Résumé du contenu de la page N° 1
YCE FSVlOO and FSV200 Series
6 G
eneral Purpose Solenoid Valves
@
m
I
8
m
I
@
fx
8
a
03
fx
@
m
I
03
fx
@
m
03
m
I
03
m
I
@
fx
I
8
fx
I
@
a
fl OMEGg
Operator’ s Manual
h An OMEGA Technologies Compsny
Résumé du contenu de la page N° 2
Servicing USA and Canada: Call OMEGA Toll Free Canada USA One Omega Drive, Box 4047 976 Bergar Lava1 (Quebec) H7L 5Al Stamford, CT 06907-0047 Telephone: (514) 856-6928 Telephone: (203) 359-1660 FAX: (514) 856-6886 FAX: (203) 359-7700 Sales Service: l-800-826-6342 / l-800-TC-OMEGASM Customer Service: l-800-622-2378 / l-800-622-BESTSM Engineering Service: l-800-872-9436 / l-800-USA-WHENSM TELEX: 996404 EASYLINK: 62968934 CABLE OMEGA Servicing Europe: United Kingdom Sales and Distribution Center 25
Résumé du contenu de la page N° 3
Table of Contents FSVIOO I FSV200 Series General Purpose Solenoid Valve Page 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Chapter 1 Introduction 1 1 . 1 Unpack ing .................................................................................................................. 1 1.2 Desc ri p ti on ......................
Résumé du contenu de la page N° 4
Notes
Résumé du contenu de la page N° 5
Chapter 1 Introduction 1 .l Unpacking Remove the Packing List and verify that you have received all equipment, including the follow- ing (quantities in parentheses): General Purpose Solenoid Valve (1) Operators Manual (1) ’ If you have any questions about the shipment, please call OMEGA Customer Service Depart- ment. When you receive the shipment, inspect the container and equipment for signs of dam- age. Note any evidence of rough handling in transit. Immediately report any damage to the shippi
Résumé du contenu de la page N° 6
1.3 Features The FSVlOOlFSV200 solenoid valves have the following features: ??2-way Normally Closed ?? Pilot-Operated ??Piston-Type ??Bronze Construction ??Variety of Voltages ??Maximum Temperature of 195°F ??Maximum Pressure 150 PSI 1.4 Available Models OMEGA Engineering, Inc. has the following models with the following characteristics: FSVI 00 Series for Water Description Part Number * FSVI 01 Solenoid Valve with BUNA N/EPDM Seal and 318” NPT Connector FSV102 Solenoid Valve with BUNA N/EPDM Se
Résumé du contenu de la page N° 7
FSV200 Series for Light Oils and Solvents DescriDtion Part Number * FSV201 Solenoid Valve with Viton Seal and 3/8” NPT Connector FSV202 Solenoid Valve with Viton Seal and 112 ” NPT Connector FSV203 Solenoid Valve with Viton Seal and 3/4” NPT Connector FSV204 Solenoid Valve with Viton Seal and 1 .O” NPT Connector FSV205 Solenoid Valve with Viton Seal and 1.25 ” NPT Connector FSV206 Solenoid Valve with Viton Seal and 1.50 ” NPT Connector FSV207 Solenoid Valve with Viton Seal and 2.00 ” NPT Connect
Résumé du contenu de la page N° 8
Solenoid Valve Chapter 2 Parts of the FSVlOO/200 Series PLUNGER ASSEMBLY PISTON SPRING SPLtT RING (TEFLON, PISTON BODY SEAT WASHER NUT Figure 2-1. 310”, l/2”, 314” NPT SOLENOID SPRING WAS HER --SOLENOID BONNET BOHET G PLUNGER ASSEMBLY PISTON SPRING SPLIT RING (TEFLON) -PISTON BODY Figure 2-2. I”, I%“, lYz”, 2” NPT Chapter 3 Installation Be sure to adhere to the following when installing your solenoid valve: Arrow on valve body indicates direction of flow. Apply wrench only on end of valve bein
