ページ1に含まれる内容の要旨
installation, start-up and
558F
service instructions
DuraPac Series
Sizes 090-151
SINGLE PACKAGE ROOFTOP
1 1
7 / to 12 / Tons
2 2
ELECTRIC HEATING/ELECTRIC COOLING UNITS
Cancels: II 558F-90-3 II 558F-90-4
9/15/05
IMPORTANT — READ BEFORE INSTALLING INSTALLATION
Read and become familiar with these installation instruc- Unit is shipped in the vertical discharge configuration. To
tions before installing this unit. convert to horizontal configuration, remove screws from hor-
izontal duct opening cov
ページ2に含まれる内容の要旨
Fig. 1 — Horizontal Conversion Panels Ducts passing through an unconditioned space must be insu- The center drain plug looks like a star connection, however it 1 lated and covered with a vapor barrier. can be removed with a / in. socket drive extension. 2 If plenum return is used on a vertical unit, the return should IV. STEP 4 — RIG AND PLACE UNIT be ducted through the roof deck to comply with applicable Inspect unit for transportation damage. File any claim with fire codes. transportation agen
ページ3に含まれる内容の要旨
D ALT ROOF CURB UNIT CONNECTOR ACCESSORY “A” BC DRAIN GAS POWER CONTROL ACCESSORY SIZE PKG. ACCY. POWER HOLE CRRFCURB003A01 1′-2″ [356] 558F 3 3 CRBTMPWR001A01 / ″ [19] NPT / ″ 4 4 090-151 CRRFCURB004A01 2′-0″ [610] [19] NPT 1 CRBTMPWR002A01 1 / ″ [31.7] 4 1 /2″ 7 15 3 1 2′-8 / ″ 1′-10 / ″ 1 / ″ 1 / ″ 16 16 4 / ″ 2 2 3 [12.7] CRBTMPWR003A01 /4″ [19] NPT NOTES: [827] [583] [44.5] [12.7] NPT [12.7] NPT NPT 1.Roof curb accessory is shipped 3 / ″ 4 1 disassembled. CRBTMPWR004A01 1 /4″ [31.7] [19] N
ページ4に含まれる内容の要旨
MAXIMUM ALLOWABLE DIFFERENCE (in.) A-B B-C A-C 0.5 1.0 1.0 Fig. 3 — Unit Leveling Tolerance NOTE: Trap should be deep enough to offset maximum unit static differ- ence. A 4-in. trap is recommended. Fig. 5 — Condensate Drain Piping Details HORIZONTAL DRAIN PLUG DRAIN OUTLET NOTE: Drain plug is shown in factory-installed position. Fig. 4 — Condensate Drain Connection (Side View) NOTES: DIMENSIONS OPERATING 1. Dimension in ( ) is in millimeters. UNIT WEIGHT ‘‘A’’ ‘‘B’’ ‘‘C’’ 2. Hook rigging shack
ページ5に含まれる内容の要旨
—5— Fig.7A — Base Unit Dimensions — 558F090,102,120,150
ページ6に含まれる内容の要旨
—6— Fig. 7B — Base Unit Dimensions — 558F091,103,121,151
ページ7に含まれる内容の要旨
Table 1A — Physical Data — 558F090,102,120,150 Units 558F UNIT SIZE 090 102 120 150 1 1 1 NOMINAL CAPACITY (tons) 7 / 8 / 10 12 / 2 2 2 OPERATING WEIGHT (lb) Unit Al/Al* 755 760 915 930 Al/Cu* 766 776 937 957 Cu/Cu* 778 787 960 980 EconoMi$er IV 75 75 75 75 Roof Curb† 143 143 143 143 COMPRESSOR Reciprocating Reciprocating Reciprocating Scroll Quantity 22 22 No. Cylinders (per circuit) 22 2 — Oil (oz) 42 ea 65 ea 54 ea 54 ea REFRIGERANT TYPE R-22 Operating Charge (lb-oz) Circuit 1 4-13 6-14 7- 3
