Summary of the content on the page No. 1
Use Use & & Car Care e Manual Manual
Assembly Instructions Included
3 30 0" Stainless Steel
Outdoor Grill
with Electronic Ignition
Welcome/Product Registration
1
General Safety Instructions 2
Grill Features and Components 3-4
Grill Assembly
5-8
Built-In Instructions
Gas Requirements
Leak Testing 9-11
Lighting the Grill 12
Using the Grill
Rotisserie/Side Burner Usage 13-15
Care & Maintenance 16
Troubleshooting Your Grill 17-18
Visit the Frigidaire Web Site at:
Warranty 19
http://www.frigidaire.c
Summary of the content on the page No. 2
Welcome & Congratulations Congratulations on your purchase of a new grill! We at Questions? Electrolux Home Products are very proud of our product and we are completely committed to providing you with 1-800-320-0859 the best service possible. Your satisfaction is our #1 pri- ority. Please read this Use & Care Manual very carefully. It contains valuable information on how to properly Register Your Product Register Your Product maintain your new grill. The PRODUCTREGISTRATIONCARD The PRODUCT REG
Summary of the content on the page No. 3
General Safety Instructions IMPORTANT SAFETY INFORMATION - Read this manual carefully before using your grill to reduce the risk of fire, burn hazard or other injury. - Extreme care should be used because of the high temperatures produced by this appliance. CHILDREN SHOULD NOT BE LEFT UNATTENDED IN AN AREA WHERE THE GRILL IS BEING OPERATED. - This appliance must be kept clear from combustible materials, gasoline or other flammable vapors and liquids. Do not allow flammable materials to co
Summary of the content on the page No. 4
Grill Features: GL30 7 1 8 2 9 12 3 13 4 10 5 11 6 1. Roll top grill hood 8. Warming shelf 2. Grilling/Cooking surface 9. Infrared back burner 3. Side Shelf 10. Electronic igniter: main, rear infrared & side burner 4. Control knob: back infrared burner 11. Cart with door 5. Control knobs: main burners 12. Side Burner 6. Convection vents 13. Control knob: Side Burner 7. Hood Handle NOTE: Cart, side burner and side shelf are not included with the head only units. 3
Summary of the content on the page No. 5
Grill Assembly IMPORTANT: Remove all protective plastic film from Shelf Hooks stainless steel parts prior to assembly/use. This film is installed at the factory to prevent damage that could occur during shipment and handling. Fig. 1 SIDE SHELF ATTACHMENT 1. Attach the shelf to the left side of grill by inserting the shelf hooks into the slots on the side of the grill and pushing down on the shelf assembly until level with grill. (See Fig. 1) 2. Lock the shelf in place by inserting (2) self tappi
Summary of the content on the page No. 6
Side Burner Assembly SIDE BURNER PARTS ASSEMBLY 1. Attach the side shelf to the grill by inserting the shelf Side Shelf Tabs hooks into the slots on the side of the grill and pushing down on the shelf assembly until level with the grill. Fig. 8 (See Fig. 8) 2. Lock the side shelf in place by inserting (2) hex head screws in the side burner. (See Fig. 9) NOTE: A power screwdriver extension is needed to insert screws. Screw Holes 3. Install burner and cap. (See Fig. 10-11) 4. Install grate over
Summary of the content on the page No. 7
Built-In Instructions The Frigidaire Gallery Grill can be installed as a built-in grill. If installed as a built-in grill, the outdoor cooking center must be constructed of non-combustible material. PLANNING AND DESIGN Start by identifying the number and size of components you want to include in your outdoor cooking center. Countertops must be constructed of non-combustible, outdoor-safe materials. Consider outdoor lighting to illuminate after-dark grilling. For assistance in designing and bui
Summary of the content on the page No. 8
27 1/2” Minimum Built-In Instructions Note: Make Sure To Use Non-Combustible Material For Construction Note A: Wire & Plumbing Cutout Left & Right Sides 6” x 4” Opening Minimum GFI Electrical Outlet For Rotisserie Motor .75 (6.5 Amp Min.) Note A* 3/4” Top 2.00 Required igniter 2” Cutout 4” A 6” Front Side Cutout View C B Open Space Minimum Clearance To Open Hood 5” 1.50” 35.5” Max 0.75” 0.75 Max Max 1.440 Max Top View GL30 Frigidaire Gallery Grills Built-In Dimensions With trim kit Without trim
Summary of the content on the page No. 9
Gas Requirements GENERAL INFORMATION Never attach an unregulated gas line to the appliance. Connection to an unregulated gas line can cause excessive heat or fire. Verify the type of gas supply to be used, either Natural Gas (N.G.) or Liquid Propane (L.P.), and make sure the serial plate agrees with that of the supply. Conversion kits are available separately for an additional cost which will enable you to convert your grill from L.P. to N.G. or to convert your grill from N.G. to L.P. Please see
Summary of the content on the page No. 10
