ページ1に含まれる内容の要旨
Quality Refrigeration
OWNER’S MANUAL
Instructions for the installation, operation
and maintenance of all Traulsen:
Reach-In Even Thaw Refrigerator Models*
RET132EUT
RET232EUT
RET232NUT
*For roll-in even-thaw models please refer to form number TR35867.
This Traulsen unit is built to our highest quality standards. We build our refrigerators, freezers and heated
cabinets this way as a matter of pride. This philosophy has made Traulsen the leader in commercial
refrigeration since
ページ2に含まれる内容の要旨
TABLE OF CONTENTS I. THE SERIAL TAG Page 1 VI. OTHER II. RECEIPT INSPECTION Page 2 a-Service Information Page 5 III. INSTALLATION b-Spare Parts Page 5 a-Location Page 2 c-Warranty Registration Page 5 b-Packaging Page 2 VII. GEN’L USE, OPERATION & SERVICE Page 6 c-Installing Legs or Casters Page 2 VIII. EXPECTED THAW PERFORMANCE/ d-Tray Slides Page 3 OPERATIONAL TROUBLESHOOTING e-Cord & Plug Page 3 a-Introduction Page 6 f-Power Supply Page
ページ3に含まれる内容の要旨
II. RECEIPT INSPECTION III. INSTALLATION (continued) All Traulsen products are factory tested for performance and III. c - INSTALLING LEGS OR CASTERS: are free from defects when shipped. The utmost care has 6” high stainless steel legs are supplied standard for been taken in crating this product to protect against damage all Traulsen reach-in and pass-thru units. Casters in in transit. All interior fittings have been carefully secured and lieu of legs are available as an optional accessory
ページ4に含まれる内容の要旨
III. INSTALLATION (continued) IV. OPERATION IV. a - EVEN-THAW OVERVIEW: III. d - TRAY SLIDES: The “Even-Thaw” refrigerator was specially designed to thaw Reach-In models are supplied with fourteen (14) pairs of #1 frozen food product under safe, temperature controlled condi- type tray slides on 4” centers. These are shipped installed tions. It is not intended as a storage refrigerator. from the factory, and are easily removable for cleaning without tools. NOTE: USING THIS REFRIGERATOR FOR S
ページ5に含まれる内容の要旨
IV. OPERATION (continued) V. CARE & MAINTENANCE IV. d - BATCH LOADING: V. a - CLEANING THE CONDENSER: The Even-Thaw model can accommmodate any size partial The most important thing you can do to insure a long, reli- load, or up to twenty eight (28) 18” x 26” pans of product. Use able service life for your Traulsen is to regularly clean the of aluminum pans is highly recommended. Product should be condenser coil. placed on pans in one layer only to allow for proper air flow. The condensing unit
ページ6に含まれる内容の要旨
V. CARE & MAINTENANCE (continued) VI. OTHER VI. a - SERVICE INFORMATION: V. c - REPLACING THE GASKETS: Before calling for service, please check the following: To remove the gasket to be replaced, grasp it firm- ly by one corner and pull it out. Before attempting to in- Is the electrical cord plugged in? stall a new gasket, both the unit and the gasket itself must be at room temperature. Insert the four corners Is the fuse OK or circuit breaker on? first by using a rubber mallet (or hammer wi
ページ7に含まれる内容の要旨
VII. GENERAL USE, OPERATION & VIII. EXPECTED THAW PERFOR- SERVICE SUMMARY MANCE/OPERATIONAL TROUBLE- SHOOTING VII. a - INTRODUCTION/OVERVIEW: VIII. a - INTRODUCTION: The Traulsen Even Thaw is designed to be used as a Even thaw performance is a function of many factors, espe- thawing cabinet. While it may be utilized in a refrigeration cially those involving product types and loading. As a result, mode, that is not its intended use. Its function is to hold the actual thaw times will vary as eve
ページ8に含まれる内容の要旨
VIII. EXPECTED THAW PERFORMANCE/OPERATIONAL TROUBLESHOOTING (continued) VIII. e - INCOMPLETE THAWING: In operation, incomplete thawing (i.e. bags of product in which not every piece was completely thawed) has been found to usually be the result of those pkgs. respective pan level having had restricted airflow due to overloading (from stacked pkgs. or irregular shaped packages that blocks air from getting to the pkgs. closest to the cabinet interior side wall or rear). Allowing for proper
ページ9に含まれる内容の要旨
IX. TROUBLE SHOOTING GUIDE FIND YOUR PROBLEM HERE REMEDY 1. Condensing unit fails to start. a. Check if cord & plug has been disconnected. 2. Condensing unit operates for a. Are doors closing properly? prolonged periods or continuously. b. Dirty condenser or filter. Clean properly. c. Evaporator coil iced. Needs to defrost. d. Shortage of refrigerant, call service. 3. Food compartment is too warm. a. Check door(s) and gasket(s) for pr
ページ10に含まれる内容の要旨
X. SPARE PARTS LIST MODEL DESCRIPTION PART NUMBER RE132E-FHS FULL HEIGHT DOOR GASKET 341-60105-00 TXV VALVE 404A 325-60080-08 LIGHT BULB 378-29776-00 MIT II CONTROL MODULE 110V 337-60317-60 OFF/ON POWER SWITCH 337-60346-00 AIR FILTER 341-60062-05 CONDENSER FAN BLADE 325-60135-00 CONDENSER FAN MOTOR 338-60050-00 TRAY SLIDE, #1 LONG 701-60032-00 RE232E-FHS FULL HEIGHT DOOR GASKET SFO-17357-00 TXV VALVE 404A 325-60080-39 LIGHT BULB 378-40414-00 MIT II RELAY MODULE 230V 337-60317-61 OFF/ON POWER SWI
ページ11に含まれる内容の要旨
XI. WIRING DIAGRAM ALL ONE SECTION MODELS ONLY -10-
ページ12に含まれる内容の要旨
XI. WIRING DIAGRAM MODELS RET232NUT-FHS & RET232NUT-HHS ONLY -11-
ページ13に含まれる内容の要旨
XI. WIRING DIAGRAM MODELS RET232EUT-FHS & RET232EUT-HHS ONLY -12-
ページ14に含まれる内容の要旨
XII. WARRANTY INFORMATION STANDARD DOMESTIC WARRANTY TRAULSEN warrants new equipment to the original purchaser, when installed within the United States against defective material and workmanship for three (3) years from the date of original installation. Under this warranty, TRAULSEN will repair or replace, at its option, including service and labor, all parts found to be defective and subject to this warranty. Warranty term begins upon the date of Installation, the date of End User Inv
ページ15に含まれる内容の要旨
Notes:
ページ16に含まれる内容の要旨
HOURS OF OPERATION: Monday thru Friday 7:30 am - 4:30 pm CST Traulsen 4401 Blue Mound Road Fort Worth, TX 76106 Phone: (800) 825-8220 Fax-Svce: (817) 740-6757 Website: www.traulsen.com Quality Refrigeration © 2013 Traulsen - All Rights Reserved
