ページ1に含まれる内容の要旨
TM
Master Mariner
Stainless Steel 2-Burner Propane Grill
Use, Care & Assembly Manual
With Lighting Instructions
Model 9972 Series
ASSEMBLER/INSTALLER:
Leave these instructions with the consumer.
CONSUMER/USER:
Read all instructions and keep in a safe place for future reference.
IMPORTANT
CONSUMER/USER: This instruction manual
INSTASTART™ For Outdoor Use Only
contains important information necessary for the
Electronic Ignition
proper assembly and safe use of the appliance.
Read and follow all war
ページ2に含まれる内容の要旨
Contents DANGER DANGER indicates an imminently hazardous situation which, if not Technical Characteristics . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 avoided, will result in death or serious injury. General Safety Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 Portable L.P. Gas Barbecue Cylinders. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 Maintenance . . . . . . . . . . . . . . . . . .
ページ3に含まれる内容の要旨
Only persons who can understand and follow the instructions should DANGER use or service this outdoor grill. If you need assistance or outdoor grill information such as an instruction manual or labels, contact The Coleman Company, Inc. � EXPLOSION - FIRE HAZARD � Never store propane near high heat, open flames, pilot lights, direct sunlight, other ignition sources or where temperatures exceed 120 degrees F (49°C). DANGER � Propane gas is heavier than air and leaking propane will sink to the lowe
ページ4に含まれる内容の要旨
DANGER WARNING � CARBON MONOXIDE HAZARD � BURN HAZARD � This grill is a combustion appliance. All combustion appliances � Never leave grill unattended when hot or in use. produce carbon monoxide (CO) during the combustion process. � Keep out of reach of children. This product is designed to produce extremely minute, non-hazardous amounts of CO if used and maintained in accordance with all warnings and instructions. Do not block air flow into or out of the grill. CAUTION � Carbon Monoxide (CO) p
ページ5に含まれる内容の要旨
Maintenance � Interior components - Remove heavy residue from grill and WARNING empty grease tray between each use. We recommend cleaning all accessible surfaces, and all removable components, at least � Do not overheat grill. Stainless steel loses anti-corrosive characteristics once a year, depending on amount of use, and always prior to when subjected to extreme heat. long term storage. � Grill grates - Clean with brass wire brush while grill is warm. � About stainless steel - Stainless ste
ページ6に含まれる内容の要旨
Grill Assembly Fig. 1 IMPORTANT: Remove all protective plastic film from stainless steel parts and any packing materials from grill prior to assembly/use. This film or packing materials are installed at the factory to prevent damage that could occur during shipment and handling. With lid latched, lift up on handle and set grill so it is resting on 1. the back of the case. (Fig. 1) Note: Use a drop cloth to help protect the stainless steel finish. Align bolts on leg with holes on bottom of grill
ページ7に含まれる内容の要旨
Grill Assembly continued Install grease tray onto tracks at bottom front of grill. (Fig. 6) 6. Fig. 6 Insert tab on heat tent into slot on bracket at back of grill. 7. (Fig. 7) Push down on tab at front of heat tent to lock into slot on grill 8. bracket. (Fig. 8) Install the remaining heat tent as shown. (Fig. 9) 9. Slip right side grill grate under tab at back of grill. (Fig. 10) 10. Fig. 7 Fig. 8 Fig. 9 Fig. 10 7
ページ8に含まれる内容の要旨
Grill Assembly continued Push down on grate to lock into tabs on right side of grill. 11. Fig. 11 (Fig. 11) Insert remaining grill grate under tab at back of grill, then push 12. down on grate to lock into tabs on left side of grill. (Fig. 12) Place warming rack on tabs at left side of grill and push down to 13. lock. (Fig. 13) Press down on other side to lock warming rack into tabs on right 14. side of grill. (Fig. 14) Turn both control knobs on front of grill to OFF position. (Fig. 15) 15. Fig
ページ9に含まれる内容の要旨
