Resumen del contenido incluido en la página 1
1260 E. VanDeinse, Greenville , MI 48838
Toll Free Phone 1-800-2 23-3900 Fax 1-616-754-9690
Installation and Operating Instructions For
Models:
5210 48" Gas Top / Electric Convection Self Clean Range
4210 30" Gas Top / Electric Convection Self Clean Range
ATTENTION INSTALLER: Leave this manual with appliance
Save these instructions
CERTIFIED CERTIFIED CERTIFIED
for future use
C US C US C US
NOTE: Clock must be
set or your main oven
will not function!
WARNING
Resumen del contenido incluido en la página 2
To move range for service or cleaning The use of a gas cooking appliance results in the production of heat and moisture in the room in which it is installed. Ensure that the kitchen is well ventilated: keep WARNING natural ventilation holes open or install a mechanical Range body rests on base. device (mechanical extractor hood). Prolonged intensive use of the appliance When moving, move by base may call for additional ventilation, for only. example opening of a window, or more 1. Disc
Resumen del contenido incluido en la página 3
Gas Top/Electric Convection Self Clean Models 4210/5210 CONSUMER WARRANTY ENTIRE PRODUCT – LIMITED ONE YEAR WARRANTY AGA MARVEL warrants the replacement or repair of all parts, of this appliance which prove to be defective in material date of original purchase. Such parts will be repaired or replaced at the option of Heartland without charge, subject to the terms and conditions set out below. date of original purchase. OVEN & WARMING DRAWER ELEMENTS
Resumen del contenido incluido en la página 4
TABLE OF CONTENTS Description ........... ....................................... Page Description ................................................... Page 1. Assembly and Installation ....................................... 1 30. Baking Cookin g Guide......................................... 23 2. Closet Assembly ...................................................2-4 31. Porcelain Care & Cleaning .................................. 24 3. Positioning the Range ......................
Resumen del contenido incluido en la página 5
Assembly and Installation To fully enjoy your new range, it is important that you read this booklet thoroughly. Note: shipping damage, inform your dealer immediately! Caution when unpacking: Lift the range by the bottom skirt, do not lift by nickel trim. Unpacking: Note: to avoid injury, please wear safety equipement, glasses and gloves, while you are unpacking your new range. 1) Unscrew the 12 screws that hold the crate onto the skid. There are 12 along the bottom and 4 along the top. 2) Af
Resumen del contenido incluido en la página 6
Sheet metal screw Steel washer Machine screw Bracket Gasket - Peel off backing and stick on. Sheet metaI Steel Washer Machine screw Gasket screw (black) (Nickel Plated) -Remember when working with the closet, the closet is top heavy . Use your hand to support it during installation. -With a helper,lift closet assembly from box by area that is circled.(See Fig.1 Page 2). -Rest the closet assembly on the carton,while your helper steadies the closet,peel the closet backing off the gask
Resumen del contenido incluido en la página 7
Deflector Back of cabinet Sheet metal 3 1/2" x 10" Exhaust adaptor screw If you are not venting outside, attach the deflector to the rear of cabinet with 4, sheet metal screws. If you are venting outside, attach the 3 1/2" x 10" exhaust adaptor with 4, sheet metal screws. Fasten your exhaust ducting to the adaptor. Small boxcontains: - hardware package - deflector - 3 1/2"x10 exhaust adapter Note: maximum run of ducting is 25 linear feet (subtract 5' per 90 deg elbow added to the exhaust
Resumen del contenido incluido en la página 8
CONNECTING POWER TO THE CABINET After your exhaust hood has been installed the very last thing to do is to connect the multipin plug to the range. The receptacle is located at the rear of the stove under the metal cover. Remove the screw securing the cover to the back of the range and remove the cover. Remove the cable clamp from the stove which is located just above the cover. 5210 4210 Back of Back of stove stove Metal cover Screw Exhaust Hood Recptacle Locations When installing the mult
Resumen del contenido incluido en la página 9
Positioning the Range 1. When the range is fully assembled, recheck all electrical connections especially between the exhaust hood and the back of the range. As well, check that all nuts and bolts have been tightened. position. Installation RequirementsModels 4200/4210 (page 2 of 2) Due to continuing product improvements, AGA Marvel reserves the right to amend specifica- Put both hands on the trim and carefully push the range into place. Make sure floor is clear of all debris. Don't forget to p
Resumen del contenido incluido en la página 10
Exhaust Hood Your range is equipped with a variable speed range hood that may be either vented directly to the outside, or in soapy water. Extras are available from your dealer or directly from Heartland Appliances Inc. Please order 4 Ventless Installation rivet in the closet. Figure 4 Exhaust venting options Installation of Ducting Installation through an outside wall the wall directly behind the range hood outlet (See Figure 4.), making sure no wall studs are cut. Push range into position