Gas Requirements L.P. GAS INSTALLATION Frigidaire Gallery Gas Grills that are set to operate with L.P. gas come with a high capacity hose and regulator assembly. (Note: Only use the pressure regulator and hose assembly supplied with the grill or a replacement pressure regulator and hose assemblies specified by Frigidaire). This assembly is designed to connect directly to a standard 20 lb. L.P. cylinder. L.P. Cylinders are not included with the grill. L.P. Cylinders can be purchased separately at
Summary of the content on the page No. 11
Pre Operation Leak Testing GENERAL INFORMATION Although all gas connections on the grill are leak tested prior to shipment, a complete gas tightness check must be per- formed at the installation site due to possible shifting during shipment, installation or excessive pressure unknowingly being applied to the unit. Periodically check the whole system for leaks and immediately check the system if the smell of gas is detected. BEFORE TESTING Do not smoke while leak testing. Extinguish al
Summary of the content on the page No. 12
Lighting the Grill BEFORE LIGHTING Do not attempt to “Light” the grill if the Important! Before Lighting... odor of gas is present!! Check the gas supply line for cuts, wear or abrasion. Always keep your face and body as far away from the grill as possible when lighting. GRILL BURNER LIGHTING Fig. 15 Lighting the Grill with electronic igniter 1. Make sure tall control knobs are in the “OFF” position. 2. Open the gas supply valve located on top of your L.P. tank. ATTENTION: Whe
Summary of the content on the page No. 13
Using the Grill GRILL LOCATION Do not use the grill in garages, breezeways, sheds or any enclosed area. Never operate the grill in enclosed areas as this could lead to a carbon monoxide buildup, which could result in injury or death. Place the grill on a level surface. Avoid moving the grill while it is operation. NOTE: The grill will operate best if it is not facing directly into the wind. Clearance to combustible construction - A minimum of 12” from the sides and back must be maint
Summary of the content on the page No. 14
Using the Rotisserie & Side Burners (Optional ROTISSERIE KIT to use with back infrared burner must be purchased separately) The grill rotisserie system is designed to cook items from the back using infrared heat. The rotisserie burner is an infrared type which provides intense searing radiant heat. Preferred by chefs over other cooking methods, this intense heat sears in the natural juices and nutrients found in quality cuts of meats. Remove the warming rack from the grill when usi
Summary of the content on the page No. 15
Using the Rotisserie & Side Burners ROTISSERIE LIGHTING Open the lid. Push and turn the control knob for the rotisserie counter clockwise to the “HIGH” position. Wait 5 seconds. Then press and hold the electronic igniter button. You’ll hear a snapping sound. If the burner does not light in 4 seconds, turn the control knob to OFF and wait 5 minutes before trying again. Once lit, turn the control knob to the desired setting. (See Fig. 18) (If the igniter does not function, the burner
Summary of the content on the page No. 16
Care and Maintenance DRIP TRAY The drip tray located below the grill, inside the cart, should be cleaned periodically to prevent heavy buildup of debris. NOTE: Allow the drip tray to cool before attempting to clean. Important: Do not leave the grill outside during inclement weather unless it is covered (cover sold separately). Rain water can collect inside of the grill, the grill cart or the drip tray if left uncovered. If the drip tray is not cleaned after use and the grill is
Summary of the content on the page No. 17
Troubleshooting Your Grill GENERAL TROUBLE SHOOTING You should inspect the burners at least once a year or immediately if any of the following conditions occur: • The smell of gas. • Flames appearing mostly yellow. (some yellow at the tips is OK) • The grill will not get hot enough. • Burners make a snapping noise. • The grill heats unevenly. SPIDER AND INSECT WARNING Spider and insects can nest in the burners of this or any other grill and cause the gas to flow from the front of th
Summary of the content on the page No. 18
Troubleshooting Your Grill PROBLEM SOLUTION Grill will not light with a match or low heat with dial set • Is your gas supply fully turned on? to "High" position. • If this is an L.P. grill is there gas in your tank ? Check your gas level. • If this is an L.P. grill, shut off gas supply, disconnect gas line at tank, reconnect the line to the tank. • Make sure all the knobs are in the off position, then open the gas supply valve on the L.P. tank very slowly 1/4 turn, then open fully (at
Summary of the content on the page No. 19
Warranty LIMITED LIFETIME WARRANTY Frigidaire Grills have a limited lifetime warranty on all stainless steel panels, limited 3 years on stainless burners, a limited 1 year warranty on all other parts and limited 1 year on labor. In the U.S.A., your appliance is warranted by Electrolux Home Products North America. We authorize no person to change or add to any of our obligations under this warranty. Our obligations for service and parts under this warranty must be performed by an au
