ページ1に含まれる内容の要旨
g
GE Capacitor & Power Quality Products
MATRIX FILTER
SERIES B
480 Volts, 60HZ
USER MANUAL
ページ2に含まれる内容の要旨
g GE Capacitor & Power Quality Products IMPORTANT USER INFORMATION NOTICE The GE Corporation Matrix Filter is designed for harmonic mitigation of six pulse inverter drives supplying variable torque loads in a wide variety of applications. The suitability of this filter for a specific application must therefore be determined by the customer. In no event will GE assume responsibility or liability for any direct or consequential damages resulting from the use or application of this filter. Nor wil
ページ3に含まれる内容の要旨
g GE Capacitor & Power Quality Products TABLE OF CONTENTS 1. Safety .......................................................................................................... 1 2. Introduction ................................................................................................. 3 3. Model Number Codes .................................................................................. 4 4. Specifications .................................................................................
ページ4に含まれる内容の要旨
g GE Capacitor & Power Quality Products 1. IMPORTANT SAFETY INFORMATION WARNING ONLY A QUALIFIED ELECTRICIAN CAN CARRY OUT THE ELECTRICAL INSTALLATION OF THIS FILTER WARNING High voltage is used in the operation of this filter. Use Extreme caution to avoid contact with high voltage when operating, installing or repairing this filter. INJURY, DEATH AND/OR PROPERTY DAMAGE MAY RESULT IF SAFETY PRECAUTIONS ARE NOT OBSERVED. After removing power, allow at least five minutes to elapse and verify tha
ページ5に含まれる内容の要旨
g GE Capacitor & Power Quality Products WARNING ONLY SPARE PARTS OBTAINED FROM GE OR AN AUTHORIZED GE DISTRIBUTOR CAN BE USED. GEH-7252 2 May 2003
ページ6に含まれる内容の要旨
g GE Capacitor & Power Quality Products 2. INTRODUCTION This manual was specifically developed to If the equipment is not going to be put into assist in the installation, interconnection and service upon receipt, cover and store the filter operation of the GE Matrix Filter. in a clean, dry location. After storage, ensure that the equipment is dry and that no This manual is intended for use by personnel condensation has accumulated on the internal experienced in the operation and maintenance com
ページ7に含まれる内容の要旨
g GE Capacitor & Power Quality Products 3. MODEL NUMBER CODES 37GM (5 or 8) X X X X X X X X X X X Options Voltage and Frequency A 208-240V, 60Hz B 240V, 50Hz C 380-415V, 50Hz D 480V, 60Hz E 600V, 60Hz Output Current Rating (i.e., 0044 is 44 amps) Enclosure Size B CAB 17B or CAB-002 C CAB 20B or CAB-003 D CAB 30B or CAB-004 E CAB 42B or CAB-005 F CAB-006 Mechanical Configuration G = General Purpose NEMA 1 & 2 W = General Purpose NEMA 3R N = Industrial Style NEMA 1 Total Harmonic Current Distort
ページ8に含まれる内容の要旨
g GE Capacitor & Power Quality Products 4. SPECIFICATIONS Ratings Table 1 480 VAC, 60 Hz SERIES B Filter Ratings THID Rating 8% 5% Power Dissipation Power Dissipation Maximum Efficiency Efficiency @ Rated Current @ Rated Current Output Amps (Typical) (Typical) (Typical) (Typical) RMS (%) (%) (Watts) (Watts) 6 97.2 139 97.4 132 8 97.5 164 97.6 161 11 97.8 200 97.8 197 14 98.0 233 98.0 232 21 98.3 299 98.3 294 27 98.4 351 98.5 343 34 98.6 406 98.6 399 44 98.7 479 98.7 472 52 98.8 539 98.8 533 66
ページ9に含まれる内容の要旨
g GE Capacitor & Power Quality Products SPECIFICATIONS - continued Ambient Temperature (Operating) Enclosed Filters: -40 to +40 degrees C Open Panel Filters: -40 to +50 degrees C Storage Temperature: -40 to +90 degrees C Altitude: 0 to 3300 Feet above sea level. Refer to Figure 6 for altitude derating. Relative Humidity: 0 to 95% non-condensing Agency Approvals UL-508C File E191686 Component Recognized (3-1000 HP, 120 VAC through 600 VAC 50, 50/60, 60 Hz Three Phases CAN/CSA C22, 2 No. 14-95 Pe
ページ10に含まれる内容の要旨
