ページ1に含まれる内容の要旨
®
Accu-Z
® ® ®
Z52 , Z60 & Z72 Zero Turning Radius Mowers
19097
356-005M
Operator’s Manual
Read the Operator’s manual entirely. When
you see this symbol, the subsequent
!
instructions and warnings are serious - follow
without exception. Your life and the lives of
others depend on it!
© Copyright 2003 Printed 03/11/03
Cover photo may show optional equipment not supplied
with standard unit.
ページ2に含まれる内容の要旨
Land Pride Table of Contents Table of Contents Important Safety Information . . . . . . . . . . . . . . . . . . .1 Control Lever Stops . . . . . . . . . . . . . . . . . . . . . . . 22 Introduction. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6 Reverse Spring Adjustment . . . . . . . . . . . . . . . . . 22 Application . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6 Steering Dampener. . . . . . . . . . . . . . . . . . . . . . . . 23 Using This Manual . . . . .
ページ3に含まれる内容の要旨
ON ▲ Land Pride Important Safety Information Important Safety Information These are common practices that may or may not be applicable to the products described in this manual. Keep Riders Be Aware of Signal Words ! WARNING! Indicates a potentially hazardous Off Machinery A signal word designates a degree or situation which, if not avoided, could level of hazard seriousness. The ▲ Riders obstruct the operator’s result in death or serious injury, and signal words are: view, they could be struck b
ページ4に含まれる内容の要旨
Land Pride Important Safety Information These are common practices that may or may not be applicable to the products described in this manual. ▲ Inspect all parts. Make sure parts Practice Safe Maintenance are in good condition & installed ▲ Understand procedure before properly. doing work. Use proper tools and ▲ Remove buildup of grease, oil or equipment, refer to Operator’s debris. Manual for additional information. ▲ Remove all tools and unused ▲ Work in a clean dry area. parts before operati
ページ5に含まれる内容の要旨
Land Pride Important Safety Information These are common practices that may or may not be applicable to the products described in this manual. Avoid High Wear Prepare for Emergencies Pressure Fluids Hazard Protective Equipment ▲ Be prepared if a fire starts. ▲ Escaping fluid under pressure can ▲ Protective clothing and equipment ▲ Keep a first aid kit and fire penetrate the skin causing serious should be worn. extinguisher handy. injury. ▲ Wear clothing and equipment ▲ Keep emergency numbers for ▲ A
ページ6に含まれる内容の要旨
Land Pride Important Safety Information 838-303C Danger: Battery 19097 (Beneath Seat) 838-305C 19098 Warning: Rollover Hazard (Beneath Bumper on Back of Frame) 838-306C 19097 Warning: Do not operate without deflector 818-543C 19097 Danger: Guard is missing (Beneath foot pan on mower deck) Z52®, Z60® & Z72® Zero Turning Radius Mowers Accu-Z 356-005M 03/11/03 4
ページ7に含まれる内容の要旨
Land Pride Important Safety Information 838-307C Warning: Moving Parts (Both Sides) 19057 838-308C Warning: Rotating Blade 19057 Hazard (Both Sides) 838-310C 19097 Warning: General 838-399C 19057 Warning: Fuel Imbedded in Fuel Tank 03/11/03 Z52®, Z60® & Z72® Zero Turning Radius Mowers Accu-Z 356-005M 5
ページ8に含まれる内容の要旨
Land Pride Introduction Introduction Land Pride welcomes you to the growing family of new The parts on your Accu-Z Mower have been specially product owners. designed and should only be replaced with genuine Land Pride parts. Therefore, should your Accu-Z require This mower has been designed with care and built by replacement parts go to your Land Pride Dealer. skilled workers using quality materials. Proper assembly, IMPORTANT: maintenance, and safe operating practices will help you For parts an
ページ9に含まれる内容の要旨
Land Pride Section 1 Assembly and Set-Up Section 1 Assembly and Set-Up Control Lever and Seat Assembly The seat is removed for ease in shipping and the control lever’s upper bolts and flat washers are removed and the levers are rotated down. Refer to Figure 1-1: 1. Install the standard seat (#1) (or the optional suspension seat) to the seat pan (#2) using four 5/16” nuts (#3) and four 5/16” flat washers (#4). 2. Connect the switch wires on the mower with the switch wires on the seat. Secure the s
ページ10に含まれる内容の要旨
Land Pride Section 1 Assembly and Set-Up Refer to Figure 1-4: 6. Insert the air cleaner hose through the hole in the air cleaner hood and slide hose end over the carburetor intake. 7. Secure air cleaner to the air cleaner hood with two 5/ 16” bolts, four 5/16” flat washers and two 5/16” nuts. 8. Secure hose to the carburetor intake with hose clamp. 5/16” Bolt Hose Clamp 20860 Figure 1-4 Optional Equipment Assemblies Air Cleaner Remote Air Cleaner Assembly Refer to Figure 1-2 page 7: The remote ai
ページ11に含まれる内容の要旨