ページ8に含まれる内容の要旨
Table 1B — Physical Data — 558F091,103,121,151 Units (ASHRAE 90.1-1999 Compliant Units) 558F UNIT SIZE 091 103 121 151 1 1 1 NOMINAL CAPACITY (tons) 7 / 8 / 10 12 / 2 2 2 OPERATING WEIGHT (lb) Unit Al/Al* 755 760 915 930 Al/Cu* 766 776 937 957 Cu/Cu* 778 787 960 980 Economizer EconoMi$er IV 75 75 75 75 Roof Curb† 143 143 143 143 COMPRESSOR Reciprocating Scroll Scroll Scroll Quantity 22 22 No. Cylinders (per Circuit) 22 22 Oil (oz) (each compressor) 42 53 50 60 REFRIGERANT TYPE R-22 Expansion Dev
ページ9に含まれる内容の要旨
V. STEP 5 — MAKE ELECTRICAL CONNECTIONS 1. If unit is mounted on roof curb and accessory thru- the-bottom connection is used, route wire through WARNING: Unit cabinet must have an uninter- connector provided in accessory kit through the unit rupted, unbroken electrical ground to minimize the basepan. possibility of personal injury if an electrical fault 2. Pass control wires through the hole provided on unit should occur. This ground may consist of electrical wire (see connection D, Connection
ページ10に含まれる内容の要旨
Table 2A — Electrical Data (Units Without Convenience Outlet) (558F090, 102, 120, 150) VOLTAGE COMPRESSOR OFM ELECTRIC POWER DISCONNECT 558F RANGE (ea) (ea) HEAT SUPPLY SIZE* NOMINAL IFM IFM UNIT V-Ph-Hz TYPE FLA Nominal SIZE Min Max RLA LRA Qty Hp FLA FLA MCA MOCP† FLA LRA kW — — 40.1/ 40.1 45/ 45 42/ 42 7.8/10.4 21.7/ 25.0 40.1/ 40.1 45/ 45 42/ 42 Std 12.0/16.0 33.4/ 38.5 48.9/ 55.4 50/ 60 45/ 51 and 5.8 229/229 18.6/24.8 51.7/ 59.7 71.9/ 81.8 80/ 90** 66/ 75 Alt 24.0/32.0 66.7/ 77.0 90.6/103.
ページ11に含まれる内容の要旨
Table 2A — Electrical Data (Units Without Convenience Outlet) (558F090, 102, 120, 150) (cont) VOLTAGE COMPRESSOR OFM ELECTRIC POWER DISCONNECT 558F RANGE (ea) (ea) HEAT SUPPLY SIZE* NOMINAL IFM IFM UNIT V-Ph-Hz TYPE FLA Nominal SIZE Min Max RLA LRA Qty Hp FLA FLA MCA MOCP† FLA LRA kW — — 43.1/ 43.1 50/ 50 45/ 45 7.8/10.4 21.7/ 25.0 43.1/ 43.1 50/ 50 45/ 45 12.0/16.0 33.4/ 38.5 48.9/ 55.4 60/ 60 45/ 51 Std 5.8 307/307 24.0/32.0 66.7/ 77.0 90.6/103.5 100/110** 83/ 95 31.8/42.4 88.4/102.0 117.7/134
ページ12に含まれる内容の要旨
Table 2A — Electrical Data (Units Without Convenience Outlet) (558F090, 102, 120, 150) (cont) VOLTAGE COMPRESSOR OFM ELECTRIC POWER DISCONNECT 558F RANGE (ea) (ea) HEAT SUPPLY SIZE* NOMINAL IFM IFM UNIT V-Ph-Hz TYPE FLA Nominal SIZE Min Max RLA LRA Qty Hp FLA FLA MCA MOCP† FLA LRA kW — — 65.2/ 65.2 80/ 80** 68/ 68 7.8/10.4 21.7/ 25.0 65.2/ 65.2 80/ 80** 68/ 68 12.0/16.0 33.4/ 38.5 65.2/ 65.2 70/ 70** 68/ 68 Std 10.6 383/383 24.0/32.0 66.7/ 77.0 96.6/109.5 100/110** 89/101 31.8/42.4 88.4/102.0 12
