Résumé du contenu de la page N° 1
CARE AND OPERATION INSTRUCTIONS
Crestline™ Series B-Vent Gas Fireplaces
36"/42" LSBV Models
P/N 875035M Rev. D 07/2010
This manual is one of a set of two supporting this product.
MODELS
Refer to P/N 850042M for Installation Instructions.
This manual is available in French. Order P/N 506223-08.
Millivolt Models Electronic Models
Ce manuel est disponible en francais. Simplement en faire
la demande numéro de la pièce 506223-08. LSBV-3628MN LSBV-4228MN LSBV-3628EN
LSBV-3628MP LSB
Résumé du contenu de la page N° 2
LENNOX CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS S'assurer que le brùleur et le compartiment des CONGRATULATIONS! commandes sont propres. Voir les instructions d'installation et d'utilisation qui accompagnent In selecting this LENNOX B-vented gas appliance, you have chosen one of the finest l'apareil. and most dependable fireplaces available. This gas fireplaces is a beautiful, prestigious alternative to a wood burning fireplace
Résumé du contenu de la page N° 3
LENNOX CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS Millivolt appliances may be fitted at time of WARNING: B-VENT APPLIANCES ARE manufacture with either a Honeywell millivolt SIT Valve NOT DESIGNED TO OPERATE IN NEGA- Shown gas control valve or as SIT millivolt gas control TIVELy PRESSURED ENVIRONMENTS valve. Both valves have been tested with and (PRESSURE WITHIN THE HOME IS approved for use with these appliances and are listed
Résumé du contenu de la page N° 4
O O L I P T O it TPTH TP TH L I P F F LENNOX CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS Fully Open or Fully Closed Figure 4 Piezo Ignitor DAMPER AND OUTSIDE AIR CONTROLS Gas Control SIT Millivolt Valve Knob This appliance is fitted with a manually controlled vent damper. The vent damper should be closed Figure 2 when the appliance is not in use to prevent cold air from entering the home through the venting system. The damper is c
Résumé du contenu de la page N° 5
LENNOX CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS The appliance is equipped with an outside Maintenance WARNING: DO NOT OPERATE THE (make-up air) vent system that is designed to SHUTOFF LEVER UNLESS A COMPLETE The appliance and venting system should be provide the appliance with outside make-up air OUTSIDE AIR VENT SySTEM HAS BEEN thoroughly inspected before initial use and at for combustion when in operation. The shut- leas
Résumé du contenu de la page N° 6
LENNOX CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS Maintenance Schedule Annually (Before the onset of the Burning Season) Maintenance Task Accomplishing Person Procedure Inspecting/Cleaning Burner, Logs Qualified Service Technician Inspect valve and ensure it is properly operat- and Controls ing. Check piping for leaks. Vacuum the control compartment, fireplace logs and burner area. Check Flame Patterns and Flame Height Qualified
Résumé du contenu de la page N° 7
AVERTISSEMENT Un foyer chaud peut causer de graves brûlures Ne laissez jamais un enfant toucher à la vitre ou à toutes autres parties du foyer LENNOX CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS HOMEOWNER’S INSTRUCTIONS - ATTACHING "SAFETy-IN-OPERATION" WARNINGS ATTACHING SAFETy IN OPERATION WARNINGS APPOSITION DES MISES EN GARDE RELATIVES COLOCACIó N DE ADVERTENCIAS DE SEGURIDAD à LA Sé CURIT é D’UTILISATION EN OPERACIó N Your fir
Résumé du contenu de la page N° 8
LENNOX CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS Adjustment To adjust the flame, position the air shutter to the nominal setting (see Figure 7 ). Allow the burner to operate for at least 30 minutes. Observe the flame continuously. If it appears weak or sooty as previously de- scribed, adjust the air shutter open or closed until desired effect is achieved. Note: If the flame still appears anemic with the air shutter closed all
Résumé du contenu de la page N° 9
LENNOX CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS These appliances are equipped with a beautifully Step 3. Place the left log as shown in Figure Logs and Rockwool Placement crafted six (6) piece ceramic fiber log set. The 13, on the landing of the rear log. Make sure logs, shown in Figure 8 on page 8, are to be the landing on the front end of the log is resting WARNING: LOGS GET VERy HOT AND positioned precisely as shown. Any
Résumé du contenu de la page N° 10
TP TH TP TH LENNOX CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS WIRING DIAGRAMS Wiring diagrams are provided here for reference purposes only. This information is also provided on schematics attached directly to the appliance on a pullout panel located within the control compartment. Two Millivolt wiring diagrams are provided here, one each for both Honeywell and SIT equipped systems. THERMOPILE MILIVOLT WIRING DIAGRAM GAS VALVE WALL
Résumé du contenu de la page N° 11
LENNOX CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS WARRANTy REPLACEMENT PARTS When ordering repair parts, always give the following information: Your gas appliance is covered by a limited twenty A complete parts list is found at the end of 1. The model number of the appliance. year warranty. You will find a copy of the war- this manual. Use only parts supplied from the 2. The serial number of the appliance. ranty accompanying this ma
Résumé du contenu de la page N° 12
O O L I P T O it TPTH TP TH L I P F F LENNOX CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS LIGHTING INSTRUCTIONS – SIT MILLIVOLT GAS VALVE FOR yOUR SAFETy READ BEFORE LIGHTING WARNING: IF yOU DO NOT FOLLOW THESE INSTRUCTIONS ExACTL y, A FIRE OR ExPLOSION MAy RESULT CAUSING PROPERTy DAMAGE, PERSONAL INjUR y OR LOSS OF LIFE. A. This appliance has a pilot which must be lighted with a piezo • Do not use any phone in your building. ignitor.
