Résumé du contenu de la page N° 1
N
Model Numbers 465611003 and 465621303
Owner’s Manual
Assembly, Operation,
Use and Care
Read and follow all safety
WARNING
statements, assembly
instructions, and use and
Failure to follow all manufacturer’s instructions could
care directions before
result in fire or explosion which could cause property
attempting to assemble
damage, personal injury or death.
and cook.
Installer/assembler:
Leave these instructions
with consumer.
CAUTION
Consumer: Keep this
Some parts may contain sharp edges – es
Résumé du contenu de la page N° 2
WARNING FOR YOUR SAFETY 1. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. 2. An LP tank not connected for use shall not be stored in the vicinity of this or any other appliance. FOR YOUR SAFETY If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. Open lid. 4. If odor continues, immediately call your gas supplier or your fire department. Safety Symbols The symbols and boxes shown below explain what
Résumé du contenu de la page N° 3
LP (Liquefied Petroleum Gas) Is nontoxic, odorless and colorless when produced. For Your Safety, LP gas has been given an odor (similar to rotten cabbage) so that it can be smelled. LP gas is highly flammable and may ignite unexpectedly when mixed with air. CAUTION For residential use only. Do not use for commercial cooking. Call Grill Service Center for Help and Parts If you need help or warranty parts call 1-800-241-7548 U.S., 1-800-387-6057 CAN, or send a FAX to 1-706-576-6355. Business
Résumé du contenu de la page N° 4
Warranty Thermos warrants to the original consumer-purchaser that this product shall be free from defects in workmanship and materials under normal and reasonable use and correct assembly (If assembled by consumer-purchaser) as follows: (1) The aluminized top and bottom for a period of three (3) years from date of purchase; excluding the paint finish; (2) The burner/venturi assembly for a period of three (3) years from date of purchase; (3) All other parts, for a period of one (1) year from date
Résumé du contenu de la page N° 5
Table of Contents For Your Safety.............................................................2 Safety Symbols LP (Liquefied Petroleum Gas).................................................3 Grill Service Center Installation Safety Precautions Warranty Information Warranty ..................................................................4 Table of Contents...........................................................5 Parts Lists and Diagrams .................................................6–8 Ass
Résumé du contenu de la page N° 6
Parts List and Diagram – Grill Lid 10 F A B 6 11 G 1 3 D 9 15 7 16 8 2 5 4 14 C E 13 12 Key Qty. Description Part No. Key Qty. Description Part No. A 1 Lid 65-6047-063-204 1 1 Coach Bolt 41-9000-570-000 B 2 Upper Hinge 65-6047-093-200 2 2 Coach Bolt 41-9000-589-000 C 1 Handle Assembly 69-6047-057-200 3 1 Washer 42-9000-390-000 D 1 Upper Latch 65-6047-096-200 4 3 Spring Washer 42-9000-381-000 E 1 Heat Shield 21-6047-082-200 5 3 Nut 43-9000-034-000 F 1 Torsion Bar 65-6047-110-200 6 4 Spring Washer
Résumé du contenu de la page N° 7
Parts List and Diagram – Grill Bottom and Burner System I 21 20 J K L W M N 19 G 18 X H 17 Q Z 22 V O 23 AA S T U P Y R Key Qty. Description Part No. Key Qty. Description Part No. G 1 Ignitor Wire 69-6047-332-200 V 1 Regulator/Valve 69-6047-031-200 H 1 Regulator Lock 69-6047-340-200 W 1 Side Shelf - Left 69-6047-008-200 I 1 Grate 65-6047-339-200 X 1 Side Shelf - Right 69-6047-009-200 J 1 Collector Box 21-6047-338-200 Y 1 Latch Clasp 11-6047-012-200 K 1 Burner 69-6047-029-200 Z 1 Venturi Guard 21
Résumé du contenu de la page N° 8
Parts List and Diagram – Plinth and Legs 27 HH 35 25 CC 29 26 BB 30 32 28 31 24 34 33 II DD EE GG Key Qty. Description Part No. Key Qty. Description Part No. BB 1 Plinth 64-6047-359-203 24 4 Leg Fasteners 11-6047-033-200 CC 1 Leg - Left 11-6047-036-201 25 4 Stand Offs 13-6047-026-200 DD 1 Leg - Right 11-6047-037-201 26 4 Coach Bolt Bracket 21-6047-021-000 EE 1 Leg Latch 21-6047-394-200 27 1 Stopper/Left Rear 22-6047-102-200 GG 4 Leveling Blocks 11-6047-065-200 28 1 Stopper/Left Front 22-6047-103
Résumé du contenu de la page N° 9
Assembly Your grill will require minimal assembly. The Grill2Go™ is packaged in three major components. Additional parts are stored beneath grill lid. Remove all protective packaging and product information cards before assembly. Spacer Grill Plinth NOTE: The rubber spacers on the grill lid help to protect the non-stick cooking surface and should not be removed. Legs Graphics in front Plinth is designed to fit into slots at each corner of legs. Plinth will only fit into legs correctly and easily
Résumé du contenu de la page N° 10
Coach bolts pass completely through holes in plinth and legs. Washer Plastic Fastener NOTE: Use square hole, not round hole, when NOTE: Do not fully tighten assembling plinth fasteners at this time. to legs. Fully unfold legs to position shown above and hand-tighten the four plastic fasteners. 10 Grill2Go
