Resumen del contenido incluido en la página 1
Resumen del contenido incluido en la página 2
MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS SAFETY PRECAUTIONS Before installing and operating this equipment, be sure everyone involved in its operation is fully trained and aware of precautions. Accidents and problems can be caused by failure to follow fundamental rules and precautions. The following symbols, found throughout this manual, alert you to potentially dangerous conditions to the operator, service personnel, or to the equipment. This symbol warns of immediate hazards which wil
Resumen del contenido incluido en la página 3
Resumen del contenido incluido en la página 4
SPECIFICATIONS MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS PAGE
Resumen del contenido incluido en la página 5
SPECIFICATIONS MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS SPECIFICATIONS GAS SUPPLY The serial plate is located inside the lower front panel. It indicates the type of gas the unit is equipped to burn. All Southbend equipment is adjusted at the factory. Check type of gas on serial plate. These models are design-certified for operation on natural or propane gases. For natural gas, the regulator is set to deliver a 4.5" W.C. pressure to the manifold. For propane gas, it is set to deliver 11"
Resumen del contenido incluido en la página 6
SPECIFICATIONS MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS EXTERIOR DIMENSIONS Single-Deck Ovens A B 8" 2.5" 18.625" 4" 38" 13.5" 2.5" 1.25" C TOP VIEW 29" 57.5" 55" 42.875" 33" 29.25" 26" SIDE VIEW FRONT VIEW Model Depth Dimensions Oven Interior Rack Clearance Shipping Crate Number A B C width depth height width depth width depth height volume weight GS/1… 38.5" 30" 34.375" 29" 22.5" 20" 28.25" 22" 55" 45.5" 45" 65.17 cu. ft. 620 lbs. SLGS/1… GB1… 45" 36.375" 40.75" 29" 28" 20" 28.25" 27.
Resumen del contenido incluido en la página 7
SPECIFICATIONS MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS SPECIFICATIONS Double-Deck Ovens A B 8" 2.5" 18.625" 4" 38" 13.5" 2.5" 1.25" C TOP VIEW 29" 66.5" 64" 38.25" 29" 42" 22.875" 13" 9.5" 6" SIDE VIEW FRONT VIEW Model Depth Dimensions Oven Interior Rack Clearance Shipping Crate Number A B C width depth height width depth width depth height volume weight GS/2… 1040 lbs. 38.75" 30" 34.375" 29" 22.5" 20" 28.25" 22" 55" 45.5" 81.5" 118 cu. ft. SLGS/2… GS/2… 45.125" 36.375" 40.75" 29" 29"
Resumen del contenido incluido en la página 8
SPECIFICATIONS MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS MINIMUM CLEARANCES ! WARNING There must be adequate clearance between the left side of the ovens and combustible construction. Minimum Clearance from Minimum Clearance from Combustible Construction Non-Combustible Construction Back 0" 0" Right Side 0" 0" Left Side 2" 0" Floor 0" 0" Adequate clearance must be provided in the aisle to allow the doors to open sufficiently to permit the removal of the racks and for serviceability. Al
Resumen del contenido incluido en la página 9
INSTALLATION MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS INSTALLATION INSTALLATION NOTICE These installation procedures must be followed by qualified personnel or warranty will be void. Local codes regarding installation vary greatly from one area to another. The National Fire Protection Association, Inc. states in its NFPA 96 latest edition that local codes are the “authority having jurisdiction” when it comes to installation requirements for equipment. Therefore, installations should com
Resumen del contenido incluido en la página 10
Resumen del contenido incluido en la página 11
INSTALLATION MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS INSTALLATION Step 2b: Installation of Legs on Single-Deck, Marathoner Gold Models 1. Raise oven sufficiently to allow clearance for the legs to be attached. Use of a lift truck or other mechanical lifting means is recommended. For safety, “shore up” and support the oven with an adequate blocking arrangement strong enough to support the load. (If it is absolutely necessary to rest the oven on its side, rest it on its left side or back
Resumen del contenido incluido en la página 12
Resumen del contenido incluido en la página 13
INSTALLATION MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS INSTALLATION Step 3: Installation of Restraint (Only for Ovens with Casters) NOTICE For an appliance equipped with casters, (1) the installation shall be made with a connector that complies with the Standard for Connectors for Movable Gas Appliances, ANSI Z21.69 or Connectors for Moveable Gas Appliances, CAN/CGA-6.16, and a quick-disconnect device that complies with the Standard for Quick-Disconnect Devices for Use With Gas Fuel, ANS
Resumen del contenido incluido en la página 14
Resumen del contenido incluido en la página 15
Resumen del contenido incluido en la página 16
Resumen del contenido incluido en la página 17
Resumen del contenido incluido en la página 18
INSTALLATION MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS Step 5: Install Down Draft Diverter (if applicable) NOTICE Installation must use approved CSA International down draft diverter supplied by Southbend. If the oven flue is to be connected directly to an external vent, a down draft diverter must be installed. The installation of ventilation pipes through walls and roofs must conform to all local codes. To install the down draft diverter, do the following: 1. Slip the down draft diverte
Resumen del contenido incluido en la página 19
INSTALLATION MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS INSTALLATION Step 6: Installation of Optional Open Rack Storage An option for single-deck Marathoner Gold ovens is to have open rack storage below the oven. The following describes how to assemble this option. All holes are pre-drilled for the screws provided. 1. Attach the legs to the oven as described in installation Step 2b on page 11. 2. Attach the two frame hangers (items “A” in the following drawing). The flanged side of each r
Resumen del contenido incluido en la página 20