Land Pride Section 1 Assembly and Set-Up Mower Deck Preparation Accu-Vac Assembly Refer to Figure 1-6: Refer to Figure 1-9 on page 12 Park the Accu-Z mower on a flat surface. Shut off the Land Pride offers as an option an Accu-Vac Collection ignition switch and remove the key from the switch. System designed to collect mower clippings into two 30 Disconnect the negative battery cable. gallon rubber containers mounted on the back of the mower. Before the Accu-Vac can be installed, the right side
ページ12に含まれる内容の要旨
Land Pride Section 1 Assembly and Set-Up Blower, Pulley and Pulley Cover Assembly 6. Install blower belt (#16) to double pulley and route it as shown. (Belt must be on top pulley) Refer to Figure 1-7: 1. Install double pulley (#13) with the bolt (#11) and existing flat washer (#12) Torque bolt 65 - 75 lbs. Blower 2. Reinstall blade drive belt on lower grove of pulley Drive Belt (13). 3. Assemble bracket (#4) where the chute bracket was assembled using the existing hardware (#2) and (#3). 4. Assem
ページ13に含まれる内容の要旨
Land Pride Section 1 Assembly and Set-Up Bagger Assembly Refer to Figure 1-8: ! CAUTION! Muffler can cause burning. Muffler should be cool before pro- ceeding. NOTE: Accu-Vac Collection System cannot be mounted on Accu-Z mowers manufactured with 3. Position muffler deflector (#5) on existing muffler Honda engines. Use only with Kawasaki engines. exhaust so that deflector is pointing away from the plastic containers. Mark for hole through deflector (#5) 1. Remove and retain rear bumper bolts (#3) and fla
ページ14に含まれる内容の要旨
Land Pride Section 1 Assembly and Set-Up 5. Install bagger (#1) through brackets and secure with pins (#2). NOTE: Lubricant can be used when installing tube to 6. Assemble clamps (#3) on the ends of the bagger tube bagger so the tube will slide over bagger inlet easier. (#4) and slide the tube over the bagger inlet and the blower as shown in Figure 1-9 and tighten clamps. Bagger Assembly Figure 1-9 19911 Front Lift and Weight Assembly (For Blade Service or Replacement) IMPORTANT: Do not use jack
ページ15に含まれる内容の要旨
Land Pride Section 2 Operation Section 2 Operation 19058 15. Right Belt/Pulley Cover 10. Battery 5. Deck Lift Pedal 1. Ignition Switch 16. Deck Height Indicator 11. Deck Adjusting Rod 6. Hour Meter 2. Throttle Lever 17. Brake Switch 12. Anti-Scalp Wheels 7. Oil Pressure Light 3. Control Levers 18. Choke Lever 13. Discharge Chute 8. Fuel Tanks 4. Blade Engagement Switch 14. Left Belt/Pulley Cover 9. Hydraulic Reservoir Accu Z Controls Figure 2-1 Controls Oil Pressure Throttle For general location
ページ16に含まれる内容の要旨
Land Pride Section 2 Operation Left/Right Fuel Tank Valve Refer to Figure 2-5: These levers control the mower’s speed, direction, neutral Refer to Figure 2-3: lock and park brake. Levers are used to steer, accelerate, The mower is equipped with a Left/Right Fuel Tank Valve brake and change direction. The mower will not move that will determine which fuel tank the mower is operating when the engine is on, drive pumps are operating and the from. It is not important which fuel tank the mower is usi
ページ17に含まれる内容の要旨
Land Pride Section 2 Operation 5. With the deck clutch switch up and/or the control Instrumentation levers in the neutral position, slowly raise off of the Electronic Hour Meter seat. The engine should stop within two seconds. Refer to Figure 2-7: 6. If the engine fails to stop when the deck clutch switch Registers 1/10 hour increments up to 9,999.9 total hours. is up or one or both of the control levers is in and the Connected to the ignition switch, the meter records the operator is off the se
ページ18に含まれる内容の要旨
Land Pride Section 2 Operation IMPORTANT: The engine starter should not be operated for periods longer then 30 seconds at a time. An interval of at least two minutes should be allowed between such cranking periods to protect the starter from overheating and burn-out. 5. Perform test to make sure safety start interlock system is operating properly. Refer to Safety start interlock system section. 6. As soon as engine begins to run, check to make certain the oil warning light is off. If not, stop e
ページ19に含まれる内容の要旨
Land Pride Section 2 Operation Driving the Mower Operating Suggestions ! DANGER! ! DANGER! Prior to operating the mower the operator should be thoroughly Never make sudden stops or reverse direction, especially when familiar with the proper use and operation of the equipment, going down a slope. The steering is designed for sensitive should read the manual completely and thoroughly, and should response. Rapid movement of the control levers in either have attempted slow moving maneuvers to become
ページ20に含まれる内容の要旨
Land Pride Section 2 Operation Use high blade speed. Your Accu Z is designed to Mower Deck Operation operate at full throttle. The throttle setting directly controls blade speed. The highest blade speed generally gives the best cut. ! DANGER! Never attempt to make any adjustments to the mower deck while Direct grass discharge to right, away from unmown the engine is running or with the blade engagement switch area. Select a mowing pattern that directs grass discharge engaged. Mower blades cannot
