22. Drip pan 1 2. Lid Sheet I 1 23. Drip pan handle 1 3. Left side panel 1 24. Screw M5x6 1 4. Right side panel 1 25. Hose 1 5. Hinge Pin 2 26. Regulator 1 6. Top hinge 2 27. Gas Hose connection 1 7. Handle bracket 2 28. Hose Clamp 2 8. Lid handle 1 29. Bolt M6x12 9 9. Cooking Grill 1 30. Washer M6 5 10. Hot Plate 1 31. Nut M6 5 11. Cross Lighting tube 1 32. Spring Washer M5 6 12. Burner 2 33. Flat Washer M6 6 13. R Clip 2 34. Bolt M5x10 6 14. Body ASSY 1
Summary of the content on the page No. 6
6 5.: Exploring drawing 1 34 36 4 33 35 32 2 6 5 8 38 7 3 37 10 9 39 16 40 12 29 11 14 29 31 15 30 17 13 19 27 38 18 25 21 26 20 22 24 23
Summary of the content on the page No. 7
7 6.: Mounting steps I a c I b II II V III e a M6x40 4x IV b 4x c 4x III IV V 4x d M6x60 e M5x20 6x f 2x f i g 2x d 2x d h 2x i e g h 2x k
Summary of the content on the page No. 8
8
Summary of the content on the page No. 9
9 1.: Attach the Body assy (14) on the trolley (see page 8 ) using the 2 hook shaped brackets provided. Attach brackets to side of gas assy with bolts and nuts provided One at front left side and the other at rear right hand side to hold the body assy in place. 2 2.: ATTACH THE HOOD AT THE BBQ LID Place the lid (2) on the grill housing (14) and 6 connect the hinge (6) with the hinge plates (15 & 16)with the screws nuts and washers provided. Push the hinge bolts (5) through the hinges and the hin
Summary of the content on the page No. 10
10 11 12 13 5.: FIT GREASE TRAY TO THE BBQ Fit the drip pan handle (23) to the front edge of the drip pan (22), using the screw (24) supplied. Slide the drip pan into place from the front of the barbecue below the control panel (20). Push it all the way back until it stops. This tray must be filled before use with an even layer, approximately 10mm thick, of non-combustible, fat absorbing medium or clean, dry sand. This must be kept clean and loose in order to absorb fat drippings. If this is not
Summary of the content on the page No. 11
11 7.: Preparation You will need to purchase a Propane bottle with a 27mm clip on valve to operate this barbecue which can be obtained from your nearest Gas Retailer. Energy saving tips: a.: Reduce the opening time of the lid. b.: Preheat the barbecue for 5 minutes low then 10 minutes medium. (with Lid open) c.: Do not preheat longer than recommended. d.: Do not use a higher setting than required. 8.: Installation After purchasing your gas bottle you will then be ready to set it up with your bar
Summary of the content on the page No. 12
12 9.: Warning and Safety Points Please read the following points before using your barbecue: 1.: Please follow all assembly instructions in this manual, if instructions are not followed it may cause problems in use. 2.: This barbecue will become very hot when being used, care is to be taken especially when pets, children or elderly people are present. 3.: In the event of a gas leak shut off gas to the barbecue, extinguish any open flames, open lid and if leak continues check for damages, poor
Summary of the content on the page No. 13
13 10.: Safety Precautions 1. Always test gas line for leaks at connector with soapy water after making connections. 2. The top must always be open when lighting the burner. 3. Use oven gloves and sturdy, long handled barbecue tools when cooking on the grill. 4. Be prepared if an accident or fire should occur. Know where the first aid kit and fire extinguishers are and know how to use them. 5. Keep any electrical supply cord and the fuel supply hose away from any heated surfaces. 6. Always c
Summary of the content on the page No. 14
14 12.: Storage Your Gas bottle must be stored outdoors in a well ventilated area and must be disconnected from your barbecue when not being used. Ensure that you are outdoors and away from any sources of ignition before attempting to disconnect your gas bottle from your barbecue. When you are using your barbecue after a period of storage, please ensure to check for gas leaks and check for any obstructions in the burner etc. before using. Also follow the cleaning instructions to ensure barbecue
Summary of the content on the page No. 15
15 Trouble Shooting Problem Possible Cause Solution Burners will not light using LP gas cylinder empty Replace with full cylinder the ignition system Faulty regulator Have regulator checked or replaced Obstructions in burners Clean burners Obstructions in gas jets or hose. Clean jets and hose. Electrode wire is loose or Reconnect wire disconnected on ignition valve. Electrode or wire is damaged.
Summary of the content on the page No. 16
16 To claim under your guarantee, contact the Barbecue Helpline No. 1. Your Gas Barbecue is guaranteed against any defect in manufacture or materials for a period of TWELVE MONTHS from the date of purchase. The guarantee covers the replacement of all defective parts free of charge. 2. This guarantee certificate is only valid when accompanied by proof of purchase. 3. The guarantee will not apply if the appliance is defective due to use that is not in accordance with these instructions, accident
Summary of the content on the page No. 17