ページ13に含まれる内容の要旨
Table 2B — Electrical Data (Units Without Convenience Outlet) (558F091, 103, 121, 151) VOLTAGE COMPRESSOR DISCONNECT OFM (ea) ELECTRIC HEAT POWER SUPPLY 558F HEATER SINGLE POINT RANGE (ea) SIZE* NOMINAL IFM IFM UNIT MODEL NO. BOX P/N V-PH-Hz TYPE FLA Nominal SIZE CRHEATER---A00 CRSINGLE---A00 Min Max Qty RLA LRA Qty Hp FLA FLA MCA MOCP† FLA LRA kW NONE —/— —/— 40.1/ 40.1 45/ 45 42/ 42 229/229 — 017 7.8/10.4 21.7/ 25.0 40.1/ 40.1 45/ 45 42/ 42 229/229 006 010 12.0/16.0 33.4/ 38.5 48.9/ 55.4 50/ 6
ページ14に含まれる内容の要旨
Table 2B — Electrical Data (Units Without Convenience Outlet) (558F091, 103, 121, 151) (cont) VOLTAGE COMPRESSOR DISCONNECT OFM (ea) ELECTRIC HEAT POWER SUPPLY 558F HEATER SINGLE POINT RANGE (ea) SIZE* NOMINAL IFM IFM UNIT MODEL NO. BOX P/N V-PH-Hz TYPE FLA Nominal SIZE CRHEATER---A00 CRSINGLE---A00 Min Max Qty RLA LRA Qty Hp FLA FLA MCA MOCP† FLA LRA kW NONE —/— —/— 44.3/ 44.3 50/ 50 46/ 46 272/272 — 017 7.8/10.4 21.7/ 25.0 44.3/ 44.3 50/ 50 46/ 46 272/272 006 010 12.0/16.0 33.4/ 38.5 48.9/ 55.
ページ15に含まれる内容の要旨
Table 2B — Electrical Data (Units Without Convenience Outlet) (558F091, 103, 121, 151) (cont) VOLTAGE COMPRESSOR DISCONNECT OFM (ea) ELECTRIC HEAT POWER SUPPLY 558F HEATER SINGLE POINT RANGE (ea) SIZE* NOMINAL IFM IFM UNIT MODEL NO. BOX P/N V-PH-Hz TYPE FLA Nominal SIZE CRHEATER---A00 CRSINGLE---A00 Min Max Qty RLA LRA Qty Hp FLA FLA MCA MOCP† FLA LRA kW NONE —/— —/— 56.2/ 56.2 70/ 70** 59/ 59 359/359 — 017 7.8/10.4 21.7/ 25.0 56.2/ 56.2 70/ 70** 59/ 59 359/359 012 010 12.0/16.0 33.4/ 38.5 56.2
ページ16に含まれる内容の要旨
Table 2C — Electrical Data (Units With Convenience Outlet) (558F090, 102, 120, 150) VOLTAGE COMPRESSOR OFM ELECTRIC POWER DISCONNECT 558F RANGE (ea) (ea) HEAT SUPPLY SIZE* NOMINAL IFM IFM UNIT V-Ph-Hz TYPE FLA Nominal SIZE Min Max RLA LRA Qty Hp FLA FLA MCA MOCP† FLA LRA kW — — 46.1/ 46.1 50/ 50 48/ 48 7.8/10.4 21.7/ 25.0 46.1/ 46.1 50/ 50 48/ 48 Std 12.0/16.0 33.4/ 38.5 53.9/ 60.4 60/ 70** 51/ 56 and 5.8 233/233 18.6/24.8 51.7/ 59.7 76.9/ 86.8 80/ 90** 72/ 81 Alt 24.0/32.0 66.7/ 77.0 95.6/108.5
ページ17に含まれる内容の要旨
Table 2C — Electrical Data (Units With Convenience Outlet) (558F090, 102, 120, 150) (cont) VOLTAGE COMPRESSOR OFM ELECTRIC POWER DISCONNECT 558F RANGE (ea) (ea) HEAT SUPPLY SIZE* NOMINAL IFM IFM UNIT V-Ph-Hz TYPE FLA Nominal SIZE Min Max RLA LRA Qty Hp FLA FLA MCA MOCP† FLA LRA kW — — 49.1/ 49.1 60/ 60 50/ 50 7.8/10.4 21.7/ 25.0 49.1/ 49.1 60/ 60 50/ 50 12.0/16.0 33.4/ 38.5 53.9/ 60.4 60/ 70** 51/ 56 Std 5.8 311/311 24.0/32.0 66.7/ 77.0 95.6/108.5 100/110** 89/101 31.8/42.4 88.4/102.0 122.7/139.
