ページ1に含まれる内容の要旨
DIRT QUAD
OWNER’S MANUAL
Read and understand this entire manual before using!
For assistance contact Razor. DO NOT RETURN TO STORE.
Item Number:
25117460
ページ2に含まれる内容の要旨
tnetnoc S Safety Warnings .................................................................................1 Parts List ..............................................................................................9 Before You Begin .................................................................................2 Safety Reminders ..............................................................................11 Assembly and Set-Up .................................................................
ページ3に含まれる内容の要旨
BEFORE YOU BEGIN Remove contents from box. Remove the foam separators that protect the components from damage during shipping. Inspect the contents of the box for scratches in the paint, dents or kinked cables that may have WARNING: occurred during shipping. Because the Dirt Quad was 95 percent assembled and packed at the factory, DO NOT USE NON-RAZOR there should not be any problems, even if the box has a few scars or dents. PRODUCTS WITH YOUR RAZOR DIRT QUAD. The Dirt Quad has bee
ページ4に含まれる内容の要旨
ASSEMBLY AND SET-UP Charging the Battery WARNING: Your electric four wheeler may not have a fully charged battery; therefore it is a good idea to charge the Always disconnect your electric battery prior to use. four wheeler from the charger • Initial charge time: 12 hours • Recharge time: Always remember to turn the before cleaning with liquid. • Run time: up to 40 minutes power switch off and recharge for at least 8 hours • Average battery life: 250 charge/discharge cycles aft
ページ5に含まれる内容の要旨
����� ����� �� �� ASSEMBLY AND SET-UP Inflating the Tires Note: The pressurized air Tires are inflated when shipped, but they invariably lose some pressure between the point of supplies found at gasoline manufacturing and your purchase. Always inflate the tires to the correct PSI before first time use. stations are designed to inflate high-volume automobile tires. If you decide to use such an air supply to inflate your tires, first make sure the pressure gauge is working, then use very short
ページ6に含まれる内容の要旨
REPAIR AND MAINTENANCE q Replacing the Fuse WARNING: To prevent shock or short circuit, please follow the instructions accordingly and do not skip or combine any steps. 1 Make sure the power switch 2 Under the front fender and 3 Open the fuse cover to is turned off. through the frame, locate the expose the fuse. fuse cover attached to the top of the battery casing. Amperage number 4 Remove the fuse and replace 5 Close the fuse cover. with a new one of equal amperage. Note: Amp
ページ7に含まれる内容の要旨
REPAIR AND MAINTENANCE 7 Reset chain tensioner. 8 Position bottom half of the 9 Position top half of the chain chain guard to align mounting guard to align mounting holes holes and screw to frame. and screw to frame. 10 On the inside of the wheel 11 On the outside of the slide bolt through wheel and wheel replace washers and axle and secure with nut. secure with bolt. q Chain and Sprocket WARNING: The chain will typically have a “loose spot” and “tight spot” corresponding with
ページ8に含まれる内容の要旨
TROUBLESHOOTING GUIDE Problem Possible Cause Solution Vehicle does not run. Vehicle is rolling backwards. Throttle will not engage if the vehicle is rolling backwards. Come to a complete stop and then activate the throttle. Undercharged battery. Charge the battery. A new battery should have been charged for at least 12 hours before using the vehicle for the first time and up to 8 hours after each subsequent use. Check all connectors. Make sure the charger connector is tightly plugged into t
ページ9に含まれる内容の要旨
TROUBLESHOOTING GUIDE Problem Possible Cause Solution Sometimes the vehicle Loose wires or connectors. Check all wires around the motors and all connectors to make sure doesn’t run, but other they are tight. times it does. Motor or electrical switch damage. Contact your local Razor authorized service center for diagnosis and repair. Charger gets warm Normal response to charger use. No action required. This is normal for some chargers and is no cause during use. for concern. If your ch
ページ10に含まれる内容の要旨
DIRT QUAD PARTs Keep your Dirt Quad running for years with genuine Razor parts. Visit our web site or e-mail us for more information on spare part availability. (Specifications subject to change without notice.) 01 Handlebar grip (right/left) 17 Brake caliper assembly 02 Speed controller w/ LEDs 18 Brake Disc 02-1 Sleeve 19 Chain 03 Handlebar 20 Sprocket 04 Brake lever assemble complete 21 Chain guard (upper) 05 Handlebar clamp complete 22 Chain guard (lower) 06 Frame 23 Plastic body assembly
ページ11に含まれる内容の要旨
SB 1918 (CALIFORNIA) DECLARATION YOUR INSURANCE POLICIES MAY NOT PROVIDE COVERAGE FOR ACCIDENTS INVOLVING THE USE OF THIS SCOOTER/ELECTRIC VEHICLE. TO DETERMINE IF COVERAGE IS PROVIDED, YOU SHOULD CONTACT YOUR INSURANCE COMPANY OR AGENT. 10
ページ12に含まれる内容の要旨
Safety Reminde RS PRE-RIDE CHECKLIST Loose Parts Tire Inflation Check and secure all fasteners before every ride. Make Periodically inspect the tires for excess wear, and regularly q q sure steering stem clamp bolts are locked properly in place. check the tire pressure and re-inflate as necessary. If you There should not be any unusual rattles or sounds from get a flat tire, the inner tube can be patched or a new tube loose parts or broken components. If you are not sure, ask can be purchas