g GE Capacitor & Power Quality Products SPECIFICATIONS - continued Table 2 480 Volt, 60 Hz Series B Matrix Filter Weights General Purpose Industrial Open Panel NEMA 1, 2, 3R NEMA 1 Output THID THID THID Amps RMS 8% 5% 8% 5% 8% 5% Weight Lbs Weight Lbs Weight Lbs Weight Lbs Weight Lbs Weight Lbs 6 2738 8394 6273 8 3040 8596 6575 11 35 45 95 105 70 80 14 35 45 95 105 80 90 21 45 60 105 120 85 100 27 50 65 135 150 100 115 34 70 85 160 175 125 140 44 70 85 160 175 125 140 52 105 135 170 200 235 265
ページ11に含まれる内容の要旨
g GE Capacitor & Power Quality Products SPECIFICATIONS - continued Table 3 480 VAC Matrix Filters Capacitor Current at Full Load Filter Capacitor Filter Capacitor Filter Capacitor Current Current Current Current Current Current Rating (Typical) Rating (Typical) Rating (Typical) Amps Amps Amps Amps Amps Amps Rms RMS Rms RMS Rms RMS 6 2.0 44 145 208 79.7 8 2.7 52 20.7 240 93.1 11 3.9 66 21.5 320 124.8 14 5.4 83 31.5 403 156.0 21 7.1 103 33.6 482 188.9 22 10.7 128 39.3 636 246.4 34 13.1 165 56.4 7
ページ12に含まれる内容の要旨
g GE Capacitor & Power Quality Products SPECIFICATIONS - continued Figure 3 8% Matrix Filter Harmonic Spectrum 100% Load 4.5 4.0 3.5 3.0 2.5 2.0 1.5 1.0 0.5 0.0 1 3 5 7 9 11 13 15 17 19 21 23 25 Harmonic order Typical Worst Case Figure 4 5% Matrix Filter Harmonic Spectrum 100% Load 3.5 3.0 2.5 2.0 1.5 1.0 0.5 0.0 1 3 5 7 9 11 13 15 17 19 21 23 25 Harmonic order Typical Worst Case GEH-7252 9 May 2003 Harmonic Current, % Harmonic Current, %
ページ13に含まれる内容の要旨
g GE Capacitor & Power Quality Products SPECIFICATIONS - continued Figure 5 5% and 8% Filter Power Factor vs Load Leading PF For All Load 1.10 1.00 0.90 0.80 0.70 0.60 0.50 0.40 0.30 0.20 0 20406080 100 120 Percent Filter Load Typical Worst Case Performance With Unbalanced Line Voltage (Typical) Table 4 All Components at Nominal Values and Worse Case Service Conditions 8% Filter 100% Load 5% Filter 100% Load Nominal THID 5.12% 3.93% 1% Unbalance 5.28% 4.06% 2% Unbalance 5.82% 4.47% 3% Unbalanc
ページ14に含まれる内容の要旨
g GE Capacitor & Power Quality Products SPECIFICATIONS - continued Figure 6 Altitude Derating Curve 1.05 1.00 0.95 0.90 0.85 0.80 0.75 0.70 0 3300 6600 9900 13200 16500 ALTITUDE (FEET) GEH-7252 11 May 2003 CURRENT DERATING FACTOR
ページ15に含まれる内容の要旨
g GE Capacitor & Power Quality Products 5. INSTALLATION INSTRUCTIONS Filter Installation Industrial style NEMA 1 enclosed filters are designed for wall and floor mounting in the vertical plane. Do not install in or near a Matrix Filters are supplied in the following corrosive environment. Avoid locations where mechanical configurations: the filter would be subjected to excessive Panel mounted assemblies vibrations. For wall mounted enclosures allow a minimum side clearance of eight (8) inches
ページ16に含まれる内容の要旨
g GE Capacitor & Power Quality Products INSTALLATION INSTRUCTIONS - continued Mounting Dimensions And Outline Drawings For Panel Mounted Filters Follow Figure 7 6 – 21 Amps, 480 VAC 60Hz Outline Drawing All dimensions are in inches GEH-7252 13 May 2003
ページ17に含まれる内容の要旨
g GE Capacitor & Power Quality Products INSTALLATION INSTRUCTIONS - continued Figure 8 27 Amps, 480 VAC 60Hz Outline Drawing All dimensions are in inches GEH-7252 14 May 2003
ページ18に含まれる内容の要旨
g GE Capacitor & Power Quality Products INSTALLATION INSTRUCTIONS - continued Figure 9 34 – 44 Amps, 480 VAC 60Hz Outline Drawing All dimensions are in inches GEH-7252 15 May 2003
ページ19に含まれる内容の要旨
g GE Capacitor & Power Quality Products INSTALLATION INSTRUCTIONS - continued Figure 10 52 - 66 Amps, 480 VAC 60Hz Outline Drawing All dimensions are in inches REACTOR ASSEMBLY CAPACITOR ASSEMBLY GEH-7252 16 May 2003
ページ20に含まれる内容の要旨
g GE Capacitor & Power Quality Products INSTALLATION INSTRUCTIONS - continued NOTE: CAPACITOR ASSEMBLY MAY BE MOUNTED IN EITHER PLANE Figure 11 83 – 128 Amps, 480 VAC 60Hz Outline Drawing All dimensions are in inches REACTOR ASSEMBLY CAPACITOR ASSEMBLY GEH-7252 17 May 2003