ページ18に含まれる内容の要旨
Table 2C — Electrical Data (Units With Convenience Outlet) (558F090, 102, 120, 150) (cont) VOLTAGE COMPRESSOR OFM ELECTRIC POWER DISCONNECT 558F RANGE (ea) (ea) HEAT SUPPLY SIZE* NOMINAL IFM IFM UNIT V-Ph-Hz TYPE FLA Nominal SIZE Min Max RLA LRA Qty Hp FLA FLA MCA MOCP† FLA LRA kW — — 71.2/ 71.2 80/ 80** 74/ 74 7.8/10.4 21.7/ 25.0 71.2/ 71.2 80/ 80** 74/ 74 12.0/16.0 33.4/ 38.5 71.2/ 71.2 80/ 80** 74/ 74 Std 10.6 387/387 24.0/32.0 66.7/ 77.0 101.6/114.5 94/106 110/125** 31.8/42.4 88.4/102.0 128.
ページ19に含まれる内容の要旨
Table 2D — Electrical Data (Units With Convenience Outlet) (558F091, 103, 121, 151) VOLTAGE COMPRESSOR DISCONNECT 558F OFM (ea) ELECTRIC HEAT POWER SUPPLY HEATER SINGLE POINT RANGE (ea) SIZE* NOMINAL IFM IFM UNIT MODEL NO. BOX P/N V-PH-Hz TYPE FLA Nominal SIZE CRHEATER---A00 CRSINGLE---A00 Min Max Qty RLA LRA Qty Hp FLA FLA MCA MOCP† FLA LRA kW NONE —/— —/— 44.9/ 44.9 50/ 50 48/ 48 234/234 — 017 7.8/10.4 21.7/ 25.0 44.9/ 44.9 50/ 50 48/ 48 234/234 006 010 12.0/16.0 33.4/ 38.5 55.0/ 60.8 60/ 60 5
ページ20に含まれる内容の要旨
Table 2D — Electrical Data (Units With Convenience Outlet) (558F091, 103, 121, 151) (cont) VOLTAGE COMPRESSOR DISCONNECT 558F OFM (ea) ELECTRIC HEAT POWER SUPPLY HEATER SINGLE POINT RANGE (ea) SIZE* NOMINAL IFM IFM UNIT MODEL NO. BOX P/N V-PH-Hz TYPE FLA Nominal SIZE CRHEATER---A00 CRSINGLE---A00 Min Max Qty RLA LRA Qty Hp FLA FLA MCA MOCP† FLA LRA kW NONE —/— —/— 49.1/ 49.1 60/ 60 52/ 52 277/277 — 017 7.8/10.4 21.7/ 25.0 49.1/ 49.1 60/ 60 52/ 52 277/277 006 010 12.0/16.0 33.4/ 38.5 55.0/ 60.8 6