Grill Assembly continued Remove plastic cap from top of propane cylinder and turn 16. Fig. 16 propane cylinder clockwise into regulator hand tight. (Fig. 16) Insert the regulator pipe firmly. The regulator uses a push-on 17. fitting to attach to the grill. It is necessary to hold the grill to make sure the fitting is seated, Align the regulator to the fuel tube on the side of the grill and push on until you hear the retainer “click” into place (Fig. 17). Gently pull on the regulator to ensure th
ページ10に含まれる内容の要旨
Operation DANGER CAUTION � DO NOT OVERHEAT GRILL � Stainless steel loses anti-corrosive characteristics when subjected to extreme heat causing damage and discoloration. � CARBON MONOXIDE HAZARD � For outdoor use only. � Never use inside house, camper, tent, vehicle or other unven- CAUTION tilated or enclosed areas. This grill consumes air � Never leave grill unattended when hot or in use. (oxygen). Do not use in unventilated or enclosed areas to avoid endangering your life. � Keep out of reach o
ページ11に含まれる内容の要旨
To Adjust Igniter NOTE: A gap of 1/8” should be maintained between the end Fig. 21 of the wire on the electrode and the burner tube for proper 1/8” Gap ignition spark. (Fig. 21) Set on sturdy, flat surface. 1. Grasp end of wire with a needle nose pliers and carefully bend 2. to adjust to proper spacing from burner tube (Fig. 21). Be careful to not break or crack the ceramic insulator. To Light To Match Light Fig. 22 CAUTION Use a long wooden match or a match extension Set on sturdy, flat surfac
ページ12に含まれる内容の要旨
To Clean Make sure grill is cool. Fig. 26 1. Always detach the propane cylinder outdoors, away from flame 2. (including pilot lights) and other ignition sources. The fitting on the regulator has a sliding collar that secures the 3. regulator to the grill fuel line. Slide the collar away from the stove and then pull the regulator off the grill fuel line. (Fig. 26) Detach the propane cylinder from the regulator and replace the 4. plastic protective cap onto the cylinder threads.(Fig. 27) Clean the
ページ13に含まれる内容の要旨
To Store Fig. 29 DANGER � EXPLOSION - FIRE HAZARD � Never store propane near high heat, open flames, pilot lights, direct sunlight, other ignition sources or where temperatures exceed 120 degrees F (49°C). � The cylinder must be disconnected when the grill is in storage. � Do not store a spare LP-gas cylinder under or near this appliance. Failure to follow the above instructions exactly may result in fire causing death or serious injury. Fig. 30 For storage or transport, the regulator may be pla
ページ14に含まれる内容の要旨
Trouble Shooting Guide Problem Possible Cause Possible Solution Burner will not light Igniter electrode covered with Clean igniter electrode with igniter grease or residue Igniter/electrode too far from Adjust electrode until proper burner spark appears (see page 11) Igniter/electrode wire loose Call Coleman for service or disconnected Wire is shorted causing spark Call Coleman for service from wire before electrode No spark being generated Call Coleman for service Burner will not light No gas f
ページ15に含まれる内容の要旨
Replacement Parts List — 9972 Series No. Description Part Number 1 Warming Grate 5010000084 2 Grill Grate 5010000083 3 Heat Tent (1 pk.) 5010000085 1 4 Thermometer Assembly 5010000091 5 Regulator 5010000081 6 Leg Kit (1 pk.) 5010000088 2 7 Grease Tray 5010000086 8 Crumb Tray 5010000087 9 Igniter/Piezo/Wire Assembly (2 pk.) 5010000080 3 9 4 8 7 5 6 Accessory items (sold separately) — 9972 Series No. Description Part Number 2 3 1 Dual Rail Mounting Kit R9972-524 1 2 Adjustable Rod Holder Mounting
ページ16に含まれる内容の要旨
Warranty Limited One Year Warranty The Coleman Company, Inc. (“Coleman”) warrants that for a period of one year from the date of original retail purchase, this product will be free from defects in material and workmanship. Coleman, at its option, will repair or replace this product or any component of the product found to be defective during the warranty period. Replacement will be made with a new or remanufactured product or component. If the product is no longer available, replacement may be
