Résumé du contenu de la page N° 1
Operator's Manual for
MODELS: KKW32132
KKW36132
KKH36132
KKW48152
KKH32132
KKH36152
KKH48152
Professional Quality Lawn Care Equipment
since 1945
Yazoo/Kees Power Equipment policy is to improve its products whenever it is
possible and practical to do so. In an effort to keep pace with changes in technology,
Yazoo/Kees reserves the right to make changes or improvements at any time without
incurring any obligation to make such changes on products previously manufactured.
MANUAL 106474 RE
Résumé du contenu de la page N° 2
INTRODUCTION INTRODUCTION INTRODUCTION INTRODUCTION INTRODUCTION TABLE OF CONTENTS TABLE OF CONTENTS TABLE OF CONTENTS TABLE OF CONTENTS TABLE OF CONTENTS This manual has been prepared for the operators of the YAZOO/KEES KUTTER 32", 36" and 48" commercial mowers. Read, understand, and follow the safety and operating instructions. SAFETY : SAFETY : SAFETY : SAFETY : SAFETY : Training Always stop the engine and blades, place the traction levers in drive, and place the mower in gear when Preparat
Résumé du contenu de la page N° 3
SAFETY WARNING: Failure to comply with the following WARNING: Failure to comply with the following WARNING: Failure to comply with the following WARNING: Failure to comply with the following WARNING: Failure to comply with the following 7. Mow only in daylight or good artificial light. instructions may result in serious injury to the instructions may result in serious injury to the instructions may result in serious injury to the instructions may result in serious injury to the instructions may
Résumé du contenu de la page N° 4
SETUP AND ADJUSTMENTS FOR SETUP AND ADJUSTMENTS FOR SETUP AND ADJUSTMENTS FOR SETUP AND ADJUSTMENTS FOR SETUP AND ADJUSTMENTS FOR YAZOO/KEES KUTTER 32", 36" AND 48" COMMERCIAL MOWERS YAZOO/KEES KUTTER 32", 36" AND 48" COMMERCIAL MOWERS YAZOO/KEES KUTTER 32", 36" AND 48" COMMERCIAL MOWERS YAZOO/KEES KUTTER 32", 36" AND 48" COMMERCIAL MOWERS YAZOO/KEES KUTTER 32", 36" AND 48" COMMERCIAL MOWERS FRONT CASTER WHEELS FRONT CASTER WHEELS FRONT CASTER WHEELS THROTTLE INSTALLATION THROTTLE INSTALLATION F
Résumé du contenu de la page N° 5
REAR AXLE HEIGHT ADJUSTMENT REAR AXLE HEIGHT ADJUSTMENT REAR AXLE HEIGHT ADJUSTMENT REAR AXLE HEIGHT ADJUSTMENT REAR AXLE HEIGHT ADJUSTMENT AXLE PIVOT BOLTS AXLE ADJUSTMENT BOLTS POSITION A PLACE JACK HERE POSITION B POSITION C LOOSEN BOLTS EACH SIDE POSITION D Figure 1 CASTER HEIGHT ADJUSTMENT CASTER HEIGHT ADJUSTMENT CASTER HEIGHT ADJUSTMENT CASTER HEIGHT ADJUSTMENT CASTER HEIGHT ADJUSTMENT MACHINERY BUSHING 1/2" SPACERS CASTER SWIVEL Figure 2 5
Résumé du contenu de la page N° 6
SETUP AND ADJUSTMENTS FOR SETUP AND ADJUSTMENTS FOR SETUP AND ADJUSTMENTS FOR SETUP AND ADJUSTMENTS FOR SETUP AND ADJUSTMENTS FOR YAZOO/KEES KUTTER 32", 36" AND 48" COMMERCIAL MOWERS YAZOO/KEES KUTTER 32", 36" AND 48" COMMERCIAL MOWERS YAZOO/KEES KUTTER 32", 36" AND 48" COMMERCIAL MOWERS YAZOO/KEES KUTTER 32", 36" AND 48" COMMERCIAL MOWERS YAZOO/KEES KUTTER 32", 36" AND 48" COMMERCIAL MOWERS CUTTING HEIGHT ADJUSTMENT CHART CUTTING HEIGHT ADJUSTMENT CHART CUTTING HEIGHT ADJUSTMENT CHART CUTTING H
Résumé du contenu de la page N° 7
SETUP AND ADJUSTMENTS FOR SETUP AND ADJUSTMENTS FOR SETUP AND ADJUSTMENTS FOR SETUP AND ADJUSTMENTS FOR SETUP AND ADJUSTMENTS FOR YAZOO/KEES KUTTER 32", 36" AND 48" COMMERCIAL MOWERS YAZOO/KEES KUTTER 32", 36" AND 48" COMMERCIAL MOWERS YAZOO/KEES KUTTER 32", 36" AND 48" COMMERCIAL MOWERS YAZOO/KEES KUTTER 32", 36" AND 48" COMMERCIAL MOWERS YAZOO/KEES KUTTER 32", 36" AND 48" COMMERCIAL MOWERS BRAKE / TRACTION ADJUSMENT BRAKE / TRACTION ADJUSMENT BRAKE / TRACTION ADJUSMENT BRAKE / TRACTION ADJUSME
Résumé du contenu de la page N° 8
