Résumé du contenu de la page N° 1
Owner's Manual
Liquid Propane,
Gas-Fired Infrared
Outdoor Patio Heater
Model 22899
//_ WARNING:
Note to Installer:
Read this Owner's Manual carefully and be sure your
Leave this Owner's Manual with the consumer after
patio heater is properly assembled, installed and
delivery and/or installation.
maintained. Failure to follow these instructions could
Note to Consumer:
result in serious bodily injury and/or property damage.
Leave this Owner's Manual in a convenient place for
This patio heater is i
Résumé du contenu de la page N° 2
Warranty ..................................................... 2 Z_WARNING Safety Instructions ..................................... 2 Failure to comply with these instructions could result in a fire or explosion that Clearance Requirements ........................... 3 could cause serious bodily injury, death, or property damage. Parts Diagram and Part List ............ 6-7 Assemblylnstructions ..................................... 8 Lightinglnstructions .................................. 11 FO
Résumé du contenu de la page N° 3
Priorto assembling yourpatioheater,thefollowing WARNING mustbereviewed. Compliance withthefollowing shouldresultin satisfactory heateroperation. This Certain materials or items, when stored Owner'sManualshouldberetained for future under the heater, will be subjected to reference. Theinstallation mustconform withlocal radiant heat and could be seriously codesof yourarea. damaged. 1. Thisgasfiredinfraredpatioheateris intended for outdoorheating.Theinstallation mustconform . Additional clearance ma
Résumé du contenu de la page N° 4
12. This patio heater is for outdoor use only. If The patioheaterheadand its components must be keptclear of dirt and cobwebs. stored indoors, you MUST remove and store Flowof combustion andventilationair the LP gas cylinder outdoors. The LP gas throughtheperforated portions of the cylinder must be disconnected when patio heatermustnotbe obstructed. heater is not in use. • Keep the bottom ventilation opening of the 13. CAUTION: You must use only the gas cylinder enclosure (Patio Heater Base) fre
Résumé du contenu de la page N° 5
The following table illustrates a breakdown of the hardware pack. It highlights what components are used in the various stages of assembly. Ref. Component Qty. to Use Purpose of Components Install Reflector to Emitter Grid PHO09 1/4" Spring Washer 3 PH018 Install Reflector to Emitter Grid 1/4" Cap Nut 3 PH019 M4 x 10 mm Round Head Screw 4 Install Emitter Grid to Burner Assembly Quantity and Actual Size of Each Hardware Piece: 1/4" Spring Washer 1/4" Cap Nut Qty. 3 Qty. 3 Part # PH009 Part # PH01
Résumé du contenu de la page N° 6
Remove allcomponents fromtheshipping boxandplace withineasyreach.Inspect patioheaterpartsfordamage as youproceed.Donotassembleor operateyourpatioheaterif partsappeardamaged. REARVIEWOF PATIO HEATER BASE SHOWN ALREADYATTACHED TOBASE
Résumé du contenu de la page N° 7
REF# DESCRIPTION PART# QTY If there are damaged or missing parts when you unpack this unit from the shipping box, or you have 1. Aluminum Reflector P7091A 1 questions about assembly, call the Customer Ser- vice Helpline 8am - 8pm CST, Monday through 2. Emitter Grid P7092A 1 Friday at 1-888-317-7642. P7093A 2 3. Safety Guard For the repair or replacement parts you need: P7094A 1 4. Burner Assembly Call 8am - 8pm CST, Monday through Friday at 1-888-317-7642 5. Control Knob P3417C 1 6. Base P7095A
Résumé du contenu de la page N° 8
Figure 1 Beforeassembling the patioheater,usethe parts REFLECTOR list to checkthat all necessaryparts have been included.Inspectpatio heaterfor damageas you proceed. Donotassemble oroperate thepatioheater if it appears damaged. If youhavequestions during the assembly process, call 1-888-317-7642, 8am- 8pmCST,MondaythroughFriday. CAUTION: EMITTER Removeall partsand hardware from shippingbox. GRiD Referto thepartslistandhardware packillustrations andassemble thepatioheaterona protectivework surfac
Résumé du contenu de la page N° 9
Insert the bottom wire of each Safety Guard 4. Figure 4 (Parts List Item #3) through the hole on the REFLECTOR burner post. Connect the Safety Guards together. See Fig. 4. WARN ING GRID Any Safety Guard or other protective device removed for servicing the patio SAFETY heater must be replaced prior to operat- GUARD ing the patio heater. 5. Attach the Cylinder Access Door (Parts List Item #7) to the patio heater base. See Fig. 5. BURNER ASSEMBLY BASE_ Figure 5 REFLECTOR \ SAFETh EMITTER GUARD GRID
Résumé du contenu de la page N° 10
Connecting a Liquid Propane Gas Cylinder to Figure 6 your Patio Heater. (Must use LP gas only) CAUTION: During and after each use, your patio heater will be hot. NEVER touch your patio heater or attempt to change the LP Gas Cylinder until you are certain it is cool to the touch. CYLINDER 1. Turn gas Control Knob, located on front of ACCESS DOOR Patio Heater to the off position. 2. Remove the Cylinder Access Door. See Fig. 6. Position the Cylinder (not included) under the regulator. Support the C
Résumé du contenu de la page N° 11
. Push and HOLD the Control Knob in fully. Rotate knob left and STOP about 1/4 inch before the IGN/ HIGH position. Hold Control Knob at this position Checkall gasconnections witha soapywater for 3 to 4 seconds allowing gas to travel up to the burner. Then SLOWLY turn Control Knob left to solutionto be suretheyare tightand leak proof. To makesoapsolution,mix onepartwaterwith the" IGN / HIGH " position, until a click sound is onepartliquiddetergent. heard. You may have to repeat this step 3 or 4 t
Résumé du contenu de la page N° 12
Question: Why won't the burner stay lit? Answer: • May be excessive winds. Position your patio Question:WhodoIcallwithquestions aboutmy heater in a more protected area away from Grand HallPatioHeater assembly orif partsare wind of 10 mph or more, with proper damaged ormissing frommyshipping box? clearances. Answer:CalltheCustomer Service Helpline • Low gas pressure. Be sure LPG Cylinder is filled. 8am- 8pmCST,Monday through Friday, at • The gas line may need to be purged. 1-888-317-7642. Questio
Résumé du contenu de la page N° 13
J_WARNING: Improper installation, adjustment, alteration, service ormaintenance can resultinafireor explosion that could cause serious bodily injury, death, or property damage. Read the installation, operating and maintenance instructions thoroughly before installing or servicing this equipment. If there are damaged or missing parts, including your Owners Manual, when you unpack this unit from the shipping box, or if you have questions about assembly or operation, call the Customer Service Helpl
