ページ1に含まれる内容の要旨
™
BLACK BEAR
™
BLACK BEAR ZTR®
®
ZTR
Safety Instructions
and
Operator’s Manual
®
Models ZTR 34/968999564
®
ZTR 44/968999565
®
ZTR 34/968999566
ページ2に含まれる内容の要旨
IMPORTANT - READ CAREFULLY The Dixon® ZTR® mower is both easy and fun to operate. However, any power mower must be operated properly to be safe. It is not a toy or a recreational vehicle. Before you start to use the mower, read this Operator’s Manual carefully. It contains valuable information that is necessary for the safe operation of the machine. Observe all safety rules and become completely familiar with the controls. The information contained in this manual applies to all Dixon Black Bear™
ページ3に含まれる内容の要旨
TABLE OF CONTENTS SAFETY AND WARNINGS............................................................ 4-15 GENERAL OPERATION ................................................... 6-7 MOWING ON A SLOPE .................................................... 8-9 FIRE HAZARDS ............................................................ 10-11 CHILDREN, BYSTANDERS AND PETS ............................ 12 SERVICE ............................................................................ 13 WARRANTY .........
ページ4に含まれる内容の要旨
SAFETY RIDING LAWN MOWERS, IF IMPROPERLY OPERATED, CAN CAUSE SERIOUS INJURY OR DEATH Pictured below are the most common causes of injury to the operator or bystander. Please read and understand this manual to prevent injuries. Blade Contact Tip Over Run Over Back Over 4
ページ5に含まれる内容の要旨
SAFETY Safety Alert Symbol When you see this symbol, BE ALERT to the potential for injury. Follow the recommended safety precautions and safe operating practices. DANGER (highlighted in red) indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury. WARNING (highlighted in orange) indicates a potentially hazardous situation which, if not avoided, could result in death or serious injury. CAUTION (highlighted in yellow) indicates a potentially h
ページ6に含まれる内容の要旨
WARNING Failure to observe the following instructions WARNING ! could result in serious injury or death. GENERAL OPERATION Read, understand, and follow all instructions in this manual and on the mower before starting. Only allow responsible adults, who are familiar with the instructions, to operate the mower. Clear the area of objects such as rocks, toys, wire, etc., which could be picked up and thrown by the blade. Be sure the area is clear of bystanders before mowing. Stop mower if anyone en
ページ7に含まれる内容の要旨
WARNING Failure to observe the following instructions WARNING ! could result in serious injury or death. GENERAL OPERATION (continued) Turn off blades when not mowing. Injury could occur from contact with moving parts. Under no circumstances should you place hands or feet under the mower deck or in the chute while blades or impeller are still running. To avoid personal injury from accidental clutch engagement, stop engine before removing grass catcher or unclogging chute. Mow only in daylight
ページ8に含まれる内容の要旨
WARNING Failure to observe the following instructions WARNING ! could result in serious injury or death. SLOPE OPERATION Slopes are a major factor related to loss-of-control and tip-over accidents, which can result in severe injury or death. All slopes require extra caution. If you feel unsure on any slope, do not mow it! DO Mow across the slope with your Dixon® ZTR® — never up or down. This will decrease the risk of tip-over. Remove obstacles such as rocks, tree limbs, wires and other foreign
ページ9に含まれる内容の要旨
WARNING Failure to observe the following instructions WARNING ! could result in serious injury or death. SLOPE OPERATION (continued) DO NOT Do not turn on slopes unless necessary, and then, turn slowly and gradually downhill, if possible. Rapid uphill turns may cause tip-over. Do not mow near drop-offs, ditches, or embankments. Unstable ground may cause loss of control. Do not mow on wet grass. Reduced traction could cause sliding. Do not try to stabilize the mower by putting your foot on the
ページ10に含まれる内容の要旨
WARNING Failure to observe the following instructions WARNING ! could result in serious injury or death. FIRE HAZARDS Use extra care when handling gasoline and other fuels. They are flammable and vapors are explosive. Store all fuel in approved containers specifically designed for that purpose. Allow engine to cool before refueling. Never remove fuel cap or add fuel with engine running. Do not smoke while refueling or operating the mower. To reduce fire hazard, keep mower free of grass, leaves
ページ11に含まれる内容の要旨
