Résumé du contenu de la page N° 1
▪ ▪ ▪ ▪ ▪
F R E E
SAFETY
GUARD
PROTECTS AGAINST BURNS
▪ ▪
See Page 2 For Details
CARE AND OPERATION INSTRUCTIONS
SLDVT Direct-Vent
P/N 506010-01 Rev. F 06/2011
Gas Fireplaces
This manual is part of a set of two supporting this product.
Refer to P/N 506009-01 for Installation Instructions.
MODELS
Ce manuel est disponible en francais, simplement
MILLIVOLT: ELECTRONIC:
en faire la demande. Numéro de la pièce 506223-02.
SLDVT-30NM SLDVT-40NM SLDVT-30NE
SLDVT-30PM SLDVT-40PM SLDVT-35NE
WHAT
Résumé du contenu de la page N° 2
® SUPERIOR DIRECT-VENT GAS FIREPLACES • MODELS SLDVT-30/35/40/45 • CARE AND OPERATION INSTRUCTIONS Thank you for your purchase. We appreciate your business! Please carefully read and follow all instructions in this manual. Safety and Pay special attention to all warnings and safety information. Following these safety, care, and operation instructions will help Your Fireplace ensure many years of dependable and enjoyable service from your fireplace. All parts of your Lennox Hearth Produ
Résumé du contenu de la page N° 3
® SUPERIOR DIRECT-VENT GAS FIREPLACES • MODELS SLDVT-30/35/40/45 • CARE AND OPERATION INSTRUCTIONS [FRENCH] [SPANISH] La sécurité et Seguridad y votre foyer su chimenea Toutes les parties de votre foyer ¡Todas las partes de la chimenea Lennox Hearth Products deviennent Lennox Hearth Products se ponen EXTRÊMEMENT CHAUDES ! MUY CALIENTES! Afin d'éviter de vous brûler gravement ou de Instale una malla o barrera física para evitar vous blesser, installez une grille ou une barrière el c
Résumé du contenu de la page N° 4
® SUPERIOR DIRECT-VENT GAS FIREPLACES • MODELS SLDVT-30/35/40/45 • CARE AND OPERATION INSTRUCTIONS Important Safety Information L'information de sûreté importante 1. WARNING: Do not operate appliance with the glass front 1. AVERTISSEMENT. Ne pas utiliser l’appareil si le panneau frontal en verre n’est pas en place, est craqué ou brisé. Confiez le removed, cracked or broken. Replacement of the glass remplacement du panneau à un technicien agréé should be done by a licensed or qualified s
Résumé du contenu de la page N° 5
® SUPERIOR DIRECT-VENT GAS FIREPLACES • MODELS SLDVT-30/35/40/45 • CARE AND OPERATION INSTRUCTIONS HOMEOWNER’S INSTRUCTIONS - ATTACHING-SAFETY-IN OPERATION WARNINGS ATTACHING SAFETY-IN-OPERATION APPOSITION DES MISES EN GARDE RELATIVES COLOCACIóN DE ADVERTENCIAS DE WARNINGS à LA SÉCURITÉ D’UTILISATION SEGURIDAD EN OPERACIóN Your fireplace has been furnished with safety instruc- Votre foyer a été livré avec des étiquettes de sécurité qui Su chimenea incluye etiquetas de instrucciones de t
Résumé du contenu de la page N° 6
® SUPERIOR DIRECT-VENT GAS FIREPLACES • MODELS SLDVT-30/35/40/45 • CARE AND OPERATION INSTRUCTIONS Appliance Installation, Service, Appliance Operation Notices Warranty Information and Maintenance Notices Your gas appliance is covered by a limited Do not operate appliance with the glass twenty-year warranty. You will find a copy front removed, cracked, or broken. IMPORTANT: Improper installation, of the warranty accompanying this manual. adjustment, alteration, service, or main- Plea
Résumé du contenu de la page N° 7
® SUPERIOR DIRECT-VENT GAS FIREPLACES • MODELS SLDVT-30/35/40/45 • CARE AND OPERATION INSTRUCTIONS Gas Pressure Requirements Orifice Sizes GENERAL INFORMATION (All Models) (Sea Level to High Altitude – All Models) The fireplace models covered in this manual Gas pressure requirements are listed in These appliances are tested and approved for are direct-vent sealed combustion gas fireplace heaters designed for residential application. installations at elevations of 0-4500 feet (0-1372 T