Résumé du contenu de la page N° 11
Grill fits firmly onto plinth. Tab on grill bottom snaps under front Grease container slides lip of plinth. onto slot on left side of plinth. Cap should be open when installing. Ignitor on grill bottom fits into slot in plinth. A Attach 1 lb. LP cylinder to regulator by twisting clockwise. NOTE: 1 lb. LP cylinder sold separately. B Connect regulator to burner on right side of grill. Slide regulator lock to right to insert regulator. Regulator should rest firmly against burner. Regulator lock sho
Résumé du contenu de la page N° 12
Insert shelf rods into holes in sides of grill bottom. Shelf with valve cutout attaches to right side of grill. WARNING Combustion by-products produced when using this product contain chemicals known to the State of California to cause cancer, birth defects, and other reproductive harm. 12 Grill2Go
Résumé du contenu de la page N° 13
Your Grill2Go™ can be used with the legs fully extended or folded beneath the grill. To use grill on a table-top, fully loosen plastic fasteners (A), fold legs inward until they latch together (B), then hand-tighten the fasteners to secure legs in the closed position (C). A Turn Counterclockwise B Fold Fold right Second leg first C Turn Clockwise Grill2Go 13
Résumé du contenu de la page N° 14
Use and Care Propane Cylinder Use (1 lb. Disposable) Use only cylinder marked “Propane Fuel”. Size should be 4” diameter, 8” height, or 3” diameter, 10” height. Save cylinder cap and reinstall when not in use. Cylinder supply system must be arranged for vapor withdrawal. Gas cylinder must be upright in use. WARNING Use only 1 lb. propane bottles as specified above. Use of other gas bottles could cause gas leak or fire. Leak Testing (1 lb. Disposable) IMPORTANT! During leak test, keep g
Résumé du contenu de la page N° 15
Propane Cylinder Use (20 lb. Refillable) The 20 lb. LP tank used with your grill must meet the following requirements: Purchase LP tanks only with these required measurements:12" (30.5cm) (diameter) x 18" (45.7 cm) (tall) with 20 lb. (9 kg.) capacity maximum. Tank must be constructed and marked in accordance with specifications for LP tank of the U.S. Department of Transportation (DOT) or for Canada, CAN/CSA B-339, cylinders, spheres, and tubes for transportation of dangerous goods, Transpor
Résumé du contenu de la page N° 16
Leak Testing (20 lb. Refillable) IMPORTANT! For your safety Leak test must be repeated each time LP tank is exchanged or refilled. Do not smoke during leak test. Do not use an open flame to check for gas leaks. Grill must be leak checked outdoors in well-ventilated area, away from ignition sources such as gas fired or electrical appliances. During leak test, keep grill away from open flames or sparks. Use a clean paint brush and 50/50 soap and water solution. Use mild soap and water. D
Résumé du contenu de la page N° 17
Straight Connecting The Adapter Hose To The LP Tank (continued) 5. Hold hose end, insert nipple (A) into LP tank valve. Hand tighten coupling nut, holding connector in a straight line (B) with LP tank valve so as not to cross thread the connection. Nipple must be centered into the LP tank valve. B A Coupling nut Position coupling nut and hose-end as shown for proper connection to LP tank valve. 6. Turn the coupling nut clockwise to tighten to a full solid stop. The hose-end will seal on the back
Résumé du contenu de la page N° 18
WARNING Do not use grill until leak checked. If leak is detected at any time, STOP and call the Fire Department. If you cannot stop a gas leak, immediately close LP tank valve and call LP gas supplier or your fire department! Leak Testing Valves, Hoses and Regulator 1. Turn grill control knob to off. 2. Be sure connector is tightly connected to LP tank. 3. Completely open LP tank valve by turning hand wheel counter clockwise. If you hear a rushing sound, turn gas off immediately. There is
Résumé du contenu de la page N° 19
WARNING For Safe Use Of Your Grill: Do not leave the appliance unattended. Keep children and pets A away from the appliance at all times. 3 ft. (1m) minimum Never use regulator from this grill 10 ft. recommended with any other LP appliance. When cooking, the appliance must be on a level surface in an area clear of combustible material. Do not block holes in bottom or back of grill. Check burner flames regularly. Use grill only in well-ventilated space. NEVER use in enclosed space suc
Résumé du contenu de la page N° 20
Safety Tips The use of alcohol, prescription or nonprescription drugs may impair the consumer’s ability to properly assemble or safely operate the appliance. When grill is not in use, disconnect 1 lb. cylinder or turn off 20 lb. cylinder. Never move grill while in operation or still hot. Allow the appliance to cool before moving or storing. Use only tools supplied or plastic tools. Maximum load for side shelf is 10 lbs. The regulator may make a humming or whistling noise during opera
