ページ1に含まれる内容の要旨
® ®
KODIAK ZTR
Operator’s manual
KODIAK 52, 21 KAW/968999576,
KODIAK 52, HONDA/968999577,
KODIAK 52, 20 KOH/968999578,
KODIAK 52, 25 KOH/968999579,
KODIAK 60, 25 KOH/968999580,
KODIAK 60, 26 B&S/968999581
Please read the operator’s manual carefully
and make sure you understand the
instructions before using the unit. English
ページ2に含まれる内容の要旨
IMPORTANT - READ CAREFULLY ® ® The Dixon ZTR mower is both easy and fun to operate. However, any power mower must be operated properly to be safe. It is not a toy or a recreational vehicle. Before you start to use the mower, read this Operator’s Manual carefully. It contains valuable information that is necessary for the safe operation of the machine. Observe all safety rules and become completely familiar with the controls. The information contained in this manual ® ® ® applies to all Dixo
ページ3に含まれる内容の要旨
TABLE OF CONTENTS Page SAFETY & WARNING....................................4-15 WARRANTY........................................................16 SPECIFICATIONS.............................................17 SEAT ADJUSTMENT.........................................18 CONTROLS..................................................19-21 OPERATION INSTRUCTIONS....................22-32 CARE & MAINTENANCE............................33-45 TROUBLESHOOTING..................................46-47 STANDARD SER
ページ4に含まれる内容の要旨
SAFETY RIDING LAWN MOWERS, IF IMPROPERLY OPERATED CAN CAUSE SERIOUS INJURY OR DEATH Pictured below are the most common causes of injury to the operator or bystander. Please read and understand this manual to prevent injuries. Blade Contact Tip Over Run Over Back Over 4
ページ5に含まれる内容の要旨
SAFETY Safety Alert Symbol When you see this symbol, BE ALERT to the potential for injury. Follow the recommended safety precautions and safe operating practices. DANGER (highlighted in red) indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury. WARNING (highlighted in orange) indicates a potentially hazardous situation which, if not avoided, could result in death or serious injury. CAUTION (highlighted in yellow) indicates a potentia
ページ6に含まれる内容の要旨
WARNING Failure to observe the following safety instructions could result in serious injury or death. GENERAL OPERATION: Read, understand, and follow all instructions in this manual and on the mower before starting. Only allow responsible adults, who are familiar with the instructions, to operate the mower. Clear the area of objects such as rocks, toys, wire, etc., which could be picked up and thrown by the blade. Be sure the area is clear of other people before mowing. Stop mower if anyone ente
ページ7に含まれる内容の要旨
WARNING Failure to observe the following safety instructions could result in serious injury or death. GENERAL OPERATION (continued): Never leave a running mower unattended. Always turn off blades, set parking brake, stop engine and remove key before dismounting. Turn off blades when not mowing. Injury could occur from contact with moving parts. Under no circumstances should you place hands or feet under the mower deck or in the chute while blades or impeller are still running. To avoid person
ページ8に含まれる内容の要旨
WARNING Failure to observe the following safety instructions could result in serious injury or death. GENERAL OPERATION (continued): Never dismount mower without applying parking brake or stopping engine. Protect your eyes. Always wear safety goggles or safety glasses with side shields when operating mower. Data indicates that operators, age 60 years and above, are involved in a large percentage of riding mower- related injuries. These operators should evaluate their ability to operate the ridin
ページ9に含まれる内容の要旨
WARNING Failure to observe the following safety instructions could result in serious injury or death. SLOPE OPERATION: Slopes are a major factor related to loss-of-control and tip-over accidents, which can result in severe injury or death. All slopes require extra caution. If you feel uneasy on a slope, do not mow it! DO Mow across the slope with your Dixon® ZTR® -- never up or down. This will decrease the risk of tip-over. Remove obstacles such as rocks, tree limbs, wires and other foreign obje
ページ10に含まれる内容の要旨
WARNING Failure to observe the following safety instructions could result in serious injury or death. SLOPE OPERATION (continued): DO (continued): Keep all movement on the slopes slow and gradual. Do not make sudden changes in speed or direction. Use extreme caution when operating the mower with attachments to prevent tip-over or roll-over. If front wheels lift off the ground, pull levers back to stabilize the mower. Discontinue mowing the slope! When operating on slopes over 15 degrees, the u
ページ11に含まれる内容の要旨
WARNING Failure to observe the following safety instructions could result in serious injury or death. SLOPE OPERATION (continued): DO NOT Do not turn on slopes unless necessary, and then, turn slowly and gradually downhill, if possible. Rapid uphill turns may cause tip-over. Do not mow near drop-offs, ditches, or embank- ments. The mower could suddenly turn over if a wheel is over the edge of a cliff or ditch or if an edge caves in. Do not mow on wet grass. Reduced traction could cause sliding.