WARNING Failure to observe the following instructions WARNING ! could result in serious injury or death. FIRE HAZARDS (continued) To prevent fire or explosion, keep sparks and open flames away from battery. Keep electrical connections clean and tight. Inspect them often. Loose connections and corrosion increase fire risk. Before disconnecting the negative ground cable, make sure all switches are off. This decreases the chance of sparking and fire. Use care when backing to avoid pushing the gra
ページ12に含まれる内容の要旨
WARNING Failure to observe the following instructions WARNING ! could result in serious injury or death. CHILDREN, BYSTANDERS AND PETS Tragic accidents can occur if the operator is not alert to the presence of children, bystanders and pets. Children are attracted to lawn mowers and the mowing activity. NEVER assume children, bystanders and pets will stay where they were last seen. Be alert to avoid accidents. Keep bystanders and pets out of the mowing area and keep children under the watchful
ページ13に含まれる内容の要旨
WARNING Failure to observe the following instructions WARNING ! could result in serious injury or death. SERVICE Never run a mower inside a closed area or without proper ventilation. Keep nuts and bolts tight, especially blade attachment bolts, and keep equipment in good condition. Never tamper with safety devices. Check their proper operation regularly. Stop and inspect the equipment if you strike an object. Repair, if necessary, before restarting. Never make adjustments or repairs with the e
ページ14に含まれる内容の要旨
DIXON® ZTR® PRO SERIES COMMERCIAL/RESIDENTIAL WARRANTY POLICY Black Bear™, Kodiak™, Grizzly™ & SilverTip™ Mowers DIXON® WARRANTS ITS ZTR® MOWERS AGAINST DEFECTS IN MATERIAL AND WORKMANSHIP FOR THE PERIODS SET FORTH BELOW. THE SOLE REMEDY UNDER THIS WARRANTY IS REPLACEMENT OR REPAIR OF PARTS INCLUDING LABOR COSTS. THIS WARRANTY IS SUBJECT TO THE FOLLOWING CONDITIONS AND LIMITATIONS: 1. COMMERCIAL WARRANTY (use other than, or in addition to, mowing at owner’s primary place of residence): a. First
ページ15に含まれる内容の要旨
SPECIFICATIONS BLACK BEAR™ 34 Model 968999564 Chassis: 11 gauge rectangular tube Body: Designed for operator comfort by use of high-density closed cell foam padded back and arm rests, TM upholstered with Cordura water-repellent fabric. Seat is adjustable fore and aft. Mower Deck: Made of 7 gauge fabricated welded construction with external reinforcement ribs. Two blades combine for a 34" (86cm) cut width. Cut height approximately 1½" (38mm) to 5½"(140 mm) via 17 position lift handle. Blade Drive
ページ16に含まれる内容の要旨
SPECIFICATIONS BLACK BEAR™ 34 Model 968999566 Chassis: 11 gauge rectangular tube Body: Designed for operator comfort by use of high-density closed cell foam padded back and arm rests, TM upholstered with Cordura water-repellent fabric. Seat is adjustable fore and aft. Mower Deck: Made of 7 gauge fabricated welded construction with external reinforcement ribs. Two blades combine for a 34" (86cm) cut width. Cut height approximately 1½" (38mm) to 5½"(140 mm) via 17 position lift handle. Blade Drive
ページ17に含まれる内容の要旨
SPECIFICATIONS BLACK BEAR™ 44 Model 968999565 11 gauge rectangular tube Chassis: Designed for operator comfort by use of high-density Body: closed cell foam padded back and arm rests, TM upholstered with Cordura water-repellent fabric. Seat is adjustable fore and aft. Mower Deck: Made of 7 gauge fabricated welded construction with external reinforcement ribs. Three blades combine for a 44" (112cm) cut width. Cut height approximately 1½" (38mm) to 5½"(140 mm) via 17 position lift handle. Blade Dr
ページ18に含まれる内容の要旨
SEAT ADJUSTMENT INSTRUCTIONS 1. Grasp seat slide adjuster and move it into adjustment position. 2. Slide seat forward or backward. 3. Release seat slide adjuster. Seat Slide Adjuster —Fig. 1— 18
ページ19に含まれる内容の要旨
CONTROLS CONTROL LEVERS For access to the seat, move control levers to neutral position and swing them outward. o NEUTRAL SLOW FAST 90 SLOW FORWARD FORWARD RIGHT REVERSE TURN —Fig. 2— Left Turn Opposite TO GO FORWARD From neutral position, gently push control levers forward. To increase speed, move levers further forward. TO GO BACKWARDS From neutral position, gently pull control levers toward you. TURNING Turning is controlled by moving one control lever slightly forward or rearward of
ページ20に含まれる内容の要旨
CONTROLS PARK BRAKE The park brake is designed to hold the mower from moving and is not intended for use in stopping the mower while it is in motion. The engine will stop if the park brake is engaged while the control levers are in the drive position. Engage park brake before CAUTION ! starting engine. TO SET PARK BRAKE The hand-operated park brake is located on the operator’s left. —Fig. 3— To engage brake, pull lever up (to the rear). To release brake, move lever forward (down). NOTE: Alwa
