Résumé du contenu de la page N° 1
™
Advolution 2710
UHR 70-1700
INSTRUCTIONS FOR USE
INSTRUCCIONES DE USO
ADVANCE MODELS 56422000, 56422002
NILFISK MODEL 56422001
A-English
B-Español
3/06 Form No. 56041634
Résumé du contenu de la page N° 2
WEEE SYMBOL INFORMATION Correct Disposal of This Product (Waste Electrical & Electronic Equipment) English (Applicable in the European Union and other European countries with separate collection systems) This marking shown on the product or its literature, indicates that it should not be disposed with other household wastes at the end of its working life. To prevent possible harm to the environ- ment or human health from uncontrolled waste disposal, please separate this from other types of wast
Résumé du contenu de la page N° 3
ENGLISH / A-3 TABLE OF CONTENTS Page Introduction ........................................................................................... A-3 Parts and Service ................................................................................. A-3 Nameplate ............................................................................................ A-3 Uncrating the Machine .......................................................................... A-3 Important Safety Instructions ...........
Résumé du contenu de la page N° 4
A-4 / ENGLISH IMPORTANT SAFETY INSTRUCTIONS This machine is only suitable for commercial use, for example in hotels, schools, hospitals, factories, shops and offi ces other than normal residential housekeeping purposes. Read all instructions before using. WARNING! To reduce risk of fi re, electric shock, or injury: • Use only as described in this manual. Use only manufacturer’s recommended attachments. • This machine shall be used only by properly trained and authorized persons. • This machine
Résumé du contenu de la page N° 5
ENGLISH / A-5 IMPORTANTES CONSIGNES DE SECURITE Cette machine ne convient qu´à un usage industriel, par exemple dans les hôtels, les écoles, les hôpitaux, les usines, les boutiques et les bureaux et autres utilisations que le ménage domestique résidentiel. Lisez toutes les instructions avant l´utilisation. ATTENTION! Pour réduire le risque d´incendie, d´électrocution, ou de blessure: • Ne l´utilisez que comme décrit dans ce manuel. N´utilisez que des attachements recommandés par le fabricant
Résumé du contenu de la page N° 6
A-6 / ENGLISH KNOW YOUR MACHINE As you read this manual, you will occasionally run across a bold number or letter in parentheses - example: (2). These numbers refer to an item shown on these pages unless otherwise noted. Refer back to these pages whenever necessary to pinpoint the location of an item mentioned in the text. NOTE: Refer to the service manual for detailed explanations of each item illustrated on the next 2 pages. 1 Pad Drive Deck 2 Dust Control Shroud 3 Burnishing Pad 4 Pad R
Résumé du contenu de la page N° 7
ENGLISH / A-7 KNOW YOUR MACHINE A Master Key Switch B Battery Condition Indicator C Hour Meter / Error Display D Pad Drive Indicator Light E Pad Drive Raise / Lower Switch F Horn Indicator Light G Horn Switch FORM NO. 56041634 - Advolution™ 2710 / UHR 70-1700 - A-7
Résumé du contenu de la page N° 8
A-8 / ENGLISH BATTERIES If your machine shipped with batteries installed do the following: • Check that the batteries are connected to the machine (7). • Turn ON the Key Switch (A) and check the Battery Indicator (B). If the green light is ON, the batteries are ready for use. If the green light is OFF, the batteries should be charged before use. See the “Charging The Batteries” section. If your machine shipped without batteries installed do the following: • Consult your Authorized Nilfi sk-Ad
Résumé du contenu de la page N° 9
ENGLISH / A-9 INSTALLATION OF THE BURNISHING PAD WARNING! Disconnect the machines Battery Pack Connection (7) by pulling up on the Emergency Power Disconnect (10) handle, when ever servicing the machine. CAUTION! Turn the key switch off (O) and remove the key, before changing the brushes, and before opening any access panels. 1 See Figure 2. Grab hold of the right side of the Pad Drive Deck (1) and lift up until it Latches (16) in place as shown. 2 Place your hand underneath the Dust Control
Résumé du contenu de la page N° 10
A-10 / ENGLISH INSTALLATION OF THE DUST COLLECTION BAG The Advolution™ 2710 / UHR 70-1700 uses dust collection bag PN 56391185 (sold 6 to a Package). See Figure 3. Unfold the Dust Collection Bag (5) and while holding onto the Card Board Retainer (AA) insert it over the Collection Tube (BB) found on the top of the Pad Drive Deck (1) on the left side of the machine. NOTE: Never operate the Advolution™ 2710 / UHR 70-1700 with out a Dust Collection Bag (5) or the optional Active Dust Control Kit (
Résumé du contenu de la page N° 11
