ページ1に含まれる内容の要旨
PCG-GRS150/GRS170
SERVICE MANUAL For American Area
US Model
CanadianModel
Ver 1-2002J
Revision History
S400
Lineup : PCG-GRS170
PCG-GRS150
Illust : PCG-GRS170
• Design and specifications are subject to
change without notice.
NOTEBOOK COMPUTER
9-876-018-01
Confidential
ページ2に含まれる内容の要旨
Information in this document is subject to change without notice. Caution Markings for Lithium/Ion Battery - The following or similar texts shall be provided on battery pack of equipment or in both the Sony, VAIO and CLIE are trademarks or registered trademarks of operating and the service instructions. Sony. Microsoft, Windows, Windows Media, Outlook, Bookshelf and other Microsoft products are trademarks or registered trademarks CAUTION: Danger of explosion if battery is incorrectly replaced. o
ページ3に含まれる内容の要旨
TABLE OF CONTENTS Section Title Page CHAPTER 1. BLOCK DIAGRAM ............................... 1-1 (to 1-2) CHAPTER 2. FRAME HARNESS DIAGRAM ........ 2-1 (to 2-2) CHAPTER 3. EXPLODED VIEWS AND PARTS LIST ............................................ 3-1 3-1. Main Section .................................................................... 3-2 3-2. LCD Section – Made by HI – .......................................... 3-5 3-3. Connector Section (CH Type Only) ................................. 3-7 (t
ページ4に含まれる内容の要旨
Headphone MIC Speaker CHAPTER 1. BLOCK DIAGRAM Chipset : Intel 845MZ 200MHz Memory Bus Memory Pentium 4 (DDR1600) CPU Lo cal Bus CONTROLLER Processor CLKGEN HUB (MCH) 512KB L2 SMBUS2 SMBUS 2 IM I 15inch XGA 593 FCBGA 478pins 9870GT D DDR(SO-DIMM) Port Repricator SONY uFCPGA Refer to Clock Generator TV-Out Block Diagram LCD CONN AV Cable USB Right Port-0 Out LineOut CONN Total max memory size TV-Out 512MB AV USB Left Port-3 Out LineOut CONN Port-3 Graphics VGA DSUB-15 USB3 AT I USB Rear Port-2 M7
ページ5に含まれる内容の要旨
CHAPTER 2. FRAME HARNESS DIAGRAM LCD Block ANTENNA ANTENNA LCD EXTERNAL MICROPHONE (GRS70P Model) INVERTER HEADPHONE PHONE USB USB USB NETWORK PRINTER DC-IN AV OUT MONITOR Rear Panel PCGA-PRGR2 Port Replicator HARNESS (2P) CN5001 CN1801 99 1 CN3501 CN9301 J9331 CN1501 100 2 IEEE 1394 i.LINK CN2901 CN3101 MODEM CARD 1 7 1 11 CN1112 LCD HARNESS 2 8 2 12 MBX-75 Board FFC CN2007 CPU (Side-A) VIF-22 Board (Side-A) 12 1 7 1 MEMORY PC CARD CN4601 8 2 STICK CONNECTOR 2 1 DC FAN CN101 FFC Side IFX-203 B
ページ6に含まれる内容の要旨
CHAPTER 3. EXPLODED VIEWS AND PARTS LIST NOTE: • Items marked “ * ” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • The mechanical parts with no reference number in the exploded views are not supplied. • When two or more parts are shown in parallel, use the part described first as the main part. • The parts marked “ $ ” are the High Value Modules. • The parts marked “ # ” are the parts on which barcode label is att
ページ7に含まれる内容の要旨
3-1. Main Section Ref.No. Part No. Description Ref.No. Part No. Description 1 4-667-050-01 ESCUSHION (TP) 63 4-653-801-11 [CH]...SHEET HDD 2 1-796-166-21 PAD, TOUCH 64 4-653-799-11 [CH]...BRACKET HDD 3 X-4625-237-1 HOUSING (PALM REST) ASSY 65 X-4625-233-1 ASSY DOOR HDD 4 4-667-053-01 ESCUSHION (JOG) 66 1-761-564-21 # (GRS150)...WIRELESS LAN CARD * 5 4-667-062-01 PLATE (GND) 67 X-4625-236-1 HOUSING BOTTOM ASSY 6 9-885-028-59 GT T/P FPC 68 4-654-379-12 [CH]...COVER (PORT) 7 4-653-795-01 [CH]...BUT
ページ8に含まれる内容の要旨
60 30 B3 31 B3 84 B2 83 1 A R M B17 K E 18 B12 38 2 23 98 40 B10 V 27 F P B2 21 Q P B2 76 16 B10 B3 S 24 B6 70 M B2 20 72 71 B13 75 GRS150 72 B17 B11 B15 Model B7 B3 B11 D 11 26 B17 B13 B17 B B7 E B2 I 17 U V 3 70 T 61 W C G 25 97 L Supplied with 3 B13 O H 86 19 B3 G S B17 B1 4 102 A GRS150 92 77 D 101 Model N 39 7 50 B20 6 51 B6 91 B15 100 78 41 58 B15 O 10 22 15 59 29 89 52 53 90 W 73 C 8 B20 34 74 B4 J 32 GRS150 L 53 F I 9 66 Model 55 B3 33 36 47 J B3 B2 37 B4 B3 Q 5 B2 K B17 T 57 56 U B20 5
ページ9に含まれる内容の要旨
Ref.No. Part No. Description Ref.No. Part No. Description 3-2. LCD Section – Made by HI – 201 4-666-090-01 COVER SCREW LOWER ACCESSORIES 202 X-4625-183-1 HOUSING (BEZEL 15) ASSY ************ 205 203 4-667-073-01 COVER (HINGE) 203 B18 202 204 1-754-261-11 (GRS150)... 0800 1-477-205-42 $ ADAPTOR, AC FILM ANTENNA (FOR LEFT) 801 A-8110-809-A $# BP2NX SNT (U) ASSY (S) 205 4-666-091-01 COVER SCREW UPPER 0802 1-757-562-21 CORD, POWER 201 222 803 4-653-768-02 WEIGHT SAVER 206 4-666-340-01 LATCH HONTAI (
ページ10に含まれる内容の要旨
Ref.No. Fig. Part No. Description 3-3. Connector Section (CH Type only) 901 1-817-023-11 [CH]...CONNECTOR, USB USB connector 902 1-779-745-21 [CH]...JACK, DC DC IN connector 903 X-4625-501-1 [CH]...BRACKET IO ASSY I/O Bracket 901 ∗ Among the parts that are used on the boards of this model, only the connectors that are show in the list can be replaced. (The parts other that the specified connectors cannot be replaced.) 902 903 902 901 902 901 Confidential 3-7 3-8 PCG-GRS150/GRS170 (AM) (END)
ページ11に含まれる内容の要旨
PCG-GRS150/GRS170 (AM) List of PCG-GRS Series (As of October, 2002) Service Manual Model Name Part No. PCG-GRS150 9-876-018-01 PCG-GRS170 This manual and the constituent data may not be replicated, copied nor reprinted in whole or in part without prior written authorization of Sony Corporation. English 2002J1600-1 9-876-018-01 Sony Corporation © 2002 Sony Corporation Published by Sony EMCS VAIO-GSC [SNT] — 24 —
ページ12に含まれる内容の要旨
Revision History Suffix Ver. Date Contents QM No. First -01 Ver. 1 2002.10.15 Edition < Remarks > [Confidential] PCG-GRS150/GRS170 (AM)