Résumé du contenu de la page N° 8
® SUPERIOR DIRECT-VENT GAS FIREPLACES • MODELS SLDVT-30/35/40/45 • CARE AND OPERATION INSTRUCTIONS OPERATION AND CARE OF YOUR APPLIANCE On millivolt systems, the piezo igniter, HI/LO flame adjustment knob, and pilot and main gas OFF/ON control knob are located below WARNING the glass panel enclosure. The gas valve for electronic systems is also located below the Young children should be carefully supervised when they are in the glass enclosure panel (see Figure 1). same room a
Résumé du contenu de la page N° 9
O O W W OUT IN IN T T H H N N ® SUPERIOR DIRECT-VENT GAS FIREPLACES • MODELS SLDVT-30/35/40/45 • CARE AND OPERATION INSTRUCTIONS Electronic Appliances Note: It is recommended that batteries not be installed in the battery holder until a power Pressure-Tap Burner Stage (Manifold) Terminal To light electronic appliances refer to the detailed outage, or if the appliance is to be operated Regulator Gas lighting instructions found on Pages 24 and solely with two (2) "D" batteries. Supply G
Résumé du contenu de la page N° 10
® SUPERIOR DIRECT-VENT GAS FIREPLACES • MODELS SLDVT-30/35/40/45 • CARE AND OPERATION INSTRUCTIONS Cleaning Glass Replacing Logs MAINTENANCE (Also see Front Glass Enclosure Panel, Removal If the logs become damaged by accident or (See Maintenance Schedule, Page 26) and Installation on Page 11). improper handling and need replacement, Note: Clean glass after first two weeks of use only the proper replacement logs from Refer to the maintenance schedule for maintenance operation (after
Résumé du contenu de la page N° 11
® SUPERIOR DIRECT-VENT GAS FIREPLACES • MODELS SLDVT-30/35/40/45 • CARE AND OPERATION INSTRUCTIONS Front Glass Enclosure Panel, Removal Only doors certified with the appliance Header and Installation shall be used. Spacing Seules des portes certifiées pour cet Top Standoffs appareil doivent être utilisées. WARNING CAUTION: DO NOT abuse glass door by 5/8” • Do not attempt to substitute the Nailing striking or slamming shut. Flange materials used on this door, 1/2” or replace crac
Résumé du contenu de la page N° 12
® SUPERIOR DIRECT-VENT GAS FIREPLACES • MODELS SLDVT-30/35/40/45 • CARE AND OPERATION INSTRUCTIONS SLDVT-30 and 35 - Install the four logs as Volcanic Stone Follows: WARNINGS Carefully position the ceramic fiber logs over • DO NOT attempt to install the the burner as shown in Figure 9. Logs should logs until the appliance instal- be placed in the order shown and per the fol- lation has been completed, the lowing instructions. gas line connected and tested for leaks and the ini
Résumé du contenu de la page N° 13
® SUPERIOR DIRECT-VENT GAS FIREPLACES • MODELS SLDVT-30/35/40/45 • CARE AND OPERATION INSTRUCTIONS SLDVT-30 AND SLDVT-35 LOG PLACEMENT Log 3 4 Number Description 1 Left Front Log 2 Right Front Log 3 Left Rear Log 4 Right Rear Log Catalog Number for the entire log set: H7244 1 2 Position on the left Left Rear Brackets Right Rear Bracket 3 rear log brackets Right Front Log "Nub" Left Front Brackets Rockwool Right Front Brackets 2 1 (Do Not Place Rockwool Over Burner Slots) Step 3 St
Résumé du contenu de la page N° 14
