Résumé du contenu de la page N° 1
Quality Refrigeration
OWNER’S MANUAL OWNER’S MANUAL
OWNER’S MANUAL
OWNER’S MANUAL OWNER’S MANUAL
Instructions for the installation, operation
and maintenance of all Traulsen:
Reach-In Even Thaw Refrigerator Models*
Reach-In Models*
RET132EUT-FHS, RET132EUT-HHS, RET232EUT-FHS, RET232EUT-HHS,
RET232NUT-FHS & RET232NUT-HHS
*For roll-in even-thaw models please refer to form number TR35867.
This Traulsen unit is built to our highest quality standards. We build our refrigerators, freezers and heated
Résumé du contenu de la page N° 2
TABLE OF CONTENTS I. THE SERIAL TAG Page 1 VI. OTHER II. RECEIPT INSPECTION Page 2 a-Service Information Page 5 III. INSTALLATION b-Spare Parts Page 5 a-Location Page 2 c-Warranty Registration Page 5 b-Packaging Page 2 VII. GEN’L USE, OPERATION & SERVICE SUMMARY Page 6 c-Installing Legs or Casters Page 2 VIII. EXPECTED THAW PERFORMANCE/ d-Tray Slides Page 2 OPERATIONAL TROUBLESHOOTING e-Cord & Plug Page 3 a-Introduction Page 7 f-Power Supply Page 3 b-Test Parameters Page 7 g-Wiring Diagram Page
Résumé du contenu de la page N° 3
II. RECEIPT INSPECTION III. INSTALLATION (cont’d) All Traulsen products are factory tested for perfor- III. c - INSTALLING LEGS OR CASTERS: mance and are free from defects when shipped. The lieu of legs are available as an optional accessory for utmost care has been taken in crating this product to the same models. These are shipped from the factory protect against damage in transit. All interior fittings packed inside a cardboard box which is strapped to have been carefully secured and the l
Résumé du contenu de la page N° 4
III. INSTALLATION (cont’d) IV. OPERATION (cont’d) III. e - CORD & PLUG: IV. c - EVEN THAW OPERATION: Most self-contained models are supplied with a cord & The Traulsen Even-Thaw cabinet is a refrigerator, with two plug attached. It is shipped coiled at the top of the cabi- important additional features: 1) the ability to introduce net, secured by a nylon strip. For your safety and pro- small amounts of heat into the cabinet, and 2) increased tection, all units supplied with a cord and plug inc
Résumé du contenu de la page N° 5
IV. OPERATION (cont’d) V. CARE & MAINTENANCE IV. g - ADJUSTING THE TEMPERATURE SCALE: V. a - CLEANING THE CONDENSER: The Traulsen Even-Thaw model is preset at the factory The most important thing you can do to insure a long, to operate within strict temperature parameters. Should reliable service life for your Traulsen is to regularly clean these settings require adjustment, please contact our the condenser coil. Service Department at (800) 825-8220. The condensing unit requires regularly sched
Résumé du contenu de la page N° 6
V. CARE & MAINTENANCE (cont’d) VI. OTHER V. c - REPLACING THE GASKETS: VI. a - SERVICE INFORMATION: To remove the gasket to be replaced, grasp it firmly Before calling for service, please check the following: by one corner and pull it out. Before attempting to install a new gasket, both the unit and the gasket it- Is the electrical cord plugged in? self must be at room temperature. Insert the four cor- ners first by using a rubber mallet (or hammer with a Is the fuse OK or circuit breaker on?
