Résumé du contenu de la page N° 1
4/01 ErNs 511502
Gas Fired Cookers
for
lnstructions
lnstallation
Fired Range
Vent
Aga Gas Power
L.P'G.
N.G. and
(2 Oven)
P.V.
Models: G.C.
\@'9,-4
(4
Oven)
G.E. P.V.
(.e]
Markets
Candian
For U.S. and
AND THE USER
APPLIANCE
LEFT VMTH THE
SHOULD BE
INSTRUCTIONS
THESE INSTALLATION
NOTE:
REFERENCE.
FOR FUTURE
TO RETAIN
fof
the site is inspected
installation can be made,
Before
arc delivered unassembled
The Gas fired ranges
codes
wiih local installation
to conform
and corre
Résumé du contenu de la page N° 2
TILING WALL tiles should the wallwhich is to be tiled, in no circLlmstances in a fecess or against a lfthe cooker is to stand plate. the range top overlap - THREADS U.S. PIPE GAS SUPPLY PIPE lN THE GAS ACCESSIBLE LOCATION VALVE lllUST BE INSTALLED lN AN A [4ANUAL NOTE: rHE oF GAS To TURNING oN oR SHUTTING THE PURPoSE oF Eiienrni io rne nppLrANcE FoR APPLIANCE. BE U.S. PIPE THREADS. CONTROLS MUST ALL GAS (15,000 Btu/h) Heat lnput 4.4kW Maximum 14 inches w-g w.g. for Natural
Résumé du contenu de la page N° 3
VENT SYSTEM powered vent pipe 50mm (2in) diameter which can reach up to 6 Products of combustion discharge is by a fan (29ft) with one bend Exits from the metres (19.5fr) in length through a of 6 x 90' bends or I metres Faximum (Figs. 2 & 3). rear centre or from the under side appliance can be from rear L.H. or-R.H. sides, from the ( pipe wall fixing plate by 25mm 1in) Fig. 1 The vent should exit through the outsrde
Résumé du contenu de la page N° 4
DESN 511189 1 FIG, DESN 511 126
Résumé du contenu de la page N° 5
rtt el ffic{lrhl ||!$ru ] EL S|l'E ffi.TD i f,ffi tHtt^tsl gx al'lr: ml !t \rrfir ntr{N o xtE off ||n/rdr*l I L,'1: lSilr$d€l,M !3r I nE|,|n& t' Carejts|* t &€l rU rids & *xs{ra$hn ldar vArft !*hr&fig donlr6b. Wdng r.rq$ {3i qrd ]rrpr.fllr d!ng4|qf rawF cp!|q!rj \is|ly {rr'ldrrt als $dr6s. frsrnl
Résumé du contenu de la page N° 6
l-*\o. E I i n
Résumé du contenu de la page N° 7
TERMINAL POSITION '1. external air and terminal so that the vent terminal is exposed to the The range must be installed clearance comDlv with: Section 7.7 National Fuel Gas Codes ANSI2223 1 latest edition In l.r.s.: The installation code. In Canada: CAN/CGA-8149 preferably than the terminal being not less 2. Termination should be on a clear expanse ofwall, (14in) projection- 355mm away from a corner, recess of '1.5" inside to outside face of wallwith the hole falling from 3. A hole mu
Résumé du contenu de la page N° 8
GC PV ovElrtsl 12 f*l]--';o,*o*o, qarsEo lrDs WHEN i! I I -T 4Se#"- 'r ,i 1r' I ti rrtlr4tN,| I tF=: lh= I I t-- | | H l' -Tl I | | - lrilL l" Hil I I f lt r-,---J Bl I l tLI&::L=FJ I t4-:il + I 'Yr' .,-N )n-,1* | | tl I lF I Tl *1r1e-----* v#i?#..'-"- ---J I L-_ IINT PIPE ")., Llt. stDE vEw Fno$r v|gw w V r11i,/ j/ ,/ ,/ / / , ,, / ./,/ / / / ,/ ,1"// ,/ ,/ _* ^'cg::='t-Uil --1v x{ | 4,,HVll ,IE- P,] I l" /\ //'="'\'l ?. I .ir t I | | I \// \t I// , 6l j|l' l{, )lW I ur
Résumé du contenu de la page N° 9
(1 cE PV OVENS| t|,rocK ouT HO|.:S fOB VENT PIPE Llr. 8&€ \4rv GAS CONrrlEmONA.H. nn "V\"/. i.r{. 6DE V|EW n s J K L M N P o R c F 11668 3S 3 698 65 375 48 595 mm1487 96? 851 41 1314 PLATE LOCATION OF NAME plate. be used the name These numbers rn!st serial numbers for this appliance are found on The model and burner youf plate is located on the inside of the outef from Aga Distributor. The name when requesting advice door.