Resumen del contenido incluido en la página 11
Vented Installation, Tools, Material, and Dimensions Tools required to install vented hood: - Hammer - Slot screwdriver - Pliers - Electric drill - Measuring tape - 3/32” (3 mm) Drill bit - 1/2” (13 mm) Drill bit - Sabre saw OR Keyhole saw Materials Required: - 3 1/4" x 10" (82.55 mm x 254 mm) metal duct—enough to go through wall or attic to outside. Elbows as required. - Roof cap or wall venthood - Caulking to seal around duct - #6 x 1/2” (82.55 mm x 254 mm) sheet metal scre
Resumen del contenido incluido en la página 12
Important Safety Instructions 1. PROPER INSTALLATION—BE SURE YOUR APPLIANCE IS PROPERLY INSTALLED AND GROUNDED BY A QUALIFIED TECHNICIAN. Have the installer show you the location of the circuit breaker or fuse. Mark it for future reference. 2. Never use your appliance for warming or heating the room. Use only for its intended use as described in this manual. 3. Do not leave children alone. Children should not be left alone or unattended in area where the appliance is in use. Children should
Resumen del contenido incluido en la página 13
Exhaust Hood Safety Caution: Do not store items of interest to children in closet above the range or on top of range closet. Children climbing on range to reach items could be seriously injured. 1. . 2. Warming Oven Safety Caution: Do not store items in the warming drawer, items stored there could be damaged if the warming control is turned on. Self Clean Safety Instructions Read the instructions below and the appropriate timer instructions before attempting to operate. Do
Resumen del contenido incluido en la página 14
Heartland H Heeaarrttllaan nd d Features Cooking Controls The cooking controls are located on the right hand side of the Control Panel for ease and accuracy in cooking and baking. Sealed Burner Features A) Centre Burners - are two maximum 8,000 BTU (2.34 kW) (L/P 7,000BTU)with simmer of 600 BTU (.2 kW) sealed gas burners ,easy clean, for medium duty cooking tasks. B) Left Burners - front sealed burner is maximum 10,000 BTU (2.93 kW) )(L/P 9,000BTU) with simmer of 1000 BTU (.3 B kW) and
Resumen del contenido incluido en la página 15
Warming Drawer Features H) Located under the main oven, glides open for easy access. - sliding humidity control - large 1 cubic foot warming area I) Thermostatic temperature control, located just right and behind the warming drawer. Storage Features (48" models only) - Rack storage area: ideal for oven racks and baking trays. - Utensil drawer: Unique storage space, keeping necessities within easy access. Control Panel A U T O TIMER J STOP K L M Please Note:
Resumen del contenido incluido en la página 16
6 6 6 6 6 6 6 6 6 6 0 0 3 0 3 0 3 0 3 0 3 3 0 0 3 3 0 3 0 3 2 2 2 2 2 2 2 2 2 2 Control Panel Layout graphic on the right side of the knob. Model 4210 Control Model 5210 Panel Control Panel Left Rear Burner Control - Medium Left Rear Burner Control - Medium Left Front Burner Control Right Rear Burner Control - Large - Medium Centre Rear Burner Control Left Front Burner Control - Medium - Large Centre Front Burner Control Right Front Burner Control - Medium - Medium 200 95 Right Rear Burner Con
Resumen del contenido incluido en la página 17
OPERATION Top Burner Operation Lighting the Top Burners Your range is equipped with a spark ignition system that is electrically operated. You need only to push in and turn the knob to any position and the burner will light. When you turn the knob, you will hear a distinct clicking noise. After the burner lights, the clicking noise will stop. Note: When lighting any one burner, all burners will spark, but only the burner that you have begins to spark to re-ignite the burner! See Page 12 fo
Resumen del contenido incluido en la página 18
Power Failure Operation If electrical power is interrupted in your area, you can still cook meals on the top burners of your Heartland gas /electric range. Of course your oven will be inoperable, however, by following these simple directions you will be able to use the top Caution: make sure your hands and clothing are clear of the burner you are lighting! Manually Lighting the Top Burners 1) Remove cast grate, for unobstructed access to the burner head. 3) Push in and turn the corresponding c
Resumen del contenido incluido en la página 19
Heartland Closed Heea arrttll n H a an p O en Warming Drawer Control and Operation drawer behind the drawer door. ranges from 130°F to 220°F. (54°C to 104°C). High When the control is in use the indicator will glow until the temperature level has been reached, then it will cycle on and off to maintain temperature. Warm rolls, breads, vegetables, meats etc. as well as plates on HIGH. The warming drawer also features a humidity control located along the top of the drawer door. When the Low
Resumen del contenido incluido en la página 20
Bake - Broil Control Warming drawer Main oven indicator light indicator light Oven Bake/ Broil Control Baking To bake, push down and turn the oven control counter clockwise to any desired temperature. When baking is selected, the indicator light under the bake symbol lights up, and the bake element will activate. The element will then cycle on and off to maintain an average temperature in the oven. Please note: - please allow oven to cycle on/off before placing food in oven. 290°C.) Broil