Résumé du contenu de la page N° 7
VII. GENERAL USE, OPERATION & SERVICE SUMMARY VI. b - LOADING GUIDELINES: VI. a - INTRODUCTION/OVERVIEW: The Even-Thaw model can accommodate any size The Traulsen Even Thaw is designed to be used as a partial load, or up to (28) 18” x 26” pans of product (for thawing cabinet. While it may be utilized in a example approximately 672 lbs. of chicken). Use of alu- refrigeration mode, that is not its intended use. Its minum pans is highly recommended. Product should be function is to hold the cabin
Résumé du contenu de la page N° 8
VIII. EXPECTED THAW PERFORMANCE/OPERATIONAL TROUBLESHOOTING VIII. a - INTRODUCTION: VIII. f - EQUIPMENT ISSUES: Even thaw performance is a function of many factors, If improper loading has been eliminated as a possible especially those involving product types and loading. cause for extended thaw cycle times, there are As a result, actual thaw times will vary as even similar several system checks which can be done to diagnose sized loads of the same product will exhibit some the Traulsen Even-Tha
Résumé du contenu de la page N° 9
VIII. OPERATIONAL TROUBLESHOOTING (cont’d) VIII. g - OTHER CAUSES OF EXTENDED THAW TIMES (cont’d): evaporator exit air can be short circuited on to the top two or three upper right hand levels and be routed right back to the return evaporator inlet duct. Therefore, those upper shelves could get very cold and perhaps a substantial amount of product on the right side could become very cold and possibly even refreeze (as the evaporator outlet air temperature is 20 degrees F). IX. TROUBLE SHOOTING
Résumé du contenu de la page N° 10
X. SPARE PARTS LIST PART NUMBER APPLIES TO MODEL(S) PART NAME AND/OR DESCRIPTION 341-60105-00 RET132EUT-FHS Full Height Door Gasket SFO-17357-00 RET232EUT-FHS Full Height Door Gasket 341-60060-00 RET232NUT-HHS Half Height Door Gasket 341-09501-00 RET232NUT-FHS Full Height Door Gasket 325-60003-00 RET132EUT & RET232EUT Filter Drier 325-60003-03 RET232NUT Filter Drier 325-60080-08 RET132EUT TXV Valve 134a 325-60080-07 RET232NUT & RET232EUT TXV Valve 134a 337-60006-00 RET132EUT & RET232NUT Run
Résumé du contenu de la page N° 11
XI. WIRING DIAGRAM ALL ONE SECTION MODELS ONLY -10-
Résumé du contenu de la page N° 12
XII. WIRING DIAGRAM MODELS RET232NUT-FHS & RET232NUT-HHS ONLY -11-
Résumé du contenu de la page N° 13
XIII. WIRING DIAGRAM MODELS RET232EUT-FHS & RET232EUT-HHS ONLY -12-
Résumé du contenu de la page N° 14
XIV. WARRANTY INFORMATION STANDARD DOMESTIC WARRANTY TRAULSEN & CO., INC. warrants new equipment to the original purchaser, when installed within the United States against defective material and workmanship for one (1) year from the date of original installation. Under this warranty, TRAULSEN & CO., INC. will repair or replace, at its option, including service and labor, all parts found to be defective and subject to this warranty. The compressor part is warranted for an additional four (4) year
Résumé du contenu de la page N° 15
XV. INDEX A M Mullion Air Ducts 6 B Batch Loading 4 N Blower Switch 4 O C Operational Troubleshooting 7 Call Service Light 6 Cleaning 5 - 6 P Casters 2 Power Supply 3 Cord & Plug 3 Process Loading 4 Clearance 3 Product Mix - Issues 6 Condenser, Cleaning The 4 R D Refrigerations System 3 Return Authorization 2 E Even-Thaw Operation 3 S Evaporator Outlet 6 Serial Tag 1 Extended Thaw Times, Causes Of 6 Spare Parts List 9 F T Fan Switch 6 Temperature Scale Adjustment 4 Troubleshooting 6-7 G Tray Sli
Résumé du contenu de la page N° 16
HOURS OF OPERATION: Monday thru Friday 7:30 am - 4:30 pm CST Traulsen 4401 Blue Mound Road Fort Worth, TX 76106 Phone: (800) 825-8220 Fax-Svce: (817) 740-6757 Website: www.traulsen.com Quality Refrigeration © 2005 Traulsen - All Rights Reserved