Résumé du contenu de la page N° 13
O O L I P T O it TPTH TP TH L I P F F LENNOX CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS INSTRUCTIONS D’ALLUMAGE – VANNE GAz MILLIVOLT SIT POUR VOTRE Sé CURITé , LISEz CES INSTRUCTIONS AVANT L’ALLUMAGE AVERTISSEMENT : SI VOUS NE SUIVEz PAS CES INSTRUCTIONS à LA LETTRE, IL POURRAIT S’EN SUIVRE UN INCENDIE OU UNE ExPLOSION CAUSANT DES DOMMAGES MATéRIELS, DES BLESSURES CORPORELLES OU MêME DES PERTES DE VIE. • Appelez immédiatement votre
Résumé du contenu de la page N° 14
LENNOX CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS LIGHTING INSTRUCTIONS — ELECTRONIC FOR yOUR SAFETy READ BEFORE LIGHTING WARNING: IF yOU DO NOT FOLLOW THESE INSTRUCTIONS ExACTL y, A FIRE OR ExPLOSION MAy RESULT CAUSING PROPERTy DAMAGE, PERSONAL INjUR y OR LOSS OF LIFE. A. When lighting the appliance, follow these instructions • Immediately call your gas supplier from a neighbor’s exactly. phone. • If your gas supplier cannot be reac
Résumé du contenu de la page N° 15
LENNOX CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS INSTRUCTIONS D’ALLUMAGE — ELECTRONIC POUR VOTRE Sé CURITé , LISEz CES INSTRUCTIONS AVANT L’ALLUMAGE AVERTISSEMENT: SI VOUS NE SUIVEz PAS CES INSTRUCTIONS à LA LETTRE, IL POURRAIT S’EN SUIVRE UN INCENDIE OU UNE ExPLOSION CAUSANT DES DOMMAGES MATéRIELS, DES BLESSURES CORPORELLES OU MêME DES PERTES DE VIE. A. Lorsque vous allumez l’appareil, suivez exactement ces instruc- • Appelez immé
Résumé du contenu de la page N° 16
LENNOX CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS TrOuBLESHOOTiNg THE MiLLivOLT gAS CONTrOL SYSTEM Note: Before troubleshooting the gas control system, be sure external gas shut off valve (located at gas supply inlet) is in the “ON” position. important: Valve system troubleshooting should only be accomplished by a qualified service technician. SyMPTOM POSSIBLE CAUSES CORRECTIVE ACTION 1. Spark ignitor will not light A. Defective ignit
Résumé du contenu de la page N° 17
LENNOX CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS TrOuBLESHOOTiNg THE ELECTrONiC igNiTiON SYSTEM Note: Before troubleshooting, be sure that the appliance main line gas shut-off valve, the gas control valve and the wall switch are in the “ON” position. important: Valve system troubleshooting should only be accomplished by a qualified service technician. SyMPTOM POSSIBLE CAUSES CORRECTIVE ACTION 1. Nothing happens when A. Low voltage/o
Résumé du contenu de la page N° 18
LENNOX CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS ACCESSORy COMPONENTS Pine Cones and Wood Bits 91L05 FPCk Twelve Piece Ember kit A twelve piece ember kit (model FPCK) has been developed to provide a means of enhancing the already impressive log presentation of this Remote Control System (Standard) H0249 RCL H5794 36LBFB fireplace. This kit contains three (3) ceramic H5795 36LBFB-BB H5796 36LBFB-BS fiber pine cones and nine (9
Résumé du contenu de la page N° 19
LENNOX CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS ACCESSORy COMPONENTS Outside Combustion Air kits (with duct) 81L87 FOAk-4 (without duct) 81L88 FOAk-LD Arch Screen Door H1960 H1961 Decorative Arch Screen Door This attractive screen door is east to install and enhances the appearance of the appliance. H5800 LDGHk36 Hood kit H5801 LDGHk42 Hood kit This hood is designed to be fitted to the face of the applianc
Résumé du contenu de la page N° 20
LENNOX CRESTLINE™ SERIES B-VENT GAS FIREPLACES • 36"/42" LSBV MODELS • CARE AND OPERATION INSTRUCTIONS REPLACEMENT PARTS LIST LSBV-3628 LSBV-4228 No. DESCRIPTION Part No. qty. Part No. qty. 1. Gas Fireplace Assembly – – – – 2. Firescreen H3820 2 H3827 2 3. Rod, Screen H3815 2 H3828 2 4. Refractory, Side (RH) H3816 1 H3816 1 Refractory, Side (RH) Herringbone H3821 1 H3829 1 5. Refractory, Side (LH) H3817 1 H3817 1 Refractroy, Side (LH) Herringbone H3822 1 H3830 1 6. Refractory
