Résumé du contenu de la page N° 1
INSTALLER’S & OWNER’S MANUAL
HVAC INSTALLER: PLEASE LEAVE MANUAL FOR HOMEOWNER
Rx
Rx
n
Free-standing dehumidification
for your home.
n
Includes installation, operating
and safety instructions, warranty
information and all ancillary products.
n
Read and save these instructions.
P.O. Box 8680 Madison, WI 53708 • TOLL-FREE 1-800-533-7533 • www.thermastor.com • sales@thermastor.com
© 2006 Therma-Stor LLC • Manual P/N TS- 235 8/07
For small usage:
Résumé du contenu de la page N° 2
TABLE OF CONTENTS Table of Contents 1. Specifications Part Number: 4023673 1. Specifications .......................................................................... 2 Model: Santa Fe Rx Dehumidifier 2. Installation .............................................................................. 2 Electrical: 110-120 VAC, 6.3 Amps, grounded 2.1 Location .............................................................................. 2 Capacity: 86 pints/day @ 80°F, 60% RH 2.2 Electrical Requireme
Résumé du contenu de la page N° 3
SAFETY PRECAUTIONS The water is discharged through a 20’ long white hose coming 3.2 Humidity Control Adjustment from the unit bottom. The hose is about the diameter of a TV The humidity control knob is located under the removable top (top coaxial cable and can be routed in much the same way. If a drain must be lifted off to access). Turning the knob clockwise lowers is not convenient, a small hole can be drilled through the floor humidity. Turning it counter clockwise to the stop shuts it
Résumé du contenu de la page N° 4
FOR HVAC INSTALLER ONLY continuously, the filter is clean enough for continued use. If the 4.1A Filter Options ball floats above the hole and starts to spin and perhaps wobble An optional filter frame is available that attaches to the back of the within 30 seconds, the filter needs to be changed. machine and adds 6-1/2” to the units’ depth. It allows the choice of using either 95% efficient, HEPA grade, or activated carbon 5. Service filters in addition to the standard filter. These filters
Résumé du contenu de la page N° 5
FOR HVAC INSTALLER ONLY 3. Defective compressor overload (Sec. 5.6A). 2. Remove the unit top. 4. Defective compressor (Sec. 5.6). 3. If optional HEPA, 95% efficient or carbon filters are attached to 5. Defrost thermostat open (Sec. 5.8). the unit back, the filter(s) and their frame must be removed. 6. Defective relay (Sec. 5.10). 4. Remove the back cover (4 screws). 7. Pump Safety switch open (Sec. 5.9) 5. Remove the cabinet (6 screws). 6. Disconnect the blower leads: black from the black wir
Résumé du contenu de la page N° 6
FOR HVAC INSTALLER ONLY 5.6A Replacing a Burned out Compressor 5.10 Relay The refrigerant and oil mixture in a compressor is chemically very The relay provides power to the compressor via the black wire. stable under normal operating conditions. However, when an Current passes through relay contacts between terminals 4 and 6. electrical short occurs in the compressor motor, the resulting high The contacts are closed when power is applied to relay terminals temperature arc causes a portion of
Résumé du contenu de la page N° 7
SANTA FE Rx WIRING DIAGRAM 7 Santa Fe Rx Installer’s & Owner’s Manual
Résumé du contenu de la page N° 8
SANTA FE Rx SERVICE PARTS LIST • To order contact your reseller or call 1-800-533-7533 ITEM PART NO. QTY. DESCRIPTION ITEM PART NO. QTY. DESCRIPTION 1 4022254 1 Accumulator 4020530 3 Compressor Mounting Grommet 2 4021475 1 Air Filter, 2 x 16 x 20 Nominal 11 4023649 1 Condensate Pump, Low Profile 4024145 1 Air Filter, 4 x 20 x 32 Nominal, HEPA 12 4023661 1 Cord/Wire Harness (not shown) (optional, requires kit, Item 3) 13 4021470 1 Defrost Control Thermostat 4023612 2 Air Filter, 3 x 16 x
Résumé du contenu de la page N° 9
SANTA FE Rx FILTER FRAME ASSEMBLY This kit attaches to the back of the Santa Fe Rx. The back is the Filter Test side where the air comes out of the lower section. The optional 95% efficiency and HEPA filters have long lives when prefitered by the standard pleated inlet filter; they can 1. Remove the protective plastic from the frame top & sides. last many years in certain conditions. How long they last can, Assemble the frame top (Item 1) & bottom (Item 2) to the frame sides however, vary
Résumé du contenu de la page N° 10
SANTA FE Rx SET UP INSTRUCTIONS Before operating this unit, please read the Installers & Owners 5. Blower switch is set in the off position at the factory. See manual Manual. for blower operation options. 6. Install the filter (as shown in Figure). Air flow arrow must point How to prepare the Santa Fe Rx for operation down. 1. Locate the unit per the manual. 7. L ower the top down so the keyhole slots in the top drop over the 2. Cut the cable tie holding the cord and hose on top. posts. Sli
Résumé du contenu de la page N° 11
SANTA FE Rx LAMINATE TOP KIT Please read these instructions before modifying the Santa Fe Rx to 4. A ttach the ¾” diameter by 1” high rubber bumpers to the outer use the Laminated Top holes as indicated using the phillips screwdriver and the screws provided. 1. Tools required. A medium size phillips screwdriver. 5. P lace the laminated top so the holes in the bottom of the 2. Remove the posts using the phillips screwdriver. laminated top rests over the ¾” diameter by 1” high rubber 3. R emov
Résumé du contenu de la page N° 12
Santa Fe Rx Dehumidifier Limited Warranty WARRANTOR: modification, unauthorized or improper repair or installation, accident, acts of nature or any other cause Therma-Stor LLC beyond Therma-Stor LLCs reasonable control. PO Box 8680 Madison, WI 53708 LIMITATIONS AND EXCLUSIONS: If any SANTA FE RX Telephone: 1-800-533-7533 Dehumidifier part is repaired or replaced, the new part shall be warranted for only the remainder of the original WHO IS COVERED: This warranty extends only warranty peri
Résumé du contenu de la page N° 13
Information in this document is subject to change without notice. No part of PO Box 8680 • Madison, WI 53708 this document may be reproduced or transmitted in any form or by any means, Phone: 608-222-5301 • Fax: 608-222-1447 electronic or mechanical, for any purpose, without the express written permission of Therma-Stor LLC. © 2006 Therma-Stor LLC. All rights reserved. Web: www.thermastor.com • Email: sales@thermastor.com