ENGLISH / A-11 BEFORE EACH USE: 1 Be sure you understand the operator controls and their function. 2 Turn the Master Key Switch (A) ON (l) and check the Battery Condition Indicator (B). If the red light comes on, recharge the battery pack before using the machine 3 Check that a new or clean pad has been installed. 4 Check that a Dust Collection Bag (5) is installed. PLAN YOUR FLOOR BURNISHING: 1 Pre-sweep or scrub fl oor area of debris to prevent scratching and poor burnishing performance. 2 Ar
Résumé du contenu de la page N° 12
A-12 / ENGLISH AFTER USE 1 Raise the Pad Drive Deck (1), then drive the machine to a service area. 2 Turn the Master Key Switch (A) OFF (O) and remove the key. 3 Remove the burnishing pad, rinse the pad with warm water and hang it up to dry. NOTE: Allow pad to dry completely before using again. 4 Check the Dust Collection Bag (5) if over half full or damaged remove and replace with a new bag. 5 Check the maintenance schedule and perform any required maintenance. 6 Wipe the machine with a damp c
Résumé du contenu de la page N° 13
ENGLISH / A-13 CHARGING THE BATTERIES Charge the batteries each time the machine is used for 1 hour or longer, or whenever the Battery Condition Indicator Lights (B) light up red. To Charge the Batteries... 1 IMPORTANT!: Open the Battery Compartment Cover (13) to provide proper ventilation. 2 Disconnect the Battery Connector Assembly (7) and plug the battery charger into the plug connected to the batteries. 4 Follow the instructions on the battery charger. 5 Check the fl uid level in all battery
Résumé du contenu de la page N° 14
A-14 / ENGLISH GENERAL MACHINE TROUBLESHOOTING OPERATOR DISPLAY PANEL STATUS LIGHTS: Hour Meter / Error Display (C): If an error code is displayed on the Hour Meter / Error Display (C) a system error has occurred, the error display will read “Err” followed by a two digit code(s). Reference the Service Manual for fault code descriptions and corrective action. SWIRL MARKS • Floor not clean. • Area not properly swept - debris in pad or brush. • Improper pad for the job. • Moving the machine too
Résumé du contenu de la page N° 15
ENGLISH / A-15 TECHNICAL SPECIFICATIONS (as installed and tested on the unit) Model Advolution™ 2710 UHR 70-1700 Model No. 56422000 / 56422002 56422001 Voltage, Batteries V 36V 36V Battery Capacity Ah 395 395 Protection Grade IPX3 IPX3 Sound Pressure Level (IEC 60704-1) dB(A)/20 μPa 69 69 Gross Weight lbs. / kg 1,379 / 625 1,379 / 625 2 2 2 Vibrations at the Hand Controls (ISO 5349-1) m/s 1.27 m/s 1.27 m/s 2 2 2 Vibrations at the Seat (EN 1032) m/s 0.19 m/s 0.19 m/s Gradeability 0 0 Transport
Résumé du contenu de la page N° 16
B-2 / ESPAÑOL ÍNDICE Página Introducción .......................................................................................... B-2 Componentes y servicio ....................................................................... B-2 Placa de identifi cación .......................................................................... B-2 Desembalaje de la máquina ................................................................. B-2 Instrucciones importantes de seguridad ..........................
Résumé du contenu de la page N° 17
ESPAÑOL / B-3 INSTRUCCIONES IMPORTANTES DE SEGURIDAD Esta máquina es apta únicamente para su uso comercial, por ejemplo, en hoteles, colegios, hospitales, fábricas, tiendas y ofi cinas, y no para la limpieza diaria del hogar. Lea todas y cada una de las instrucciones antes de utilizar el aparato. ¡ADVERTENCIA! Con el fi n de reducir el peligro de incendio, descarga eléctrica o lesión: • Utilícelo sólo de la manera descrita en este manual. Utilice sólo los accesorios recomendados por el fabrica
Résumé du contenu de la page N° 18
B-4 / ESPAÑOL CONOZCA SU MÁQUINA A lo largo de este manual encontrará números o letras en negrita entre paréntesis – por ejemplo: (2). Estos números se refi eren a un objeto que se muestra en dicha página, a menos que se indique lo contrario. Consulte estas páginas siempre que lo necesite para localizar los elementos citados en el texto. NOTA: Consulte el manual de servicio para obtener explicaciones más detalladas de cada objeto ilustrado en las siguientes 2 páginas. 1 Platina del motor de
Résumé du contenu de la page N° 19
ESPAÑOL / B-5 CONOZCA SU MÁQUINA A Conmutador de llave principal B Indicador de situación de las baterías C Pantalla de cronómetro / error D Luz indicadora de motor del disco E Interruptor de elevación / descenso del motor del disco F Luz indicadora de claxon G Interruptor de claxon FORM NO. 56041634 - Advolution™ 2710 / UHR 70-1700 - B-5
Résumé du contenu de la page N° 20
B-6 / ESPAÑOL BATERÍAS Si su máquina se entrega con baterías instaladas, realice lo siguiente: • Compruebe que las baterías estén conectadas a la máquina (7 ). • Encienda el conmutador de llave (A) y compruebe el indicador de batería (B). Si la luz verde está encendida, las baterías están listas para el uso. Si la luz verde está apagada, las baterías deberían cargarse antes de la utilización. Consulte la sección “Recarga de las baterías”. Si su máquina se entrega sin baterías instaladas, rea