Résumé du contenu de la page N° 10
REMOVE COVER TO LOCATE C COMMISSIONING - (Erg LIGHTING THE BURNER 4) NAKED LIGHTS CAUTION: NO SMOKING OR gas control combination valve. the burner outer door to expose the Open IN THE OFF POSITION. THE GAS VALVE KNOB 2 lS SET BEFORE LIGHTING ENSURE THAT CAUTION: (SEE IS SWITCHED ON. THE ELECTRICAL SUPPLY TO THE AGA AND EIG.A) '1. puqe fof soundness and gas gas installation from the meter cock Turn off union cock 1. Test the gas to the gas the valve control knob 2 anti-clockwise
Résumé du contenu de la page N° 11
OFF i\ ,ru. rGNrroN { FIG B WHTTE BLOCK LOW FIRE FIG C BAND GREEN n-- NORMAL RUNNING gas position gas pressure. Turn the control knob 2 to PILOT 6. After 30 minutes, check the burner {see Fjg'B) {i) pressure gauge. gas knob to the pressure plug fit Turn valve control 2 Remove the main burnef test nipple 5 and position grcen ofthe band. mid plate. pressure to the data (ri/ Check bumer corectly co'responds gas gas pressure other appliances are used (iii) that the is unaffected to the m
Résumé du contenu de la page N° 12
green plug. position ofthe band for normal running Tum temperature control knob 2 to the mid moisturc from the insulation may run down if cooker has been cold for a long time, 7. On the first lighting or the prevent be wiped ofito staining. the enamelled front ofthe cooker. This should at automatically to maintain the cooker confirmed the heat control will operate Once the corect setting has been fulltempe€turc. LINE lN BE ON OR ABOUT THE BLACK HOURS THE HEAT INDICATOR SHOULD NOTE: AF
Résumé du contenu de la page N° 13
./'-.--"\.t.' -r' \ DESN 510818 PILOT ASSEMBLY TIIERMOCOUPLE
Résumé du contenu de la page N° 14
YEARLY SERVICE It is recommended that the range be serviced every 12 months. to ensure it is cold upon aadval. the range l"ras been turned OFF the night before Arrange with the housholder that 1. Disconnect Electric Supply before servicing. WARNING: gas gas valve. Break the gas the seNice valve beneath the combination 2. lsolate the supply by turning off heaxgon union connection nut. gas ofthe combustion draw complete burner assembly clear 3. Detach the inner burner doorfixing screw and
Résumé du contenu de la page N° 15
ln the eventof a component failure which requires rcplacement, contact your local Aga distributor who will advise and supply the necessary replacement. Expendable components that will require replacing at some time or other are listed as fo ows: Description '. Pilor Thermocouple 2. lvlain Burner 3a. Pilot BurnerAssembly N_G. 3b. Pilot Burner Assembly L.P.G. 4. Combustion Gas Valve 5a. Pressure Regulator N.G. 5b. Pressure Regulator L.P.c. 6. Combustion Chamber Door Seal 7. Sole
