Résumé du contenu de la page N° 1
N
Product Guide
Model 4611118
IMPORTANT: Fill out the product record information below.
Serial Number
See rating label on grill for serial number.
Date Purchased
For support and to register your
grill, please visit us at
www.charbroil.com
If you have questions or need
assistance during assembly,
please call 1-800-241-7548.
Estimated assembly time: 30 minutes
This product is manufactured by Char-Broil, LLC, a division of the W. C. Bradley Company under the terms of a license agreement grante
Résumé du contenu de la page N° 2
TABLE OF CONTENTS DANGER Product Record Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 1. Never operate this appliance unattended. Safety Symbols. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 2. Never operate this appliance within 10ft (3m) of Installation Safety Precautions . . . . . . . . . . . . . . . . . . . . . . . . . . 3 any structure, combustible material or other gas Use and Care . . . . . . . . . . . . . . . . . . . . . . . . . . .
Résumé du contenu de la page N° 3
Installation Safety Precautions USE AND CARE • Use grill, as purchased, only with LP (propane) gas and the regulator/valve assembly supplied. • Grill installation must conform with local codes, or in their WARNING absence of local codes, with either the National Fuel Gas Code, ANSI Z223.1/ NFPA 54. Storage and handling of For Safe Use of Your Grill and to Avoid Serious liquefied petroleum gasses must conform to LP Gas Code Injury: ANSI / NFPA 58. Grill is not for use in or on recreationa
Résumé du contenu de la page N° 4
LP (Liquefied Petroleum Gas) Propane Cylinder Installation/Removal • Is nontoxic, odorless and colorless when produced. For Your Propane Cylinder Installation: Safety, LP gas has been given an odor (similar to rotten cabbage) so that it can be smelled. 1. Remove cap from end of Propane cylinder (sold separately). • LP gas is highly flammable and may ignite unexpectedly 2. Cap should be kept on cylinder when not in use to prevent dirt when mixed with air. and debris from entering Regulator/Valve
Résumé du contenu de la page N° 5
Lighting Instructions Important! Remove or raise lid to open position. CAUTION Attempting to light burner with lid closed may cause an explosion. Do not expose any part of your body or clothing directly above cooking area when lighting. SPIDER ALERT! 1. From beneath the grill, place lighted wooden match up through lighter/ventilation hole in center of bottom. 2. While holding match in place, turn control knob to lighting position. Grill will ignite. 3. Observe burner flames
Résumé du contenu de la page N° 6
Grill Maintenance CAUTION - Allow grill to cool before cleaning. Frequency of cleaning is determined by how often grill is used. • Putting out grease fires by closing the lid is not possible. Grills are well ventilated for safety reasons. - DO NOT use self-cleaning oven to clean any grill part. • Do not use water on a grease fire. Personal injury may Extreme heat would remove any chrome plating and cause result. If a grease fire develops, turn knobs and LP premature rusting. cylinde
Résumé du contenu de la page N° 7
LIMITED WARRANTY This warranty only applies to units purchased from an authorized retailer. Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated below beginning on the date of manufacture*. The manufacturer reserves the right to require that defective parts be returned, postage and or freight pre-paid by the consumer for
Résumé du contenu de la page N° 8
Parts List Key Qty Description Part # A 1 Lid Handle . . . . . . . . . . . . . . . . . . . . . G102-0001-9031 B 1 Lid . . . . . . . . . . . . . . . . . . . . . . . . . . . G102-0002-0031 C 2 Hinge Brackets . . . . . . . .. . . . . . . . . . G102-0003-0031 D 1 Cooking Grate . . . . . . . . . . . . . . . . . . G102-0004-9181 E 1 Heat Distribution Plate . . . . . . . . . . . G102-0005-0000 F 1 Burner . . . . . . . . . . . . . . . . . . . . . . . . G102-0100-0000 G 1 Heat Resistant Shield . . . .
Résumé du contenu de la page N° 9
Assembly 1 BURNER (F) - Position Heat Shield (G) as shown at right below and place into Bottom (H). HEAT RESISTANT SHIELD (G) - Insert narrow end of Burner (F) through large hole in side of Bottom (H) and rest burner bracket on Shield (G). - Insert one 1/4-20 x 3/8” Screw (M) through Bottom (H), Shield (G) and into burner bracket. BOTTOM (H) CAUTION Some parts may contain sharp edges! Wear protective gloves if necessary. 1/4-20 x 3/8” SCREW (M) 2 - Position Legs (K) as shown at
Résumé du contenu de la page N° 10
Assembly (Con’t.) 3 #10-24 x 3/4” SCREW (O) HEAT DISTRIBUTION PLATE (E) - Assemble Side Handles (I) to Bottom (H) using two each #10-24 x 3/4” Screws (O), Fiber Washers (L) and #10-24 Flange Nuts (N) SIDE HANDLE (I) per Handle (I). - Rest the notches on ends of Heat Distribution Plate (E) on Side Handles Screws (O) inside Bottom (H). PLEASE NOTE: This table top propane gas grill has been designed to work effectively without the use of lava rocks. The reflective heat FIBER WASH
Résumé du contenu de la page N° 11
Assembly (Con’t.) 5 - Before assembly, inspect Regulator (J) for damage, dirt or debris accumulation. Clean out if present. - With knob pointing down, insert Regulator/Valve (J) into end of Burner (F). Notch in Regulator/Valve (J) MUST engage dimple in end of Rotate clockwise to lock Burner (F). - Once Regulator/Valve (J) has completely engaged Burner (F), turn Regulator/Valve (J) clockwise to lock in position with knob pointing up. Regulator/Valve (J) Regulator/
Résumé du contenu de la page N° 12
EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department. Troubleshooting Prevention/Solution is turned on. Problem Possible Cause • Replace Cylinder. Burner will not Light. • Out of Propane • Retighten cylinder. • Regulator not fully tightened to cylinder. • Inspect burner for obstructions. • See ‘Care and Use’ for burner cleaning instructions. • See ‘Care and Use’ section “Before Cooking For The First Time’. Flames burns out on • Grill not suf
Résumé du contenu de la page N° 13
13
Résumé du contenu de la page N° 14
14
Résumé du contenu de la page N° 15
NOTES 15
Résumé du contenu de la page N° 16
P.O. Box 1240 Columbus, GA. 31902–1240 Printed in China
