Resumen del contenido incluido en la página 1
OPERATING INSTRUCTIONS
AND OWNER’S MANUAL
Model # 35-R
READ INSTRUCTIONS CAREFULLY: Read and follow all instructions. Place instructions in a safe
place for future reference. Do not allow anyone who has not read these instructions to assemble,
light, adjust or operate the heater.
GAS-FIRED INFRA-RED
PORT ABLE CONSTRUCTION HEA TER
DO NOT LEA VE HEA TER UNA TTENDED OR IN OPERA TION WHILE SLEEPING
CYLINDER NOT INCLUDED
GENERAL HAZARD WARNING:
F AILURE TO COMPL Y WITH THE PRECAUTIONS AND INSTRUCTION
Resumen del contenido incluido en la página 2
SPECIFICATIONS VENTILATION MODEL NO. ............ 35-R WARNING GAS TYPE ......... LP-Gas MAX. INLET THIS APPLIANCE IS UNVENTED AND MUST BE PRESSURE. ......... 22 in. w.c. USED ONLY IN A WELL VENTILATED AREA. MIN. INLET PRESSURE .......... 22 in. w.c. The flow of combustion and ventilation air must not be MANIFOLD obstructed. DO NOT use in a tightly enclosed area. Any PRESSURE .......... 21 in. w.c. combustion process requires and consumes oxygen, and may produce carbon monoxide. This heater must
Resumen del contenido incluido en la página 3
The minimum ambient temperature rating for this heater is GENERAL INFORMATION 20 degrees F. A. Your 35-R portable gas-fired infra-red heater comes This heater incorporates a “Tip Over” switch which fully assembled and is tested at the factory for proper automatically shuts off the burner in the event of tipping. gas and input as stated on the nameplate. Ensure that this switch is in the vertical position and is B. Each heater is equipped with a 100% safety shutoff, secured with the screws provid
Resumen del contenido incluido en la página 4
ODOR FADE WARNING WARNING heater dataplate, or contact the Scheu Products Company to determine combustion air ventilation requirements of the Asphyxiation Hazard heater. • Do not use this heater for heating human living quarters. • Lack of proper ventilation air will lead to improper • Do not use in unventilated areas. combustion. • The flow of combustion and ventilation air must not be • Improper combustion can lead to carbon monoxide obstructed. poisoning leading to serious injury or death. Sy
Resumen del contenido incluido en la página 5
The connection of Model 35-R to an LP-Gas cylinder must CAUTION be made in a well ventilated area using the regulator and hose assembly supplied with the appliance. DO NOT DO NOT PLACE CLOTHING OR attempt to adjust this regulator. It has been preset at the OTHER COMBUSTIBLE factory to provide safe and proper operation of the ATERIALS ON THIS APPLIANCE. appliance. Use a 7/8” open end wrench to connect the POL fitting (supplied with the LP regulator) to the LP-Gas cylinder. Turn the POL nut in a c
Resumen del contenido incluido en la página 6
• Clean the orifice of each burner with a #55 drill bit (for LP-Gas). NOTE: In cases where long runs of gas supply lineshave been installed ahead of the appliance, it may be necessary • Clean the thermocouple lead. to bleed trapped air out of the supply lines before lighting DO NOT operate this heater if any part has been under the burner. New installations generally require bleeding of water. Call a qualified service person to inspect the appliance supply lines. Wait a minimum of five minutes a
Resumen del contenido incluido en la página 7
Tip Over Switch Magnetic Portion of Control Thermocouple Tip Over Switch Adaptor Leads Leads Control Junction Block Adaptor Kit Heater Bottom Figure 4 REPLACEMENT PARTS LIST Tip-Over Switch Arrangement NOTE: The purpose of the tip-over Switch is to stop the flow REF. # ...... ITEM# DESCRIPTION of gas when heater is accidentally knocked over. When and 1 ............. 00333 ........ CONT M-N SS PORT 3/8MPXI/4MP if the heater is knocked over, simply stand heater up. 2 ............. 02455 ........B
Resumen del contenido incluido en la página 8
Gas-Fired Infra-Red Portable Construction Heater • Model # 35-R 13 3 2 9 4 5 12 8 10 1 11 14 6 7 IF SERVICE IS REQUIRED PLEASE DO NOT RETURN THIS APPLIANCE TO YOUR STORE For information regarding service, please call our Toll-Free Number: 1-888-619-7060 Our office hours are 7:00 AM to 4:00 PM, CT Time Zone, Monday through Friday Please include the model number, date of purchase and description of problem in all communication. Operating Instructions and Owner’s Manual 8
Resumen del contenido incluido en la página 9
OPERATING INSTRUCTIONS AND OWNER’S MANUAL Model # 35-R WARNING: USE ONL Y MANUF ACTURER’S REPLACEMENT P AR TS. USE OF ANY OTHER P ARTS COULD CAUSE INJURY OR DEA TH. REPLACEMENT P ARTS ARE ONL Y A V AILABLE DIRECT FROM THE F ACTORY AND MUST BE INST ALLED BY A QUALIFIED SERVICE AGENCY . PARTS ORDERING INFORMATION: PURCHASING: Accessories may be purchased at any SCHEU PROUCTS CO. local dealer or direct from the factory FOR INFORMATION REGARDING SERVICE Please call Toll-Free 888-619-7060 E-Mail Addr