® SUPERIOR DIRECT-VENT GAS FIREPLACES • MODELS SLDVT-30/35/40/45 • CARE AND OPERATION INSTRUCTIONS SLDVT-40 LOG PLACEMENT Log 5 4 1 Number Description 1 Ember Chunk 2 Left Front Log 3 Right Front Log 4 Left Rear Log 5 Right Rear Log Catalog Number for the entire log set: H7245 2 3 Left Rear Position on the left Place Ember Chunk Here Right Rear Bracket 4 rear log bracket Bracket Right Front Log "Nub" Left Front Brackets Rockwool Right Front Brackets 2 3 (Do Not Place Rockwool
Résumé du contenu de la page N° 15
® SUPERIOR DIRECT-VENT GAS FIREPLACES • MODELS SLDVT-30/35/40/45 • CARE AND OPERATION INSTRUCTIONS SLDVT-45 LOG PLACEMENT Log 4 3 5 Number Description 1 Left Front Log 2 Right Front Log 3 Center Log 4 Left Rear Log 5 Right Rear Log Catalog Number for the entire log set: H7547 2 1 Align holes at the bottom of Left Rear Center Rear Bracket Right Rear Bracket 3 center log (3) over the center Brackets Center Log "Groove" and right rear brackets. Left Front Brackets Rockwool Righ
Résumé du contenu de la page N° 16
® SUPERIOR DIRECT-VENT GAS FIREPLACES • MODELS SLDVT-30/35/40/45 • CARE AND OPERATION INSTRUCTIONS BURNER ADJUSTMENTS (QUALIFIED TECHNICIANS ONLY) Flame Appearance and sooting Proper flame appearance is a flame which is blue at the base and becomes yellowish-orange in the body of the flame. When the appliance is first lit, the entire flame may be blue and will gradually turn yellowish-orange during the first 15 minutes of operation. If after a short period the flame stays lowered b
Résumé du contenu de la page N° 17
® SUPERIOR DIRECT-VENT GAS FIREPLACES • MODELS SLDVT-30/35/40/45 • CARE AND OPERATION INSTRUCTIONS Burner Air Shutter Adjustment Procedure 4. Leave the control knob (off/pilot/on) in the Millivolt Appliance Checkout ON position and the burner OFF/ON switch OFF (and remote switches, if applicable). The pilot flame should be steady, not lifting WARNINGS or floating. Flame should be blue in color with 5. When satisfied that the burner flame ap- traces of orange at the outer edge. pear
Résumé du contenu de la page N° 18
VENT TH TH TP TP ® SUPERIOR DIRECT-VENT GAS FIREPLACES • MODELS SLDVT-30/35/40/45 • CARE AND OPERATION INSTRUCTIONS If you encounter any problems or have any Please call Lennox Hearth Products for the ORDERING REPLACEMENT questions concerning the installation or ap- phone number of your nearest LHP dealer, PARTS plication of this system, please contact your who will answer your questions or address dealer or distributor. your concerns. A complete parts list is found at the end of this
Résumé du contenu de la page N° 19
® SUPERIOR DIRECT-VENT GAS FIREPLACES • MODELS SLDVT-30/35/40/45 • CARE AND OPERATION INSTRUCTIONS Unit Shipping Weights/Volumes Cat. Model Ship. Ship. No. Weight Volumn H7496 SLDVT-30NM 78 lbs. 9.09 cu. ft. H7497 SLDVT-30PM 78 lbs. 9.09 cu. ft. H7498 SLDVT-30NE 78 lbs. 9.09 cu. ft. H7282 SLDVT-35NM 86 lb. 10.61 cu. ft. H7284 SLDVT-35PM 86 lb. 10.61 cu. ft. H7286 SLDVT-35NE 86 lb. 10.61 cu. ft. H7283 SLDVT-40NM 108 lb. 14.01 cu. ft. H7285 SLDVT-40PM
Résumé du contenu de la page N° 20
® SUPERIOR DIRECT-VENT GAS FIREPLACES • MODELS SLDVT-30/35/40/45 • CARE AND OPERATION INSTRUCTIONS ACCESSORY COMPONENTS (continued) Screen Panel Kits Pull Screen Panel Kit Cat. No. Model No. Models Where Used This easy to install optional decorative screen kit H6112 PSFPKM30 SLDVT-30 installs over the standard glass enclosure panel. H6113 PSFPKM35 SLDVT-35 These screen kits cannot be used in conjunction with the arch door kits or door frame kits. H6114 PSFPKM40 SLDVT-40 H6115 PSFPKM45 S
