Résumé du contenu de la page N° 1
CHARNWOOD
COUNTRY 15B
Roomheater with Boiler
Operating
and
Installation Instructions
CHARNWOOD Bishops Way, Newport, Isle of Wight PO30 5WS, United Kingdom
T:+44 (0)1983 537799 F:+44 (0)1983 537788 charnwood@ajwells.co.uk www.charnwood.com
Résumé du contenu de la page N° 2
OPERATING INSTRUCTIONS FOR THE CHARNWOOD COUNTRY 15B Before lighting the stove check with reduced outputs. The wood should be 1) In the solid fuel position the grate the installer that the work and checks cut and split and then left to season in bars are vertical with gaps in between described in the Installation a well ventilated dry place for at least allowing the primary combustion air Instructions have been carried out one year but preferably two years to come up through the grate and correc
Résumé du contenu de la page N° 3
or fire lighters, and kindling on the each stage for the flames to appear REFUELLING grate and cover with approximately2 above the fire. inches of fuel. Turn the control knob Keep the firebox well filled but do not Aftera period of slumbering always to maximum, and open the airwash overfill to prevent fuel from spilling turn the air control up to maximum control fully (see Fig. 1). Light the over the top of the front fire bars. and wait until flames appear above the paper or fire lighters. Close
Résumé du contenu de la page N° 4
maximum. When the fire is burning e) that an extractor fan is not fitted in well load on more fuel as necessary the same room as the stove. and move the air controls to the f) there is sufficient draw in the desired setting. chimney, (once the chimney is warma draught reading of at least 0.10 inches When burning wood use large logs water gauge should be obtained). rather than small ones. Proceed as above, but do not riddle the fire either Throat Plate when shutting down or reviving. Door Glass B
Résumé du contenu de la page N° 5
ventilate the room. d) If the hot water goes cold when the Over-Firing b) Let the fire out and safely dispose pump is turned on, or if some radiators of the fuel from the appliance. If the fire is over-fired it will cause are hotter than others, then the system c) Check for flue or chimney may need balancing, the pump may be premature failure of the internal fire blockage, and clean if required. pumping the water too quickly around parts. Overfiring is occurring when d) Do not attempt to re-ligh
Résumé du contenu de la page N° 6
INSTALLATION INSTRUCTIONS FOR THE CHARNWOOD COUNTRY 15B If it is found that there is excessive HEALTH AND SAFETY CHIMNEY draw in the chimney thena draught stabilizer should be fitted. PRECAUTIONS In order for the appliance to perform satisfactorily the chimney height must It is important that there is sufficient Please take care when installing the not be less than4 metres measured draw in the chimney and that the stove that the requirements of the vertically from the outlet of the stove chimney
Résumé du contenu de la page N° 7
suitable inhibitor should be used. The 22mm Open Vents system must be correctly vented as Feed and Expansion Tank Cold Water Tank shown in Figs.5 and 6. The height differential between the header tank Overflow Overflow and the appliance must not exceed 15.2 metres (50 feet). If all four boiler tappings are used Domestic Hot Water Draw Off then, if possible, diagonal pairs should be connected for domestic hot water and central heating. Wherea common return is used an injector tee must be Gravity
Résumé du contenu de la page N° 8
Back of the Stove Blanking Plate Soot Door Alternative In Side or Rear Soot Door Of Chimney Positions Register Plate With Soot Door Clamping Plate Blanking Plate with fold horizontal Clamping plate finishes flush with inside face of firebox top and bottom. Fig 8. Vertical Register Plate With Bricked Up Fireplace Seal Blanking Plate Fig 11. Horizontal Register Plate with fire cement Alternative With Vertical Rear Flue Soot Door Connector Positions Fig. 12. Flue Blanking Plate. Various types and p
Résumé du contenu de la page N° 9
knob is turned. roof of the appliance and should be adjusted to give the correct water flow checked to ensure that it has not against the circuit resistance and the become dislodged in transit. The system should be correctly balanced. PRE LIGHTING method of location and positioning of On completion of the installation and the throat plate is shown in Fig. 3. CHECK commissioning please leave the operating instructions with the Before initial lighting the following customer and advise on the use o
Résumé du contenu de la page N° 10
IssueD CHARNWOOD COUNTRY 15B PARTS LIST 38 40 35 48 Items 26& 27 are not used on models after serial no. 1926 Item 24 has been replaced by items 51& 52 but they are not interchangeable. 9 23 39 28 14 52 7 6 13 10 11 46 12 33 15 21 43 41 45 44 47 42 16 32 34 29 15 21 30 31 31 19 20 8 26 28 7 6 23 36 25 37 51 17 27 22 24 24 Item Part No. Description Item Part No. Description 1* 008/FV35L Left Hand Door Seal 36 002/FV01 Left Hand Door 2* 008/FV35R Right Hand Door Seal 37 002/FV02 Right Hand Door 3*
Résumé du contenu de la page N° 11
Your Local Charnwood Dealer CHARNWOOD Bishops Way, Newport, Isle of Wight PO30 5WS, United Kingdom T:+44 (0)1983 537799 F:+44 (0)1983 537788 charnwood@ajwells.co.uk www.charnwood.com