SETUP AND ADJUSTMENTS FOR SETUP AND ADJUSTMENTS FOR SETUP AND ADJUSTMENTS FOR SETUP AND ADJUSTMENTS FOR SETUP AND ADJUSTMENTS FOR YAZOO/KEES KUTTER 32", 36" AND 48" COMMERCIAL MOWERS YAZOO/KEES KUTTER 32", 36" AND 48" COMMERCIAL MOWERS YAZOO/KEES KUTTER 32", 36" AND 48" COMMERCIAL MOWERS YAZOO/KEES KUTTER 32", 36" AND 48" COMMERCIAL MOWERS YAZOO/KEES KUTTER 32", 36" AND 48" COMMERCIAL MOWERS TRANSMISSION DRIVE BELT TRANSMISSION DRIVE BELT TRANSMISSION DRIVE BELT TRANSMISSION DRIVE BELT TRANSMISS
Résumé du contenu de la page N° 9
OPERATING INSTRUCTIONS OPERATING INSTRUCTIONS OPERATING INSTRUCTIONS OPERATING INSTRUCTIONS OPERATING INSTRUCTIONS BEFORE OPERATING BEFORE OPERATING BEFORE OPERATING BEFORE OPERATING BEFORE OPERATING PRE-START CHECKLIST PRE-START CHECKLIST PRE-START CHECKLIST PRE-START CHECKLIST PRE-START CHECKLIST Be thoroughly familiar with all controls and how to use Make the following checks and perform the services as them before operating the mower. Know beforehand required before each start up. how to st
Résumé du contenu de la page N° 10
OPERATING INSTRUCTIONS OPERATING INSTRUCTIONS OPERATING INSTRUCTIONS OPERATING INSTRUCTIONS OPERATING INSTRUCTIONS 6. Pull starter rope until engine starts. 7. Warm engine momentarily, then move the throttle control out of the choke position until engine runs smoothly, approximately 1/2 throttle. Engage the blades and set the desired rpm. The best cutting and bagging is obtained with engine at or near top rpm. NOTE: DO NOT engage the blades at full rpm. To NOTE: DO NOT engage the blades at
Résumé du contenu de la page N° 11
SERVICE SERVICE SERVICE SERVICE SERVICE SERVICE ASSISTANCE - SERVICE ASSISTANCE - SERVICE ASSISTANCE - SERVICE ASSISTANCE - SERVICE ASSISTANCE - REPLACEMENT PARTS REPLACEMENT PARTS REPLACEMENT PARTS REPLACEMENT PARTS REPLACEMENT PARTS CAUTION CAUTION CAUTION CAUTION CAUTION To retain the quality of your mower, use genuine YAZOO/ DO NOT BY-PASS THE INTERLOCK SWITCHES DO NOT BY-PASS THE INTERLOCK SWITCHES DO NOT BY-PASS THE INTERLOCK SWITCHES DO NOT BY-PASS THE INTERLOCK SWITCHES DO NOT BY-PASS TH
Résumé du contenu de la page N° 12
SERVICE SERVICE SERVICE SERVICE SERVICE CUTTER HOUSING SPINDLE ASSEMBLYS CUTTER HOUSING SPINDLE ASSEMBLYS CUTTER HOUSING SPINDLE ASSEMBLYS CUTTER HOUSING SPINDLE ASSEMBLYS CUTTER HOUSING SPINDLE ASSEMBLYS The cutter housing assembly is designed with a slip fit Cutter housing assemblys use sealed bearings and inner race and pulley. The sole purpose of the setscrew are maintance free. in the pulley is to hold the housing assembly together. The setscrew is not ment to secure the pulley. The pulle
Résumé du contenu de la page N° 13
SERVICE SERVICE SERVICE SERVICE SERVICE AUXILARY BELT REPLACEMENT AUXILARY BELT REPLACEMENT WHEEL DRIVE BELT REPLACEMENT WHEEL DRIVE BELT REPLACEMENT WHEEL DRIVE BELT REPLACEMENT WHEEL DRIVE BELT REPLACEMENT WHEEL DRIVE BELT REPLACEMENT AUXILARY BELT REPLACEMENT AUXILARY BELT REPLACEMENT AUXILARY BELT REPLACEMENT (48" MOWERS) (48" MOWERS) WHEEL DRIVE BELT: If belts are worn or damaged, (48" MOWERS) (48" MOWERS) (48" MOWERS) wheels will not drive properly. To replace either belt, proceed as follo
Résumé du contenu de la page N° 14
MAINTENANCE CHART MAINTENANCE CHART MAINTENANCE CHART MAINTENANCE CHART MAINTENANCE CHART ITEM ITEM ITEM ITEM ITEM FREQUENCY FREQUENCY FREQUENCY FREQUENCY FREQUENCY REQUIRED SERVICE REQUIRED SERVICE REQUIRED SERVICE REQUIRED SERVICE REQUIRED SERVICE REAR TIRES BEFORE EACH MOWING INFLATE TO PROPER PRESSURE FRONT TIRES BEFORE EACH MOWING INFLATE TO PROPER UNDERSIDE OF MOWING DECK AFTER EACH MOWING PRESSURE MOWER DECK DAILY REMOVE GRASS & DEBRIS INSPECT FOR CRACKS/LOOSE UNDERSIDE OF REAR DECK AFTER
Résumé du contenu de la page N° 15
15
Résumé du contenu de la page N° 16