Résumé du contenu de la page N° 9
Chapter 4 Troubleshooting Guide Problem Possible Cause Corrective Action Failure to open when 1. Low voltage at solenoid Insure proper voltage at (below 85% of rated solenoid solenoid engergized voltage) Check for excessive Solenoid failure 2. voltage at solenoid Replace split rings 3. Worn rings 4. Pressure drop less Increase pressure differential to 5 PSI than 5 PSI Install new bonnet 5. Bonnet bent 6. Should have approx- Trim as required imately 1 /I 6” gap in split piston rings. Remove pisto
Résumé du contenu de la page N° 10
Chapter 5 Spare Parts List Coil with l/2” NPT Conduit outlet and 30” lead wires. Fits all valve sizes. Consult Factory for other voltages and coils with ground wire. 3/8”*1/2”*3/&1”~1 W’*l x”92” NPT Connector Stvles FSVI 00 7319503 7319503 7319503 7319503 73026 83192 83192 83192 N/A 82224 82224 82224 Teflon Split Piston Ring 1 85Oi9Oi (2 Req’ d) , Piston Seat Washer 8249801 84048 84571 84518 8222301 Piston Seat Washer Nut 1 8222 2 86030 76745 76750 7673801 FSVZOO I Same Parts as FSVIOO Except Fo
Résumé du contenu de la page N° 11
Chapter 6 Specifications FSVI OO/FSVZOO Series IT---- f’k I I i-t I 0 0 ri F r-- C --- + Figure 6-2. 1”, 1?4”, I%“, CL 2” Figure 6-i. 3/W ’, 112”, 8 314” FSVlOO: For fluids compatible with bronze, 430 F Stainless Steel, Ethylene Propylene, and Teflon 'I l-114" l-112" 2" pe i P Size 318” l/2" 314” 1 r otCv c Fa 3. 2 3. 3 5. 7 8. 9 15 28 39 si Th . 60 F t op a r e d r essu r p I PS h a 1 it w ve l he va t ough r ht ow ill flwt ha r tet wa f o t ounm The a r) ot c v Fa C : (et No r of d be used l
Résumé du contenu de la page N° 12
Specifications (con?) Flow Capacity Charts 450 100 90 400 80 350 70 300 E E 6o k 250 g 5 0 .E 20 0 175 .E 4 0 3 0 15 0 h. 30 E 125 IA 100 20 ;i 10 5 :8 0 0- 5 10 20 30 40 60 80 100 125 150 5 IO 20 30 40 60 SO 100 125 150 Pressure Drop Across the Valve in PSI Pressure Drop Across the Valve in PSI Figure 64. l”, I%“, I%“, 2” NPT Figure 6-3. 3/W’, l/2”, 314” NPT * Valves require minimum 5 PSI pressure differential for reliable operation. * Must be installed in horizontal piping with solenoid in ver
Résumé du contenu de la page N° 13
Notes
Résumé du contenu de la page N° 14
WARRANTY OMEGA warrants this unit to be free of defects in materials and workmanship and to give satisfac- tory service for a period of 13 months from date of purchase. OMEGA Warranty adds an addition- al one (1) month grace period to the normal one (1) year product warranty to cover handling and shipping time. This ensures that OMEGA ’ s customers receive maximum coverage on each product. If the unit should malfunction, it must be returned to the factory for evaluation. OMEGA ’ s Customer Serv
Résumé du contenu de la page N° 15
Where Do I Find Everything I Need for Process Measurement and Control? OMEGA...Of Course! TEMPERATURE Thermocouple, RTD & Thermistor Probes, Connectors, Panels & Assemblies D Wire: Thermocouple, RTD & Thermistor a I Calibrators & Ice Point References Recorders, Controllers & Process Monitors E Infrared Pyrometers a l PRESSURE/STRAIN FORCE B Transducers & Strain Gages m Load Cells & Pressure Gauges m Displacement Transducers @ Instrumentation & Accessories FLOW/ LEVEL m Rotameters, Gas Mass Flowm
Résumé du contenu de la page N° 16
