ページ1に含まれる内容の要旨
FM2102
NOTICE TO INSTALLER: Instructions must remain with installation.
1207
Supersedes
1107
Product information presented
here re fl ects con di tions at time
of publication. Consult factory
re gard ing dis crep an cies or
visit our web site:
in con sis ten cies. MAIL TO: P.O. BOX 16347 • Louisville, KY 40256-0347
SHIP TO: 3649 Cane Run Road • Louisville, KY 40211-1961
www.zoeller.com
(502) 778-2731 • 1 (800) 928-PUMP • FAX (502) 774-3624
ZOELLER ON-SITE WASTEWATER PROD UCTS
OWNER’S M
ページ2に含まれる内容の要旨
Limited Warranty Manufacturer warrants, to the purchaser and subsequent owner during pumping applications. The warranty set out in the paragraph above the warranty period, every new product to be free from defects in material is in lieu of all other warranties expressed or implied; and we do not and workmanship under normal use and service, when properly used authorize any representative or other person to assume for us any and maintained, for a period of one year from date of purchase by th
ページ3に含まれる内容の要旨
© Copyright 2007 Zoeller Co. All rights reserved. 3 Pump Performance Data TOTAL DYNAMIC HEAD/FLOW PER MINUTE EFFLUENT 1/2 HP 1/2 HP 3/4 HP 1 HP MODEL 5 STAGE 7 STAGE 10 STAGE 13 STAGE Feet Meters Gal. Liters Gal. Liters Gal. Liters Gal. Liters 40 12.2 14.4 54.5 14.5 54.9 -- -- 80 24.4 12.1 45.8 13.1 49.6 14.1 53.4 14.6 55.3 120 36.6 9.4 35.6 11.6 43.9 13.0 49.2 13.7 51.9 160 48.8 5.5 20.8 9.6 36.3 11.8 44.7 12.8 48.5 200 61 -- -- 7.1 26.9 10.6 40.1 12.0 45.4 240 73.2 -- -- 2.0 7.6 9.3 35.2 11.0
ページ4に含まれる内容の要旨
© Copyright 2007 Zoeller Co. All rights reserved. 4 Pump Performance Data TOTAL DYNAMIC HEAD / FLOW PER MINUTE EFFLUENT 1/2 HP 3/4 HP 1 HP 1 1/2 HP MODEL 4 STAGE 6 STAGE 7 STAGE 10 STAGE Feet Meters Gal. Liters Gal. Liters Gal. Liters Gal. Liters 20 6.1 32.9 124.5 35.9 135.9 37.5 141.9 37.4 141.6 40 12.2 30.1 113.9 34.2 129.5 35.8 135.5 36.3 137.4 60 18.3 26.4 99.9 32.3 122.3 34.1 129 35.2 133.3 80 24.4 22.3 84.4 30.4 115 32.3 122.3 34.3 129.8 100 30.5 16.1 60.9 28 106 30.4 115.1 32.9 124.5 120
ページ5に含まれる内容の要旨
Electrical Data for Zoeller Effl uent Turbine Pumps Locked Fuse/Circuit Winding Maximum Rotor KVA Breaker Amps Re sis tance HP Volts Phase Hz S.F. Amps Watts Amps Code Std. Delay Line to Line 1/2 115 1 60 1.6 12 970 64.4 R 30 15 1.0 - 1.3 1/2 230 1 60 1.6 6 970 32.2 R 15 8 4.2 - 5.2 3/4 230 1 60 1.5 8 1325 40.7 N 20 10 3.0 - 3.6 1 230 1 60 1.4 9.8 1600 48.7 N 25 11 2.2 - 2.7 1 1/2 230 1 60 1.3 13.1 2250 56.8 L 35 15 1.5 - 1.9 2 230 1 60 1.25 Y 13.2 2650 51.0 G 30 15 1.6 - 2.
ページ6に含まれる内容の要旨
Pump Installation and Wiring Diagram 1. Submersible ef fl u ent turbine pumps may be installed in any ap pli ca tion 8. An alarm should be used with any system using a pump. Follow where relatively clear effl uent, such as from a dos ing tank or high the wiring diagram with the alarm for installation and check your head STEP system etc., is being pumped. local codes. 2. Pumps should always be installed vertically. Pumps should never 9. Run the appropriate power to the control panel from a fu
ページ7に含まれる内容の要旨
Splicing Underground Wires Splicing of wires to be buried must be done according to the National Electrical Code. Wire connectors or splicing means installed on conductors for direct burial shall be listed for such use. Start-up and Maintenance Before placing the equipment into operation the following must be be air locked. To expel trapped air, jog the unit several times, using checked: the manual con trols. • Septic tank and/or pump chamber should be pumped and cleaned Have a qualifi ed elec
ページ8に含まれる内容の要旨
Typical Installations ALL INSTALLATIONS REQUIRE A FILTER BEFORE THE PUMP. WARNING! P/N Z Z OELLER ZOELLER EFFLUENT TURBINE PUMP NOTE: Flow must be directed around the motor for cooling on 2 HP and higher units. SK2220 SEPTIC TANK ! WARNING ELECTRICAL HAZARD SHOCK P/N 10-1193 REV. A C ZO Z0ELLER PUMP LOUISVILLE, KY CO. ZOELLER EFFLUENT TURBINE PUMP SK2219 SEPTIC TANK MAIL TO: P.O. BOX 16347 Louisville, KY 40256-0347 Manufacturers of . . SHIP TO: 3649 Cane Run Road Louisville, KY 4021