ページ12に含まれる内容の要旨
WARNING Failure to observe the following safety instructions could result in serious injury or death. FIRE HAZARDS: Use extra care when handling gasoline and other fuels. They are flammable and vapors are explosive. Store all fuel in approved containers specifically designed for that purpose. Allow engine to cool before refueling. Never remove fuel cap or add fuel with engine running. Do not smoke while refueling or operating the mower. To reduce fire hazard, keep mower free of grass, leaves and
ページ13に含まれる内容の要旨
WARNING Failure to observe the following safety instructions could result in serious injury or death. FIRE HAZARDS (continued): To prevent fire or explosion, keep sparks and open flames away from battery. Keep electrical connections clean and tight. Inspect them often. Loose connections and corrosion increase fire risk. Before disconnecting the negative ground cable, make sure all switches are off. This decreases the chance of sparking and fire. Use care when backing to avoid pushing the grass b
ページ14に含まれる内容の要旨
WARNING Failure to observe the following safety instructions could result in serious injury or death. CHILDREN: Tragic accidents can occur if the operator is not alert to the presence of children. Children are attracted to lawn mowers and the mowing activity. NEVER assume children will stay where they were last seen. Be alert to avoid accidents. Keep children out of the mowing area and under the watchful care of another responsible adult. Be alert and turn mower off if a child enters the area.
ページ15に含まれる内容の要旨
WARNING Failure to observe the following safety instructions could result in serious injury or death. SERVICE: Never run a mower inside a closed area or without proper ventilation. Keep nuts and bolts tight, especially blade attachment bolts, and keep equipment in good condition. Never tamper with safety devices. Check their proper operation regularly. Stop and inspect the equipment if you strike an object. Repair, if necessary, before restarting. Never make adjustments or repairs with the engin
ページ16に含まれる内容の要旨
® ® DIXON ZTR PRO SERIES COMMERCIAL/RESIDENTIAL WARRANTY POLICY TM ® ® ® Black Bear , Kodiak , Mountain Kodiak , Kodiak Diesel, Grizzly™ & SilverTip™ Mowers DIXON® WARRANTS ITS ZTR® MOWERS AGAINST DEFECTS IN MATERIAL AND WORKMANSHIP FOR THE PERIODS SET FORTH BELOW. THE SOLE REMEDY UNDER THIS WARRANTY IS REPLACEMENT OR REPAIR OF PARTS INCLUDING LABOR COSTS. THIS WARRANTY IS SUBJECT TO THE FOLLOWING CONDITIONS AND LIMITATIONS: 1. COMMERCIAL WARRANTY (use other than, or in addition to, mowing at ow
ページ17に含まれる内容の要旨
SPECIFICATIONS ® KODIAK CHASSIS: 11 GA - rectangular tube SEAT: Designed for operator comfort by use of high-density closed cell foam padded back and arm rests, upholstered TM with Cordura water-repellent fabric. Seat is adjustable fore and aft. Mounted on operator suspension system. MOWER DECK: Made of 11 GA fabricated welded construction with external reinforcement ribs. Three blades combine for a 52” or 60” cut width. Cut height approximately 1.5” to 5” via 12 position lift handle. BLADE D
ページ18に含まれる内容の要旨
SEAT ADJUSTMENT INSTRUCTIONS 1. Grasp seat slide adjuster and move it into adjustment position. 2. Slide seat forward or backward. 3. Release seat slide adjuster. 18
ページ19に含まれる内容の要旨
CONTROLS CONTROL LEVERS Note: For access to the seat, move control levers to neutral position and swing them outward. TO GO FORWARD From neutral position, gently push control levers for- ward. To increase speed, move levers further forward. TO GO BACKWARDS From neutral position, gently pull control levers toward you. TURNING Turning is controlled by moving one control lever slightly forward or rearward of the other. To turn left, move left lever rearward of the right lever. To turn right,
ページ20に含まれる内容の要旨
CONTROLS PARKING BRAKE: The parking brake is designed to hold the mower from moving and is not intended for use in stopping the mower while it is in motion. The engine will stop if the parking brake is engaged while the control levers are in the drive position. Engage parking brake CAUTION before starting engine. TO SET PARKING BRAKE: The hand operated parking brake is located on the left hand side of the mower. To engage brake, pull lever up (to the rear). To release brake, move lever f
